lights CHRYSLER PT CRUISER 2005 1.G Owner's Manual

Cleaning Headlights
Your vehicle has plastic headlights that are lighter and
less susceptible to stone breakage than glass headlights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with any commercial household-type glass cleaner.
Never use an abrasive type cleaner. Use caution whencleaning inside rear windows equipped with electric
defrosters. Do not use scrapers or other sharp instru-
ments which may scratch the elements.
Instrument Panel Cover
The instrument panel cover has a low glare surface which
minimizes reflections in the windshield. Do not use
protectants or other products which may cause undesir-
able reflections. Use soap and warm water to restore the
low glare surface.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in the vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content of abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
MAINTAINING YOUR VEHICLE 289
7

FUSE Amp/Color Items Fused
1 30 Amp/Pink Ignition Start
2 40 Amp/
GreenAnti-Lock Brake (ABS)
Pump
3 40 Amp/
GreenIgnition Run
4 30 Amp/Blue Heated Seats
5 40 Amp/
GreenRadiator Fan (Low Speed
Turbo only)
6 50 Amp/Red High Speed Radiator Fan
(Turbo Only)
7 30 Amp/Blue Anti-Lock Brake (ABS)
Solenoid
8 40 Amp/
GreenElectric Back Light (EBL)
9 40 Amp/
GreenPower Top10 40 Amp/
GreenIP Fuse Block
11 10 Amp/Red Air Conditioning (A/C)
12 15 Amp/Lt.
BlueStop Lights
13 20 Amp/
YellowFuel Pump/Auto Shut
Down (ASD)
14 15 Amp/Lt.
BlueHorn
15 20 Amp/
YellowElectronic Automatic
Transaxle (ETAX)
16
17 15 Amp/Lt.
BlueHi Beam
18 30 Amp/Blue Ignition Off Draw (IOD)
19 15 Amp/Lt.
BlueHazard Flasher
294 MAINTAINING YOUR VEHICLE

CAUTION!
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it shows a
problem in the circuit that must be corrected.
VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days you may want to take steps to preserve your battery.
You may:
•Disengage the mini fuse in the Power Distribution
Center labeled IOD (Ignition Off-Draw).
•Or, disconnect the negative cable from the battery.
REPLACEMENT BULBS
LIGHT BULBS—Inside Bulb No.
ABS Indicator.......................... LED
Airbag Indicator........................ LED
Brake System Warning Indicator............. LED
Center Console Floor Lamp................. T37
Climate Controls......................6233137
Console Gear Selector...................PC194
Cruise Indicator....................... VFD*
Deck Lid Ajar Indicator................... LED
Dome Light (Sport Bar Lights)..............T904
Door Ajar Indicator..................... VFD*
Front Fog Indicator...................... LED
High Beam Indicator....................... 74
Instrument Cluster Illumination.............. 74
Low Fuel Indicator....................... LED
Low Oil Pressure Indicator................. LED
Overhead Reading Light (Rearview Mirror).....T192
MAINTAINING YOUR VEHICLE 297
7

Rear Cargo............................T906
Seat Belt Indicator....................... LED
Security Alarm Indicator................... LED
Malfunction Indicator Light................ LED
Temperature Indicator.................... LED
Trac (Active) Indicator................... VFD*
TRAC OFF Indicator..................... LED
Trip Indicator......................... VFD*
Turn Signal Indicator...................... 103
Visor Vanity............................. 74
Voltage Indicator........................ LED
NOTE:* Vacuum Fluorescent Display
All the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved and should not
be used for replacement.LIGHTS BULBS—Outside Bulb No.
Low Beam Headlight...................9006XS
High Beam Headlight...................9005XS
Front Park/Turn Signal/Side Marker Light. 4157NAKX
Front Fog Light.........................9006
Center High Mounted Stop Light
(CHMSL).........................921–W16W
Rear Tail/Stop/Turn Signal Light......3157–P27/7W
Backup Light.....................3157-P27/7W
License Light........................... 168
298 MAINTAINING YOUR VEHICLE

