cooling CHRYSLER PT CRUISER 2008 1.G User Guide

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
²The warning words ªDO NOT OPEN HOTº on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
²Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by humans and animals
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ethylene glycol engine coolant is ingested by
anyone, contact a physician immediately. Clean up any
ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine idling, and warm to normal operating tempera-
ture, the level of the coolant in the bottle should be
between the ranges indicated on the bottle.
MAINTAINING YOUR VEHICLE 401
7

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
²Do not overfill the coolant recovery bottle.
²Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
²If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
²Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
402 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)15 Gallons 56.7 Liters
Engine Oil-With Filter
2.4 Liter Engines (Use API Certified
SAE 5W-30 Engine Oil.)5.0 qts 4.7 Liters
Cooling System *
2.4 Liter Engines (Mopart
Antifreeze/Coolant 5 Year/100,000
Miles Formula), or equivalent.6.5 qts 6.2 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
MAINTAINING YOUR VEHICLE 429
7

Convertible Top Maintenance............... 416
Convertible Top Manual Override.........134,373
Cool Down, Turbo....................... 293
Coolant (Antifreeze)...................429,430
Coolant Pressure Cap (Radiator Cap).......... 400
Cooling System......................... 398
Adding Coolant (Antifreeze).............. 400
Coolant Level......................398,401
Disposal of Used Coolant................ 401
Drain, Flush, and Refill.................. 399
Inspection........................... 401
Points to Remember.................... 402
Pressure Cap......................... 400
Radiator Cap......................... 400
Selection of Coolant (Antifreeze)........... 399
Corrosion Protection...................... 411
Crankcase Emission Control System.......... 390
Cruise Light........................... 229
Cup Holder............................ 208Customer Assistance..................... 461
Data Recorder, Event...................70,105
Dealer Service.......................... 383
Deck Lid (Convertible)..................... 39
Deck Lid, Emergency Release Latch (Convertible) . . 41
Deck Lid, Power Release (Convertible)......... 39
Defroster, Rear Window................... 217
Defroster, Windshield.................. 116,279
Delay (Intermittent) Wipers................. 192
Diagnostic System, Onboard................ 380
Dimmer Switch, Headlight................. 189
Dipsticks
Automatic Transaxle.................... 408
Disposal
Antifreeze (Engine Coolant)............... 401
Engine Oil........................... 387
Door Locks............................. 19
Door Locks, Automatic.................... 21
INDEX 473
10

Door Opener, Garage..................... 197
Downshifting.......................... 304
Drive Belts............................ 388
Driver's Seat Back Tilt.................... 167
Driving
On Slippery Surfaces.................... 369
Electric Rear Window Defrost............... 217
Electric Remote Mirrors................... 137
Electrical Power Outlets................... 206
Electronic Speed Control (Cruise Control)...... 194
Electronic Vehicle Information Center
(EVIC)..........................234,235,240
Emergency Deck Lid Release Latch (Convertible) . . 41
Emergency, In Case of
