Cluster CHRYSLER PT CRUISER 2008 1.G Owner's Manual

The system is always in the “ON” mode unless:•
The TCS OFF switch has been used to turn the system
off;
•
There is a Anti-Lock Brake System malfunction;
•
There is a Traction Control System malfunction;
•
The system has been automatically deactivated to
prevent damage to the brake system due to overheated
brake temperatures.
NOTE: Extended heavy use of Traction Control may
cause the system to deactivate and turn on the TCS
indicator lamp located in the instrument cluster. This is to prevent overheating of the brake system and is
a normal condition. The system will remain disabled for
about 4 minutes until the brakes have cooled. The system
will automatically reactivate and turn off the TCS indi-
cator lamp.
If your vehicle becomes stuck in mud, ice, or snow, turn
the Traction Control System Off before attempting to
“rock” the vehicle free.
312 STARTING AND OPERATING

Tire Pressure Monitoring Low Pressure Warnings
The TPM Light will illuminate in the instrument
cluster and a chime will sound when tire pressure
is low in one or more of the four active road tires.
Should this occur, you should stop as soon as possible,
check the inflation pressure of each tire on your vehicle,
and inflate each tire to the vehicle’s recommended cold
placard pressure value. Once the system receives the
updated tire pressures, the system will automatically
update and the TPM Light will turn off. The vehicle may
need to be driven for up to 10 minutes above 15 mph (25
km/h) in order for the TPMS to receive this information.
Check TPMS WarningThe TPM Light will flash on and off for 75 seconds and
then remain on solid when a system fault is detected. The
system fault will also sound a chime. If the ignition key is
cycled, this sequence will repeat, providing the system fault still exists. The TPM Light will turn off when the
fault condition no longer exists. A system fault can occur
due to any of the following:
1. Signal interference due to electronic devices or driving
next to facilities emitting the same Radio Frequencies as
the TPM sensors.
2. Installing aftermarket window tinting that contains
materials which may block radio wave signals.
3. Excessive accumulation of snow or ice around the
wheels or wheel housings.
4. Using tire chains on the vehicle.
5. Using wheels/tires not equipped with TPM sensors.
NOTE:
1. The compact spare tire (if so equipped) does not have
a tire pressure monitoring sensor. Therefore, the TPMS
will not monitor the pressure in the compact spare tire.
STARTING AND OPERATING 335
5

NOTE:•
Tighten the gas cap until you hear a “clicking” sound.
This is an indication that the gas cap is tightened
properly. The Malfunction Indicator Light in the in-
strument cluster may turn on if the gas cap is not
secured properly. Make sure that the gas cap is tight-
ened each time the vehicle is refueled.
•
When the fuel nozzle “clicks” or shuts off, the fuel
tank is full.
Loose Fuel Filler Cap MessageIf the vehicle diagnostic system determines that the fuel
filler cap is loose, improperly installed, or damaged, a
“gASCAP” message will be displayed in the Odometer/
Trip Odometer in the instrument cluster. Refer to “Instru-
ment Cluster Description” in Section 4 of this manual.
Tighten the fuel filler cap properly and press the
odometer/trip odometer reset button to turn the message
off. If the problem continues, the message will appear thenext time the vehicle is started. This might indicate a
damaged cap. If the problem is detected twice in a row,
the system will turn on the Malfunction Indicator Light
(MIL). Resolving the problem will turn the MIL light
off.Refer to “Onboard Diagnostic System — OBDII” in
Section 7 of this manual for more information.
VEHICLE LOADINGVehicle Loading Capacities
Front Seat Occupants
....................... 2
Rear Seat Occupants (sedan) .................. 3
Rear Seat Occupants (convertible) .............. 2
Luggage ....................... 115lbs(52kg)
Rated Vehicle Capacity (sedan) ....... 865lb(392 kg)
Rated Vehicle Capacity (convertible) . . . 715 lb (324 kg)
342 STARTING AND OPERATING