Front Park/Turn Signal/Side Marker Lights
1. Remove the headlight access cover splash shield,
located in the front wheel well opening.
2. Rotate the socket to the left one quarter turn to replace
and replace the bulb.
Front Fog Lights—If Equipped
1. Remove the fasteners attaching the lower splash
shield to gain access to the fog light.
2. Twist and remove the bulb from the fog light housing.
3. Disconnect the electrical connector and replace bulb.
Tail/Stop, and Rear Turn Signal Lights
1. Remove the screw attaching the tail light housing and
remove the housing from the vehicle.
300 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transaxle and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transaxle fluid level.
•Check the manual transaxle fluid level and fill plug
condition.
•Check the coolant level, hoses, and clamps.
308 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Back-Up Lights......................... 301
Ball Joints............................. 268
Battery............................... 265
Keyless Transmitter Replacement............ 24
Belts, Drive............................ 261
Belts, Engine........................... 264
Body Mechanism Lubrication............... 269
Boot, Convertible Top...................68,72
B-Pillar Location........................ 206
Brake Fluid............................ 304
Brake, Parking.......................... 195
Brake System........................197,278
Anti-Lock........................... 198
Hoses.............................. 278
Master Cylinder....................... 279
Parking............................. 195
Warning Light........................ 130
Brakes.............................197,278
Brake/Transmission Interlock............... 186Break-In Recommendations, New Vehicle........ 56
Bulb Replacement.....................297,299
Bulbs, Light............................ 297
Calibration, Compass...................... 78
Capacities, Antifreeze (Engine Coolant)........ 302
Capacities, Fluid........................ 302
Caps, Filler
Fuel................................ 225
Oil (Engine)....................252,253,260
Radiator (Coolant Pressure)............... 275
Carbon Monoxide Warning................. 224
Cassette Tape and Player Maintenance......... 167
Cassette Tape Player................136,146,149
Catalytic Converter...................... 262
Caution, Exhaust Gas...................... 57
CD Changer......................145,151,157
CD Player..................142,153,155,159,162
CD Player Maintenance................... 168
INDEX 341
10

Emission Control System Maintenance......255,306
Engine............................252,253
Break-In Recommendations................ 56
Checking Oil Level..................... 257
Exhaust Gas Caution.................... 224
Fuel Requirements..................... 221
Jump Starting......................... 240
Oil ...........................257,302,303
Oil Change Interval.................... 258
Oil Filler Cap...................252,253,260
Oil Filter............................ 303
Oil Selection.......................... 260
Oil Synthetic......................... 260
Overheating.......................... 233
Temperature Gauge..................... 128
Timing Belt.......................... 264
Exhaust Gas Caution..............27,57,224,271
Exhaust System......................... 271Filler Location Fuel...................... 134
Filters
Air Cleaner.......................... 264
Engine Fuel.......................... 264
Engine Oil........................261,303
Flashers.............................. 232
Hazard Warning....................... 232
Flat Tire Stowage........................ 240
Flooded Engine Starting................... 183
Fluid, Brake........................... 304
Fluid Capacities......................... 302
Fluid Leaks............................. 58
Fluid Level Checks
Automatic Transaxle.................... 281
Fluids................................ 303
Fog Light Service........................ 300
Fog Lights...........................97,133
Folding Rear Seat........................ 87
Freeing A Stuck Vehicle................... 244
344 INDEX

Fuel..............................221,303
Adding............................. 225
Additives............................ 223
Capacity............................ 302
Clean Air............................ 222
Filler Cap.........................134,225
Filler Door........................... 134
Filter............................... 264
Gasoline............................ 221
Gauge.............................. 127
Hoses.............................. 277
Light............................... 133
Octane Rating........................ 221
Requirements......................... 221
System Hoses......................... 277
Tank Capacity........................ 302
Fueling............................... 225
Fuses................................ 292Garage Door Opener..................... 106
GasCap .............................. 225
Gasoline...........................221,302
Gasoline, Clean Air...................... 222
Gasoline, Reformulated................... 222
Gauges
Coolant Temperature.................... 128
Fuel................................ 127
Tachometer.......................... 129
Gearshift.............................. 187
General Information....................17,23
General Maintenance..................... 257
Glass Cleaning.......................... 289
Hazard Warning Flasher................... 232
Head Restraints.......................... 85
Headlights
Bulb Replacement...................... 299
Cleaning............................ 289
INDEX 345
10

High Beam.........................97,129
High Beam/Low Beam Select Switch......... 97
Passing.............................. 97
Switch............................... 96
Heated Seats............................ 86
Homelink Transmitter.................... 106
Hood Release........................... 93
Hoses................................ 277
Ignition............................... 12
Key ................................. 12
Wiring System........................ 262
Immobilizer..........................14,26
Indicator, Traction Control...............131,132
Infant Restraint.......................... 50
Inside Rearview Mirror.................... 75
Instrument Cluster....................124,127
Instrument Panel and Controls.............. 123
Instrument Panel Cover................... 289Instrument Panel Lens Cleaning............. 289
Integrated Power Module.................. 292
Interior Appearance Care.................. 288
Interior Fuses.......................... 295
Interior Lights........................... 94
Intermittent Wipers....................... 99
Introduction............................. 4
Jack Location........................... 235
Jack Operation.......................235,238
Jump Starting.......................... 240
Key, Programming........................ 16
Key Release Button....................... 13
Key, Replacement........................ 16
Key, Sentry............................. 14
Key-In Reminder......................... 14
Keyless Entry System...................... 21
Keys................................. 12
346 INDEX