Jacking............................. 360
Jump Starting......................... 367
Towing............................. 371
Emergency Seat Back Release (Sedan).......... 40Emission Control System Maintenance......381,434
Engine.......................... 115,378,379
Break-In Recommendations............... 115
Checking Oil Level..................... 384
Coolant (Antifreeze).................... 398
Cooling............................. 398
Exhaust Gas Caution.................... 339
Fuel Requirements..................... 337
Jump Starting......................... 367
Oil ...........................384,429,430
Oil Change Interval.................... 385
Oil Filler Cap...................378,379,387
Oil Filter............................ 430
Oil Selection.......................... 386
Oil Synthetic......................... 387
Operation............................ 115
Overheating.......................... 358
Temperature Gauge..................... 226
Timing Belt.......................... 390
474 INDEX

Ethanol............................... 337
Event Data Recorder...................70,105
Exhaust Gas Caution............38,39,115,339,397
Exhaust System......................... 397
Fabric Care.........................413,414
Filler Location Fuel....................226,340
Filters
Air Cleaner.......................... 391
Automatic Transaxle.................... 409
Engine Fuel.......................... 391
Engine Oil........................387,430
Flashers.............................. 358
Hazard Warning....................... 358
Flat Tire Stowage........................ 367
Flooded Engine Starting................... 293
Fluid, Brake........................... 431
Fluid Capacities......................... 429
Fluid Leaks............................ 117Fluid Level Checks
Automatic Transaxle.................... 408
Brake............................... 406
Cooling System....................... 398
Power Steering........................ 394
Fluids................................ 430
Fluids, Lubricants and Genuine Parts.......... 430
Fog Light Service........................ 426
Fog Lights..........................188,233
Folding Front Passenger Seat............... 167
Folding Rear Seat.....................171,173
Folding Rear Seat (Convertible).............. 173
Folding Rear Seat (Sedan).................. 171
Freeing A Stuck Vehicle................... 370
Fuel..............................337,430
Adding............................. 340
Additives............................ 338
Capacity............................ 429
Clean Air............................ 337
INDEX 475
10

Trailer Towing.......................... 343
Cooling System Tips.................... 355
Hitches............................. 345
Minimum Requirements................. 349
Trailer and Tongue Weight................ 348
Wiring.............................. 353
Trailer Towing Guide..................... 347
Trailer Weight.......................... 347
Transaxle............................. 294
Additives............................ 410
Automatic....................13,291,294,408
Autostick............................ 299
Filter............................... 409
Maintenance.......................... 408
Manual........................14,292,301
Operation........................... 294
Overdrive........................... 298
Transmission
Range Indicator....................... 227Transmitter Battery Service (Remote Keyless
Entry)...............................29,35
Transmitter, Garage Door Opener (HomeLinkt) . . 197
Transmitter Programming (Remote Keyless
