wheel CHRYSLER SEBRING 2005 2.G Warranty Booklet

7
3/60 BASIC WARRANTY
If required because of a defect in material or workmanship, the 3/60
Basic Warranty will cover the adjustment, repair or replacement of
any factory-installed part of your vehicle except tires for 3 years or
60,000 kilometres , whichever occurs first. The following items are
exceptions; they are only covered (if defective) for 1 year or 20,000
kilometres , whichever occurs first:
• light bulbs and fuses
• wiper blades
• clutch discs
• brakes (rotors, pads, linings and drums)
• windshield and rear window
• wheel alignment and wheel balancing Tires are warranted by the tire manufacturers, not by
DaimlerChrysler. For details, see the tire manufacturer’s warranty
booklet in your glove box. Your DaimlerChrysler Dealer may be able
to assist you if you experience a problem with a factory-installed
tire.
Your Koss headphones are warranted by the manufacturer, not
by DaimlerChrysler. For details, see the Koss manufacturer’s
warranty card in your glove box.
3/60 BASIC WARRANTY
2005 Passenger Car • Minivan • Pacifica

8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres , whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in Police, Taxi, Limousine, Postal or Ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometre Powertrain Warranty and are covered only under
the 3-year or 60,000-kilometre Basic Warranty.
• Engine – Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only. •
Transmission – Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .
• Front-Wheel Drive – Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY
2005 Passenger Car • Minivan • Pacifica

2005 Passenger Car • Minivan • Pacifica
12
WHAT IS NOT COVERED
WHA
T IS NOT COVERED
DAMAGE FROMMISUSE ORACCIDENT
The warranties in this booklet do not cover repairs required due to
fire, accidents, abuse, negligence, objects striking your vehicle,
carrying corrosive materials (such as chemicals, acids and
fertilizers), misuse (such as driving over curbs, overloading,
spinning wheels, etc.), racing or participating in a racing event,
improper disconnection of components, modifying the exhaust
system, tampering or making adjustments which do not comply
with DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties.
D AMAGE FROMTHEENVIRONMENT
The warranties in this booklet do not cover fading or deterioration
caused by exposure to the elements, or repairs required due to
airborne fallout, acid rain, chemicals, tree sap, insects, bird or insec\
t
droppings, salt, sand, gravel, road hazards, hail, windstorms,
lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday
abrasion from sand and dirt can affect the appearance of a vehicle’s
wheels (steel, chrome and aluminum) and other undercarriage
parts. Some surface corrosion with use is normal; it is not a defect
and is not covered by any warranty.
N ORMAL MAINTENANCE ANDWEAR
The warranties in this booklet do not cover normal
maintenance services, such as oil and filter changes, general
lubrication, tire rotation, engine tune-ups and replacing spark
plugs. Required maintenance services are described in detail in
your Owner’s Manual and herein. The warranties also do not
cover light bulbs and fuses, worn wiper blades, clutch discs, brake
rotors, pads, linings or drums, windshield and rear window,
wheel alignment and wheel balancing (unless they are defective,
see page 7).

25
1.
POWER TRAIN PLANS*
Powertrain plans complement the factory powertrain warranty by
providing enhanced roadside coverage and car rental allowance if
your vehicle is not drivable and must be kept overnight. Certain
plans also provide additional distance coverage.
Major components covered are:
• engine • transmission • front-wheel drive • rear-wheel dri\
ve
• 4-wheel drive (4x4) • all-wheel-drive vehicles
2. “G OLD ” PLANS *
Each plan provides full mechanical repair protection to non-powertrain
(Gold) components. Certain plansalso provide full mechanical
protection against powertrain component repairs beyond your vehicle’s\
powertrain warranty coverage. Contracts are available with or without
a deductible.
Major components covered are:
• steering • air conditioning • engine cooling and fuel • fr\
ont
suspension • rear suspension • electrical • hydraulic brake
components • anti-lock brakes
* Maximum terms available on new vehicles registered in Canada only. 3.
“G OLD PLUS ” PLANS *
The most complete protection available for your new vehicle is one
of three “Gold Plus” Service Contracts which combines the benefits\
of “Gold” • Mechanical repair coverage for non-powertrain components
plus the most important vehicle maintenance functions • Engine oil and oil filter changes
plus • Tire rotation every other service
plus • “Peace-of-Mind” motoring with Tire Road Hazard
Protection which provides full, or pro-rata, replacement
of the original four tires, or their repair
plus • Rental car allowance for same-day warranty repairs –
your vehicle need not be kept overnight before eligibility
for the rental allowance is met.
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACTS
2005 Passenger Car • Minivan • Pacifica – October 1, 2004

