differential CHRYSLER PT CRUISER 2004 1.G Warranty Booklet

8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first)
Vehicles placed in Police, Taxi, Limousine, Postal or Ambulance
service are excluded from the 7-year or 115,000-kilometrepowertrain warranty and are covered only under the 3-year or60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only. ¥
Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .
¥ Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
2004 Passenger Car, Minivan & Pacifica
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 8

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
77,000 km
Dealer copy.
Remove and attach to Repair Order 26-92-16-01 3N.
Maint enance Service Sc hedule ÒBÓ
77 ,000 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4 only). *
l Replace the differential fluid (Concorde, Intrepid and 300M only).
lChange the brake fluid if the vehicle is used for trailer towing (PT Cruiser and SRT-4 only).l Replace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT, and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 61

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible, Concorde, Intrepid, 300M,Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4 only). *
l Replace the differential fluid (Concorde, Intrepid and 300M only).
lChange the brake fluid if the vehicle is used for trailer towing(PT Cruiser and SRT-4 only).
l Replace the air conditioning filter (Pacifica and Minivan, if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT, and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is
used for trailer tow, taxi, police or other types of commercial service.
Maint enance Service Sc hedule ÒBÓ
77 ,000 km
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 62

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
154,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-32-01 3N.
Maint enance Service Sc hedule ÒBÓ
154,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4 only).*
l Replace the differential fluid (Concorde, Intrepid, and 300M only).
l Change the brake fluid if the vehicle is used for trailer towing (PT Cruiser and SRT-4 only).
l Replace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser, and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 93

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible, Concorde, Intrepid, 300M,Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4only).*
l Replace the differential fluid (Concorde, Intrepid, and 300Monly).
l Change the brake fluid if the vehicle is used for trailer towing (PT Cruiser and SRT-4 only).
l Replace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser, and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is used for trailer tow, taxi, police or other types of commercial service.Maint enance Service Sc hedule ÒBÓ
154,0 00 km
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 94

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
230,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-48-01 3N.
Maint enance Service Sc hedule ÒBÓ
230,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4 only). *
l Replace the differential fluid (Concorde, Intrepid, and 300M only).
l Change the brake fluid if the vehicle is used for trailer towing (PT Cruiser and SRT-4 only).
l Replace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all models).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 125

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible, Concorde, Intrepid, 300M,Pacifica, and Minivan only).
l Change the manual transaxle fluid. (PT Cruiser and SRT-4only). *
l Replace the differential fluid (Concorde, Intrepid, and 300Monly).
l Change the brake fluid if the vehicle is used for trailertowing (PT Cruiser and SRT-4 only).
l Replace the air conditioning filter (Pacifica and Minivan if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all models).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level fill plug condition (SX 2.0 only, if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* Change the manual transmission fluid and filter every 77,000 km if the vehicle is used for trailer tow, taxi, police or other types of commercial service.
Maint enance Service Sc hedule ÒBÓ
230,0 00 km
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 126