Entry)...............................27,33
Transporting Pets......................80,114
Tread Wear Indicators.................... 327
Trip Computer.......................... 235
Trip Odometer.......................... 229
Trip Odometer Reset Button................ 230
Trunk Lid, Deck Lid (Convertible)............. 39
Tumbling Rear Seat (Convertible)............ 177
Tumbling Rear Seat (Sedan)................ 175
Turbo Cool Down....................... 293
Turn Signals.........................189,230
UConnectŸ (Hands-Free Phone)............. 138
Understanding Your Instrument Panel......... 222
Uniform Tire Quality Grades................ 467
486 INDEX

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE A WORD ABOUT YOUR KEYS
IGNITION KEY REMOVALLOCKING DOORS WITH A KEYKEY-IN-IGNITION REMINDERSENTRY KEY - IF EQUIPPED Replacement KeysSentry Key ProgrammingGeneral InformationSTEERING WHEEL LOCK - IF EQUIPPED If You Wish To Manually Lock The Steering
WheelTo Release The Steering Wheel LockAutomatic Transaxle Ignition Interlock SystemDOOR LOCKS MANUAL DOOR LOCKSPOWER DOOR LOCKS - IF EQUIPPEDCHILD PROTECTION DOOR LOCK SYSTEM - IF EQUIPPEDREMOTE KEYLESS ENTRY (SEDAN)
TO UNLOCK THE DOORS AND LIFTGATETO LOCK THE DOORS AND LIFTGATE - IF EQUIPPED WITH POWER OPTIONSPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERSGENERAL INFORMATION
TRANSMITTER BATTERY SERVICEREMOTE KEYLESS ENTRY (CONVERTIBLE) TO UNLOCK THE DOORSTO LOCK THE DOORSTO UNLATCH THE DECK LIDPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERS
GENERAL INFORMATIONTRANSMITTER BATTERY SERVICESECURITY ALARM SYSTEM - IF EQUIPPED To set the alarmTo disarm the systemSecurity System Manual OverrideLIFTGATE (SEDAN) Opening The Liftgate While the Security Alarm Is ActivatedDECK LID
(CONVERTIBLE) POWER DECK LID RELEASE (Convertible)EMERGENCY SEAT BACK RELEASE (SEDAN) EMERGENCY DECK LID RELEASE LATCH (CONVERTIBLE) POWER WINDOWS AUTO DOWN FEATUREREAR WINDOW SWITCHESWIND BUFFETING
OCCUPANT RESTRAINTS (SEDAN) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT UNTWISTING PROCEDUREADJUSTABLE UPPER SHOULDER SEAT BELT ANCHORAGESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM
(BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIRBAGCHILD RESTRAINTOCCUPANT RESTRAINTS (CONVERTIBLE) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT
UNTWISTING PROCEDURESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM (BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS)CHILD RESTRAINT
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Exhaust GasSafety Checks You Should Make Inside The VehiclePeriodic Safety Checks You Should Make Outside The VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE CONVERTIBLE TOP
OPERATION To Lower The TopTo Raise The TopConvertible Top Boot Cover Installation-If EquippedConvertible Top Boot Cover Removal and StorageCONVERTIBLE TOP MANUAL OVERRIDEMIRRORS Inside Day/Night Mirror - If EquippedOutside Mirror-Drivers Side
Outside Mirror-Passengers SideElectric Remote-Control Mirrors - If EquippedIlluminated Vanity Mirrors - If EquippedSun Visor Sliding FeatureHANDS-FREE COMMUNICATION (UConnect) - IF EQUIPPED OperationsPhone Call FeaturesUConnect System Features
Advanced Phone ConnectivityThings You Should Know About Your UConnect SystemGeneral InformationSEATS FRONT SEAT ADJUSTMENTPOWER SEAT ADJUSTER -IF EQUIPPEDMANUAL LUMBAR - IF EQUIPPEDFOLDING FRONT PASSENGER SEAT - IF
EQUIPPEDDRIVERS SEAT BACK TILT - IF EQUIPPEDPASSENGER SEAT BACK TILT (EASY ENTRY SYSTEM) - CONVERTIBLEADJUSTABLE HEAD RESTRAINTSHEATED SEATS - IF EQUIPPEDFOLDING REAR SEAT (SEDAN)FOLDING REAR SEAT