HAZARD WARNING FLASHER
The flasher switch is located on the instrument
panel, below the radio. Depress the switch and
both cluster indicators and all front and rear
directional signals will flash. Depress the
switch again to turn Hazard Warning Flashers off.
Do not use this emergency warning system when the
vehicle is in motion. Use it when your vehicle is disabled
and is creating a safety hazard for other motorists. If it is necessary to leave the vehicle to go for service, the
flasher system will continue to operate with the ignition
key removed and the vehicle locked.
NOTE:
With extended use, the flasher may wear down
your battery.
IF YOUR ENGINE OVERHEATSIn any of the following situations, you can reduce the
potential for overheating by taking the appropriate ac-
tion.•
On the highways — Slow down.
•
In city traffic — While stopped, put transaxle in
neutral, but do not increase engine idle speed.
If the pointer rises to the H(red) mark, the instrument
cluster will sound a chime. Pull over and stop the vehicle
with the engine at idle, when safe. Turn off the air
conditioning and wait until the pointer drops back into
Hazard Warning Switch
358 WHAT TO DO IN EMERGENCIES

Loose Fuel Filler Cap MessageAfter fuel is added, the vehicle diagnostic system can
determine if the fuel filler cap is loose, improperly
installed, or damaged. A gASCAP message will be dis-
played in the instrument cluster. Tighten the gas cap until
aclicking sound is heard. This is an indication that the
gas cap is properly tightened. Press the odometer reset
button to turn the message off. If the problem persists,
the message will appear the next time the vehicle is
started. This might indicate a damaged cap. If the prob-
lem is detected twice in a row, the system will turn on the
Malfunction Indicator Light (MIL). Resolving the prob-
lem will turn the MIL light off.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMSIn some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.
For states that require an Inspection and Mainte-
nance (I/M), this check verifies the Malfunction
Indicator Light (MIL) is functioning and is not on
when the engine is running, and that the OBD II system
is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system may notbe ready if your vehicle was recently
serviced, recently had a dead battery, or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
MAINTAINING YOUR VEHICLE 381
7

Cleaning Plastic Instrument Cluster LensesThe lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.Seat Belt MaintenanceDo not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Dry with a soft tissue.
CONVERTIBLE TOP CAREImmediate removal of any contaminant is recommended.
Regular washing of the top will enhance its life and
appearance, and make successive cleanings easier. Do not
subject the top to excessive heat. Frequently vacuum the
top and storage compartment.WashingHand washing is highly recommended. Automatic car
washing equipment can damage the top material. If you
must use an automatic car wash, soft cloth systems are
preferred.
416 MAINTAINING YOUR VEHICLE

REPLACEMENT BULBSLIGHT BULBS — InsideBulb No.
Center Console Floor Lamp ................. T37
Climate Controls ...................... 6233137
Console Gear Selector ................... PC194
Dome Light (sedan) ...................... T579
Dome Light / Sport Bar Lights (convertible) ....T904
Instrument Cluster Illumination .............. 74
Overhead Reading Light (Overhead Console) . . . T1037
Overhead Reading Light (Rearview Mirror) .....T192
Rear Cargo ............................ T906
Visor Vanity ......................... 6501966
All the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved and should not
be used for replacement. LIGHTS BULBS — Outside
Bulb No.
Low Beam Headlight ................... 9006XS
High Beam Headlight ................... 9005XS
Front Park/Turn Signal/Side Marker
Light ............................ 4157NAKX
Front Fog Light ......................... 9145
Center High Mounted Stop Light
(CHMSL) (Sedan) ................... 921–W16W
Center High Mounted Stop Light
(CHMSL) (Convertible) .................... LED
Rear Tail/Stop .......................... 3157
Rear Turn Signal ....................... 3757A
Backup Light ..................... 3157-P27/7W
License Light ........................... 168424 MAINTAINING YOUR VEHICLE

