maintenance schedule CHRYSLER PT CRUISER 2004 1.G Warranty Booklet

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
72,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-15-01 3N.
Maint enance Service Sc hedule ÒBÓ
72,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, PT Cruiser, SRT-4, and SX 2.0 only).
l Replace the engine air cleaner filter, if required (Pacifica, Minivan, Concorde, Intrepid,and 300M only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Adjust the drive belt tension (Concorde, Intrepid, and 300M only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only)
l Change the All Wheel Drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M, and SX 2.0 only).
l Inspect the brake hoses
l Check the automatic transaxle fluid level
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses, and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of
commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 59

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
96,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-20-01 3N.
Maint enance Service Sc hedule ÒBÓ
96,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Replace the engine air cleaner filter, if required (all models).
l Replace the ignition cables (PT Cruiser, SRT-4, Sebring, Sebring Convertible, SX 2.0, and 2.4L Minivan only).lReplace the spark plugs (PT Cruiser, SRT-4, Sebring, Sebring Convertible, SX 2.0, and 2.4L Minivan only).
l Check and replace, if necessary, the PCV valve.
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L/3.8L Minivan only).
l Replace drive belts (Concorde, Intrepid, and 300M only).
l Adjust the generator belt tension (PT Cruiser and SRT-4 only).
l Replace the drive belts (SX 2.0 only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Replace power steering fluid (Concorde, Intrepid, and 300M only).
l Change the all-wheel-drive power transfer unit fluid.*
l Change the automatic transaxle fluid and filter. **
l Replace the air conditioning filter (Pacifica and Minivan, if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Pacifica, Minivan, PT Cruiser, SRT-4, and SX 2.0 only).
l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser, and SRT-4 only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses, and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
** Change the automatic transmission fluid and filter every 96,000 km if the vehicle is used for trailer tow, taxi, police orother types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 69

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
10 1,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-21-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 0 1,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
lInspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M, and SX 2.0 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of
commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 71

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
120,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-25-01 3N.
Maint enance Service Sc hedule ÒBÓ
120,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, PT Cruiser, SRT-4, and SX 2.0 only).
l Replace the engine air cleaner filter, if required (Pacifica, Minivan, Concorde, Intrepid, and 300M only).
l Replace the ignition cables (3.3L and 3.8L Minivan only).
l Replace the spark plugs (Pacifica and 3.3L/3.8L Minivan only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L/3.8L Minivan only).
l Adjust the drive belt tension (Concorde, Intrepid, and 300M only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other
types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 79

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
134,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-28-01 3N.
Maint enance Service Sc hedule ÒBÓ
134,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
l Replace the air conditioning filter (Pacifica and Minivan, if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser, and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of
commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 85

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
144,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-30-01 3N.
Maint enance Service Sc hedule ÒBÓ
144,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Replace the engine air cleaner filter, if required (all models).
l Replace the spark plugs (PT Cruiser, SRT-4, Sebring, Sebring Convertible, SX 2.0, and 2.4L Minivan only).
l Check and replace, if necessary, the PCV valve.
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L /3.8L Minivan only).
l Adjust the drive belt tension (Concorde, Intrepid, and 300M only).
l Adjust the generator belt tension (PT Cruiser and SRT-4 only).
l Adjust the generator belt tension (SX 2.0 only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Replace the engine timing belt (SX 2.0, SRT-4, 2.4L Minivan, Sebring, Sebring Convertible, and PT Cruiser only).
l Change the all-wheel-drive power transfer unit fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Pacifica, Minivan, PT Cruiser, SRT-4, and SX 2.0 only).
l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M, and SX 2.0 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses, and clamps.
l Inspect the exhaust system.
*All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 89

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
168,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-35-01 3N.
Maint enance Service Sc hedule ÒBÓ
168,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, PT Cruiser, SRT-4, and SX 2.0 only).
l Replace the engine air cleaner filter, if required (Pacifica, Minivan, Concorde, Intrepid, and 300M only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L/3.8L Minivan only).
l Adjust the drive belt tension (Concorde, Intrepid, and 300M only).
l Check and retention accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Change the all-wheel drive power transfer unit fluid.*
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses, and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police
or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 99

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
192,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-40-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 92,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Replace the engine air cleaner filter, if required (all models).
lReplace the ignition cables (PT Cruiser, SRT-4, Sebring, Sebring Convertible, SX 2.0, and 2.4L Minivan only).l Replace the spark plugs (PT Cruiser, SRT-4, Sebring, Sebring Convertible, SX 2.0, and 2.4L Minivan only).
l Check and replace, if necessary, the PCV valve.
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L/3.8L Minivan only).lReplace drive belts (Concorde, Intrepid, and 300M only).
l Adjust the generator belt tension (PT Cruiser and SRT-4 only).
l Replace the drive belts (SX 2.0 only).lCheck and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Replace power steering fluid (Concorde, Intrepid, and 300M only).
l Change the all-wheel-drive power transfer unit fluid.
*lChange the automatic transaxle fluid and filter. **lReplace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Pacifica, Minivan, PT Cruiser, SRT-4, and SX 2.0 only).
l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser, and SRT-4 only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
*All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
**Change the manual transmission fluid and filter every 96,000 km if the vehicle is used for trailer tow, taxi, police orother types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 109

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
201,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-42-01 3N.
Maint enance Service Sc hedule ÒBÓ
20 1,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M, and SX 2.0 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police or other types of
commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 113

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
216,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-45-01 3N.
Maint enance Service Sc hedule ÒBÓ
216,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, PT Cruiser, SRT-4, and SX 2.0 only).
l Replace the engine air cleaner filter, if required (Pacifica, Minivan, Concorde, Intrepid, and 300M only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner(PT Cruiser and SX 2.0 only).
l Inspect the serpentine drive belt, replace if necessary (Pacifica and 3.3L/3.8L Minivan only).
l Adjust the drive belt tension (Concorde, Intrepid, and 300M only).
l Check and retention power steering pump belt (2.4L Minivan only).
l Check the generator belt, replace if necessary (2.4L Minivan only).
l Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M and SX 2.0 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is used for trailer tow, taxi, police
or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 119