(CONVERTIBLE)TUMBLING REAR SEAT (SEDAN)TUMBLING REAR SEAT (CONVERTIBLE)REAR SEAT REMOVAL (SEDAN)TO OPEN AND CLOSE THE HOOD LIGHTS Map/Reading Lights (Sedan)Map/Reading Lights (Convertible)Multi-Function Control Lever
Headlights, Parking Lights, Instrument Panel LightsDaytime Running Lights (DRL) - If EquippedLights-on ReminderFog Lights - If Equipped Turn Signals Highbeam/Lowbeam Select Switch Passing LightWINDSHIELD WIPERS AND WASHERS Windshield WashersMist
Feature Windshield Wiper OperationIntermittent Wiper SystemTILT STEERING COLUMN ELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set At A Desired SpeedTo DeactivateTo Resume SpeedTo Vary The Speed SettingManual TransaxleTo Accelerate
For PassingGARAGE DOOR OPENER - IF EQUIPPED PROGRAMMING HOMELINKGATE OPERATOR/CANADIAN PROGRAMMINGUSING HOMELINKREPROGRAMMING A SINGLE HOMELINK BUTTONSECURITYTROUBLESHOOTING TIPSGENERAL
INFORMATIONPOWER SUNROOF (SEDAN ONLY) - IF EQUIPPED Express Open FeatureWind BuffetingSunroof MaintenanceELECTRICAL POWER OUTLETS Electrical Outlet Use With Engine OffCONSOLE FEATURES STORAGE Center Console/Armrest Storage
Bin Storage PocketsREAR SHELF PANEL- IF EQUIPPED Position 1 (Top)Position 2 (Middle)Position 3 (Floor)Position 4 (Vertical)Position 5 (table)ROOF LUGGAGE RACK - IF EQUIPPED REAR WINDOW FEATURES Electric Rear Window Defroster Rear Wiper/Washer
Switch (Sedan Models Only) - If EquippedAdding Washer FluidUNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES INSTRUMENT CLUSTER-BASE INSTRUMENT CLUSTER-PREMIUM INSTRUMENT CLUSTER-TURBO INSTRUMENT
CLUSTER DESCRIPTIONS COMPASS MINI TRIP COMPUTER (CMTC) - IF EQUIPPED Compass Mini Trip Computer Reset ButtonCompass/Temperature DisplayOdometerDisplayTrip Odometer (ODO)ELECTRONIC VEHICLE INFORMATION CENTER (EVIC) - If
Equipped EVIC Functions Compass/Temperature/AudioAverage Fuel EconomyDistance To Empty (DTE)Elapsed TimeTire Pressure Monitor (TPM)PersonalSettings (Customer Programmable Features)SETTING THE ANALOG CLOCK RADIO GENERAL INFORMATION
Radio Broadcast SignalsTwo Types of SignalsElectrical DisturbancesAM ReceptionFM ReceptionSALES CODE REF - AM/FM/CD (SINGLE DISC) RADIO WITH OPTIONAL SATELLITE RADIO AND HANDS FREE PHONE CAPABILITY Operating Instructions - Radio Mode
Operating Instructions - CD ModeOperating Instructions - Auxiliary ModeOperating Instructions - Hands-Free Phone - If EquippedOperating Instructions - Satellite Radio - If EquippedSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL SATELLITE RADIO,
HANDS-FREE PHONE, AND VIDEO ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperating Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperating
Instructions - (CD Mode for MP3 Audio Play)LOAD/EJECT Button (CD Mode for MP3 Play)SATELLITE RADIO - IF EQUIPPED System ActivationElectronic SerialNumber/Sirius Identification Number (ESN/SID)Selecting Satellite Mode in REF, and RAQ, RadiosSelecting
a ChannelStoring and Selecting Pre-Set ChannelsUsing the PTY (Program Type) Button (if equipped)PTY Button SCANPTY Button SEEKSatellite AntennaReception QualityCD/DVD DISC MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE
CONTROLS Climate ControlsOperating Tips STARTING AND OPERATING STARTING PROCEDURES AUTOMATIC TRANSAXLEMANUAL TRANSAXLENORMAL STARTINGEXTREMELY COLD WEATHER (BELOW -20 degrees F or -29 degrees C)IF THE ENGINE FAILS
TO STARTAFTER STARTINGTURBOCHARGER COOL-DOWN AUTOMATIC TRANSAXLE - IF EQUIPPED BRAKE/TRANSMISSION INTERLOCK SYSTEMAUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEMFOUR-SPEED AUTOMATIC TRANSAXLERESET
