radiator cap CHRYSLER PT CRUISER 2005 1.G Owners Manual

Jacking Instructions
1. Remove the scissors jack and lug wrench from the
stowage bag.
NOTE:If equipped with a center cap that covers the
wheel nuts, pry off the cap using the small end of the lug
wrench. To reinstall the cap, make sure it is properly
lined up before pushing it on to the wheel.
2. Loosen, but do not remove, the wheel nuts by turning
them to the left one turn while the wheel is still on the
ground.
CAUTION!
Do not attempt to raise the vehicle by jacking on the
crossmember below the radiator, on the front sus-
pension crossmember, or on the rear axle assembly.
3. There are two front jacking locations on each side of
the body and rear jacking locations located on the trailing
arm bracket under the triangular cut out symbol. Turn
the jack screw to the right until the jack head is properly
engaged with the lift area closest to the wheel to be
changed.
238 WHAT TO DO IN EMERGENCIES

Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at any time the ignition
switch is in the ON position.
•You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don’t open
the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator is hot.
Coolant Checks
Check engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
coolant.
Check the front of the radiator for an accumulation of
bugs, leaves, etc. Clean the radiator by gently spraying
water from a garden hose at the back of the core.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
272 MAINTAINING YOUR VEHICLE

With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the engine coolant (antifreeze) will begin to
drain from the coolant recovery bottle. DO NOT RE-
MOVE THE COOLANT PRESSURE CAP WHEN THE
COOLING SYSTEM IS HOT.
Cooling System—Drain, Flush and Refill
At the intervals shown on the Maintenance Schedules,
the system should be drained, flushed and refilled.
If the solution is dirty and contains a considerable
amount of sediment, clean and flush with a reliable
cooling system cleaner. Follow with a thorough rinsing to
remove all deposits and chemicals. Discard oil antifreeze
solution.
Selection Of Coolant
Use only the manufacturers recommended coolant, refer
to Recommended Fluids, Lubricants and Genuine Parts
for correct coolant type.
MAINTAINING YOUR VEHICLE 273
7

Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
The warning words“DO NOT OPEN HOT”on the
cooling system pressure cap are a safety precaution.
Never add coolant when the engine is overheated.
Do not loosen or remove the cap to cool an over-
heated engine. Heat causes pressure to build up in
the cooling system. To prevent scalding or injury, do
not remove the pressure cap while the system is hot
or under pressure.
Engine Coolant Disposal
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant recovery bottle provides a quick visual
method for determining that the coolant level is ad-
equate. With the engine idling, and warm to normal
operating temperature, the level of the coolant in the
bottle should be between the“FULL”and“ADD”marks.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
MAINTAINING YOUR VEHICLE 275
7

Back-Up Lights......................... 301
Ball Joints............................. 268
Battery............................... 265
Keyless Transmitter Replacement............ 24
Belts, Drive............................ 261
Belts, Engine........................... 264
Body Mechanism Lubrication............... 269
Boot, Convertible Top...................68,72
B-Pillar Location........................ 206
Brake Fluid............................ 304
Brake, Parking.......................... 195
Brake System........................197,278
Anti-Lock........................... 198
Hoses.............................. 278
Master Cylinder....................... 279
Parking............................. 195
Warning Light........................ 130
Brakes.............................197,278
Brake/Transmission Interlock............... 186Break-In Recommendations, New Vehicle........ 56
Bulb Replacement.....................297,299
Bulbs, Light............................ 297
Calibration, Compass...................... 78
Capacities, Antifreeze (Engine Coolant)........ 302
Capacities, Fluid........................ 302
Caps, Filler
Fuel................................ 225
Oil (Engine)....................252,253,260
Radiator (Coolant Pressure)............... 275
Carbon Monoxide Warning................. 224
Cassette Tape and Player Maintenance......... 167
Cassette Tape Player................136,146,149
Catalytic Converter...................... 262
Caution, Exhaust Gas...................... 57
CD Changer......................145,151,157
CD Player..................142,153,155,159,162
CD Player Maintenance................... 168
INDEX 341
10

Radiator Cap......................... 275
Selection of Coolant.................... 273
Corrosion Protection..................... 284
Crankcase Emission Control System.......... 264
Cruise Light........................... 132
Cup Holder............................ 115
Customer Assistance..................... 331
Dealer Service.......................... 256
Deck Lid.............................. 26
Deck Lid, Emergency Release................ 28
Deck Lid, Power Release................... 27
Defroster, Rear Window................... 176
Defroster, Windshield...................58,171
Delay (Intermittent) Wipers................. 99
Diagnostic System, Onboard................ 254
Dimmer Switch, Headlight.................. 97
Disposal
Engine Oil........................... 261Door Ajar............................. 131
Door Locks............................. 18
Door Locks, Automatic.................... 20
Door Opener, Garage..................... 106
Downshifting.......................... 194
Drive Belts............................ 261
Driving
On Slippery Surfaces.................... 243
Electric Rear Window Defrost............... 176
Electric Remote Mirrors.................... 79
Electrical Power Outlets................... 112
Electronic Power Distribution Center.......... 292
Electronic Speed Control................... 103
Emergency Deck Lid Release................ 28
Emergency, In Case of
Jacking............................. 235
Jump Starting......................... 240
Towing............................. 245
INDEX 343
10

Steering..........................199,268
Steering, Checking..................... 268
Windows............................. 28
Power Steering Fluid..................... 304
Pregnant Women and Seat Belts.............. 39
Pretensioners
Seat Belts............................. 39
Programmable Electronic Features.........107,111
Programming Transmitters............23,107,111
Radial Ply Tires......................... 214
Radiator Cap (Coolant Pressure Cap).......... 275
Radio Broadcast Signals................... 135
Radio Operation...................147,153,168
Radio (Sound Systems)...........136,146,153,159
Rear Seat, Folding......................87,88
Rear Window Defroster................... 176
Reclining Front Seats...................... 82Recommended Fluids, Lubricants and Genuine
Parts............................... 303
Refrigerant............................ 268
Remote Keyless Entry..................... 21
Replacement Bulbs....................... 297
Replacement Keys........................ 16
Replacement Parts....................... 256
Replacement Tires....................... 217
Reporting Safety Defects................... 335
Restraints, Child.......................49,54
Restraints, Infant......................... 50
Rotation, Tires.......................... 220
Safety Checks Inside Vehicle................. 57
Safety Checks Outside Vehicle............... 58
Safety Defects, Reporting.................. 335
Safety Information, Tire................... 201
Safety Tips............................. 57
Schedule, Maintenance.................... 306
350 INDEX