brake fluid CHRYSLER PT CRUISER 2005 1.G User Guide
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2005, Model line: PT CRUISER, Model: CHRYSLER PT CRUISER 2005 1.GPages: 368, PDF Size: 10.02 MB
Page 318 of 368
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transaxle and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transaxle fluid level.
•Check the manual transaxle fluid level and fill plug
condition.
•Check the coolant level, hoses, and clamps.
318 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 323 of 368
Miles 39,000 42,000 45,000 48,000 51,000 54,000
( Kilometers) (62 000) (67 000) (72 000) (77 000) (82 000) (86 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Rotate tires. X X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for
trailer towing.X
Inspect theengine air cleaner filter,replace as
necessary.*X
Change the manual transaxle fluid.† X
Inspect theMake-up air filter.Replace as nec-
essary.X
SCHEDULE “B”—ALL ENGINES 323
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 324 of 368
Miles 57,000 60,000 63,000 66,000 69,000 72,000
( Kilometers) (91 000) (96 000) (101 000) (106 000) (111 000) (115 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Rotate tires. X X X
Inspect the brake linings. X X
Replace theengine air cleaner filter.X
Replace thespark plugs and ignition cables.X
Inspect the tie rod ends and boot seals. X
Inspect thePCV valveand replace if neces-
sary. Not required if previously changed. * ‡X
Replace theMake-up air filter.X
Adjust the generator drive belt tension. X
Change the automatic transaxle fluid and fil-
ter.X
Flush and replace engine coolant at 60
months, if not done at 102,000 miles.X
324 SCHEDULE “B”—ALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 326 of 368
Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (150 000) (154 000) (159 000) (164 000) (168 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for trailer
towing.X
Inspect theengine air cleaner filterand replace as
necessary.*X
Change the manual transaxle fluid.† X
Flush and replace the engine coolant, if not replaced
at 60 months.X
Inspect theMake-up air filter,replace as necessary. X
326 SCHEDULE “B”—ALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 327 of 368
Miles 108,000 111,000 114,000 117,000 120,000
(Kilometers) (173 000) (178 000) (183 000) (188 000) (193 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X X
Inspect the brake linings. X
Replace theengine air cleaner filter.*X
Inspect the tie rod ends and boot seals. X
Replace theMake-up air filter.X
Adjust the generator drive belt tension. X
Change automatic transaxle fluid and filter.X
Inspect thePCV valve and replace if necessary.*‡ X
Flush and replace the engine coolant at 120 months,
if not replaced at 102,000 miles.X
Replace thespark plugs and ignition cables.X
SCHEDULE “B”—ALL ENGINES 327
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Page 350 of 368
ABS (Anti-Lock Brake) System.............. 212
Adding Engine Coolant (Antifreeze).......... 286
Adding Fuel........................... 239
Adding Washer Fluid..................... 192
Additives, Fuel......................... 237
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 276
Air Conditioner Maintenance............... 279
Air Conditioning Controls................. 183
Air Conditioning, Operating Tips............ 188
Air Conditioning Refrigerant.............279,280
Air Conditioning System................183,279
Air Pressure, Tires....................... 225
Airbag................................ 43
Airbag Deployment....................... 50
Airbag Light.....................47,52,62,142
Airbag Maintenance....................... 51
Airbag, Side............................ 49
Alarm, Panic............................ 23
Alarm System........................26,137Alignment and Balance................... 232
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 181
Antifreeze (Engine Coolant)...........285,311,312
Capacities........................... 311
Disposal............................ 287
Anti-Lock Brake System (ABS).............. 212
Anti-Lock Warning Light.................. 139
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 297
Auto Down Power Windows................ 32
Automatic Door Locks..................... 20
Automatic Transaxle..............12,196,199,293
Fluid and Filter Changes................. 295
Fluid Level Check...................... 294
Interlock System.....................18,200
Reset Mode.......................... 201
Selection Of Lubricant................... 293
Shifting............................. 201
350 INDEX
Page 351 of 368
Special Additives...................... 296
Autostick...........................143,204