MODEGEAR RANGES FOR THE FOUR-SPEED AUTOMATIC TRANSAXLEAUTOSTICK - IF EQUIPPED AUTOSTICK OperationAUTOSTICK General InformationMANUAL TRANSAXLE OPERATION - IF EQUIPPED 2.4 LITER TURBO - IF EQUIPPED MANUAL
TRANSAXLE - RECOMMENDED SHIFT SPEEDSDownshiftingPARKING BRAKE BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (ABS) - IF EQUIPPEDPOWER STEERING TRACTION CONTROL SYSTEM - IF EQUIPPED TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresRadial Ply TiresCompact Spare Tire - If EquippedLimited-Use Spare - If EquippedTire SpinningTread Wear IndicatorsLife of Tire
Replacement TiresAlignment and BalanceTIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED BASESYSTEM - IF EQUIPPEDGENERAL INFORMATIONFUEL REQUIREMENTS -
GASOLINE ENGINES 2.4L AND 2.4L STANDARD TURBO ENGINESREFORMULATED GASOLINEGASOLINE/OXYGENATE BLENDSMMT IN GASOLINEMATERIALS ADDED TO FUELFUELSYSTEM CAUTIONSCARBON MONOXIDE WARNINGSADDING FUEL Fuel
Filler Cap (Gas Cap)Loose Fuel Filler Cap MessageVEHICLE LOADING TRAILER TOWING COMMON TOWING DEFINITIONSTRAILER HITCH CLASSIFICATIONTRAILER TOWING WEIGHTS (MAXIMUM TRAILER WEIGHT RATINGS)TRAILER AND TONGUE WEIGHT
TOWING REQUIREMENTSTOWING TIPSRECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Towing This Vehicle Behind Another Vehicle (Flat towing with all fourwheels on the ground)WHAT TO DO IN EMERGENCIES HAZARD WARNING FLASHER IF YOUR
ENGINE OVERHEATS JACKING AND TIRE CHANGING JACK LOCATIONSPARE TIRE STOWAGEPREPARATIONS FOR JACKINGJACKING INSTRUCTIONS JUMP-STARTING PROCEDURES DUE TO A LOW BATTERY DRIVING ON SLIPPERY SURFACES ACCELERATIONTRACTIONFREEING A STUCK VEHICLE TOWING A DISABLED VEHICLE With Ignition KeyWithout The Ignition KeyCONVERTIBLE TOP MANUAL OVERRIDE MAINTAINING YOUR VEHICLE 2.4L TURBO ENGINE COMPARTMENT 2.4L ENGINE
COMPARTMENT ONBOARD DIAGNOSTIC SYSTEM - OBD II Loose Fuel Filler Cap MessageEMISSIONS INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS AUTHORIZED DEALER SERVICE MAINTENANCE PROCEDURES ENGINE OILDRIVE
BELTS - CHECK CONDITION AND TENSIONSPARK PLUGSIGNITION WIRING SYSTEMCATALYTIC CONVERTERENGINE TIMING BELTCRANKCASE EMISSION CONTROL SYSTEMFUEL FILTERAIR CLEANER ELEMENT (AIR FILTER)MAINTENANCE-FREE
BATTERYAIR CONDITIONER MAINTENANCEPOWER STEERING - FLUID CHECKFRONT SUSPENSION BALL JOINTSSTEERING LINKAGEBODY LUBRICATIONWINDSHIELD WIPER BLADESWINDSHIELD WASHER RESERVOIREXHAUST SYSTEMCOOLING
SYSTEMHOSES AND VACUUM/VAPOR HARNESSESFUEL SYSTEM CONNECTIONSBRAKE SYSTEMAUTOMATIC TRANSAXLEMANUAL TRANSAXLEAPPEARANCE CARE AND PROTECTIONFROM CORROSIONCONVERTIBLE TOP CARE WashingGeneral
CleaningCloth Top Additional Cleaning ProcedureCloth Top ProtectionWeather Strip CareINTEGRATED POWER MODULE (IPM) VEHICLE STORAGE REPLACEMENT BULBS BULB REPLACEMENT HeadlightsFront Park/Turn Signal/Side Marker LightsFront Fog Lights
- If EquippedTail/Stop, and Rear Turn Signal LightsBack Up Lights Center High Mounted Stop LightFLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS ENGINECHASSISMAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM
MAINTENANCE MAINTENANCE SCHEDULE SCHEDULE B-ALL ENGINESSCHEDULE A-NON TURBOSCHEDULE A-TURBOIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For The Appointment
Prepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE DaimlerChrysler Motors Corporation Customer CenterDaimlerChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service
ContractWARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY
GRADES TreadwearTraction GradesTemperature GradesINDEX