HeadlightsBulb Replacement ...................... 425
Cleaning ............................ 415
High Beam ........................ 189,234
High Beam/Low Beam Select Switch ........ 189
Passing ............................. 190
Switch .............................. 186
Heated Seats ........................... 169
Hitches Trailer Towing ........................ 345
HomeLink (Garage Door Opener) Transmitter . . . 197
Hood Release .......................... 183
Hoses ............................. 403,404
Ignition ............................... 13
Key ................................. 13
Wiring System (Spark Plug Wires) .......... 388
Ignition Key Removal ..................... 13
Immobilizer (Sentry Key) .................15,37Infant Restraint
....................... 73,107
Information Center, Vehicle ................. 240
Inside Rearview Mirror ................... 135
Instrument Cluster .................... 223,226
Instrument Panel and Controls .............. 222
Instrument Panel Cover ................413,415
Instrument Panel Lens Cleaning ............. 416
Integrated Power Module (Fuses) ............ 419
Interior Appearance Care .................. 413
Intermittent Wipers (Delay Wipers) ........... 192
Introduction ............................. 4
Jack Location ........................... 361
Jack Operation ....................... 360,363
Jacking Instructions ...................... 363
Jump Starting .......................... 367
Key, Programming ........................ 17
Key, Replacement ........................ 16
INDEX 477
10

Key, Sentry (Immobilizer)................... 15
Key-In Reminder ......................... 15
Keyless Entry System (Convertible) ............ 30
Keyless Entry System (Sedan) ................ 24
Keys ................................. 13
Lane Change and Turn Signals .............. 230
Lap/Shoulder Belts ..................... 45,82
Latches Hood ............................... 183
Lead Free Gasoline ...................... 337
Life of Tires ............................ 327
Liftgate (Sedan) .......................... 37
Light Bulbs ......................... 424,425
Lights ............................. 1 17,184
Airbag ...................... 70,104,116,234
Anti-Lock ........................... 233
Back-Up ............................. 427
Brake Warning ........................ 231 Center Mounted Stop
................... 428
Daytime Running ...................... 187
Dimmer Switch, Headlight ............... 186
Engine Temperature Warning .............. 232
Fog .......................... 188,233,426
Front Replacement ..................... 425
Headlight Switch ...................... 186
Headlights ........................... 186
High Beam Indicator .................... 234
Instrument Cluster ..................... 186
Lights On Reminder .................... 187
Low Fuel ............................ 233
Malfunction Indicator (Check Engine) ........ 229
Map Reading ...................... 184,185
Oil Pressure .......................... 234
Rear Servicing ........................ 427
Seat Belt Reminder ..................... 232
Security Alarm (Theft Alarm) .............. 36
Service .............................. 425478 INDEX

Theft Alarm (Security Alarm).............. 233
Tire Pressure Monitoring (TPMS) ........... 332
Traction Control ....................... 312
Turn Signal .................. 186,189,230,426
Voltage ............................. 230
Warning (Instrument Cluster Description) ..... 226
Loading Vehicle ......................... 342
Tires ............................... 317
Locks Child Protection ........................ 22
Door ................................ 19
Power Door ........................... 20
Steering Wheel ......................... 18
Low Tire Pressure System .................. 332
Lubrication, Body ....................... 395
Luggage Rack (Roof Rack) ................. 215
Lumbar Support ........................ 166
Maintenance Free Battery .................. 392 Maintenance, General
..................... 384
Maintenance Procedures ................... 384
Maintenance Schedule Schedule “A”-Non Turbo ................. 448
Schedule “A”-Turbo .................... 453
Schedule “B” ......................... 437
Schedule “B”-All Engines ................ 437
Maintenance Schedules .................... 434
Malfunction Indicator Light (Check Engine) . . 229,381
Manual Override, Convertible Top .........134,373
Manual, Service ......................... 465
Manual Transaxle .................. 292,301,410
Downshifting ......................... 304
Fluid Level Check ...................... 410
Frequency of Fluid Change ............... 410
Lubricant Selection ..................... 410
Map/Reading Lights .................. 184,185
Master Cylinder (Brakes) .................. 406
Methanol ............................. 337
INDEX 479
10