Back-Up Lights......................... 310
Ball Joints............................. 280
Battery............................... 277
Keyless Transmitter Replacement............ 25
Belts, Drive............................ 273
Belts, Engine........................... 276
Body Mechanism Lubrication............... 281
B-Pillar Location........................ 220
Brake Fluid............................ 313
Brake, Parking.......................... 209
Brake System........................ 211,290
Anti-Lock........................... 212
Hoses.............................. 290
Master Cylinder....................... 291
Parking............................. 209
Warning Light........................ 140Brakes............................. 211,290
Brake/Transmission Interlock............... 200
Break-In Recommendations, New Vehicle........ 60
Bulb Replacement.....................306,308
Bulbs, Light............................ 306
Calibration, Compass..................... 114
Capacities, Antifreeze (Engine Coolant)........ 311
Capacities, Fluid........................ 311
Caps, Filler
Fuel................................ 239
Oil (Engine)....................264,265,272
Carbon Monoxide Warning................. 238
Cargo Compartment
Luggage Carrier....................... 126
Carrier, Luggage........................ 126
Cassette Tape and Player Maintenance......... 181
Cassette Tape Player................146,149,152
Catalytic Converter...................... 274
INDEX 351
10
Page 354 of 368
Emission Control System Maintenance......267,316
Engine............................264,265
Break-In Recommendations................ 60
Checking Oil Level..................... 269
Cooling............................. 284
Exhaust Gas Caution.................... 238
Fuel Requirements..................... 235
Jump Starting......................... 254
Oil ...........................269,311,312
Oil Change Interval.................... 270
Oil Filler Cap...................264,265,272
Oil Filter............................ 312
Oil Selection.......................... 272
Oil Synthetic......................... 272
Overheating.......................... 246
Temperature Gauge..................... 138
Timing Belt.......................... 276
Exhaust Gas Caution..............29,61,238,283
Exhaust System......................... 283Filler Location Fuel...................... 143
Filters
Air Cleaner.......................... 276
Engine Fuel.......................... 276
Engine Oil........................273,312
Flashers.............................. 246
Hazard Warning....................... 246
Flat Tire Stowage........................ 253
Flooded Engine Starting................... 197
Fluid, Brake........................... 313
Fluid Capacities......................... 311
Fluid Leaks............................. 62
Fluid Level Checks
Automatic Transaxle.................... 294
Fluids................................ 312
Fog Light Service........................ 309
Fog Lights...........................97,143
Folding Rear Seat........................ 87
Freeing A Stuck Vehicle................... 257
354 INDEX
Page 360 of 368
Parking Brake.......................... 209
Passing Light........................... 98
Pets.................................. 60
Phone, Cellular.......................... 70
Phone, Hands-Free....................... 70
Placard, Tire and Loading Information......... 221
Power
Distribution Center..................... 303
Door Locks........................... 19
Outlet.............................. 117
Steering..........................213,280
Steering, Checking..................... 280
Sunroof............................. 114
Windows............................. 31
Power Steering Fluid..................... 313
Pregnant Women and Seat Belts.............. 43
Preparation for Jacking.................... 250
Pretensioners
Seat Belts............................. 42Programmable Electronic Features.........106,110
Programming Transmitters............24,106,110
Radial Ply Tires......................... 228
Radio Broadcast Signals................... 144
Radio Operation...................146,163,183
Radio, Satellite.......................... 177
Radio (Sound Systems)...........146,152,163,169
Rear Liftgate............................ 28
Rear Seat, Folding......................87,88
Rear Seat Removal........................ 91
Rear Shelf Panel........................ 122
Rear Window........................... 32
Rear Window Defroster................... 190
Rear Window Features.................... 190
Rear Wiper/Washer...................... 191
Reclining Front Seats...................... 84
Recommended Fluids, Lubricants and Genuine
Parts............................... 312
360 INDEX