2005 Passenger Car • Minivan • PacificaDealer Copy
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service
Sc hedule “B”
Odometer Reading
Date
24,0 00 km
Maint
enance Service Sc hedule “B”
24,0 00 km
Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and suspension componen\
ts.
Inspect the engine air cleaner filter and replace if necessary (Sebring\
, PT Cruiser, SRT-4
and SX 2.0 only).
Replace the engine air cleaner filter if required (Pacifica and Minivan\
only).
Inspect and replace, if required, the make-up air filter located inside \
the air cleaner
(PT Cruiser, SRT-4 and SX 2.0 only).
Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug condition
(SX 2.0, SRT-4 and PT Cruiser only, if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/re\
ar carrier
fluid must be changed at more frequent intervals than shown in schedule \
B if the
vehicle is used for trailer tow, taxi, or other type of commercial servi\
ce.

DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
2005 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and
suspension components.
Inspect the engine air cleaner filter and replace if
necessary (Sebring, PT Cruiser, SRT-4 and SX 2.0 only).
Replace the engine air cleaner filter if required
(Pacifica and Minivan only).
Inspect and replace, if required, the make-up air filter
located inside the air cleaner (PT Cruiser, SRT-4 and
SX 2.0 only).
Change the all-wheel-drive power transfer unit fluid.*
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug
condition (SX 2.0, SRT-4 and PT Cruiser only,
if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
or other type of commercial service.
Maint enance Service Sc hedule “B”
24,0 00 km

2005 Passenger Car • Minivan • PacificaDealer Copy
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service
Sc hedule “B”
Odometer Reading
Date
34,0 00 km
Maint
enance Service Sc hedule “B”
34,0 00 km
Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and suspension componen\
ts.
Inspect the engine air cleaner filter and replace if necessary (Sebring\
,
Pacifica and Minivan only).
Change the all-wheel-drive overrunning clutch and rear carrier fluid.*
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug condition
(SX 2.0, SRT-4 and PT Cruiser only, if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/re\
ar carrier fluid
must be changed at more frequent intervals than shown in schedule B if t\
he vehicle
is used for trailer tow, taxi, or other type of commercial service.

DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
2005 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and
suspension components.
Inspect the engine air cleaner filter and replace if
necessary (Sebring, Pacifica and Minivan only).
Change the all-wheel-drive overrunning clutch and
rear carrier fluid.*
INSPECT THE FOLLOWING:
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug
condition (SX 2.0, SRT-4 and PT Cruiser only,
if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning
clutch/rear carrier fluid must be changed at more frequent intervals
than shown in schedule B if the vehicle is used for trailer tow, taxi,
or other type of commercial service.
Maint enance Service Sc hedule “B”
34,0 00 km

2005 Passenger Car • Minivan • PacificaDealer Copy
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service
Sc hedule “B”
Odometer Reading
Date
48,0 00 km
Maint
enance Service Sc hedule “B”
48,0 00 km
Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and suspension componen\
ts.
Inspect the engine air cleaner filter and replace if necessary (Sebring\
, PT Cruiser,
SRT-4 and SX 2.0 only).
Replace the engine air cleaner filter if required (all models).
Replace the spark plugs (PT Cruiser, SRT-4, Sebring and SX 2.0 only).
Check and replace, if necessary, the PCV valve.
Inspect and replace, if required, the make-up air filter located inside \
the air cleaner
(PT Cruiser, SRT-4 and SX 2.0 only).
Adjust the generator belt tension (PT Cruiser, SX 2.0 and SRT-4 only).\
Inspect and adjust the power-steering pump belt tension (2.4L Sebring o\
nly).
Change the all-wheel-drive power transfer unit fluid.*
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
Inspect the tie rod ends and boot seals (Pacifica, Minivan, PT Cruiser,\
SRT-4
and SX 2.0 only).
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug condition (SX 2.0,\
SRT-4
and PT Cruiser only, if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/re\
ar carrier fluid
must be changed at more frequent intervals than shown in schedule B if t\
he vehicle
is used for trailer tow, taxi, or other type of commercial service.

DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
2005 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.
Change engine oil and engine oil filter (or every 3 months).
Inspect and lubricate, as required, all steering and suspension
components.
Inspect the engine air cleaner filter and replace if necessary
(Sebring, PT Cruiser, SRT-4 and SX 2.0 only).
Replace the engine air cleaner filter if required (all models).
Replace the spark plugs (PT Cruiser, SRT-4, Sebring
and SX 2.0 only).
Check and replace, if necessary, the PCV valve.
Inspect and replace, if required, the make-up air filter located
inside the air cleaner (PT Cruiser, SRT-4 and SX 2.0 only).
Adjust the generator belt tension (PT Cruiser, SX 2.0 and
SRT-4 only).
Inspect and adjust the power-steering pump belt tension
(2.4L Sebring only).
Change the all-wheel-drive power transfer unit fluid.*
Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
Inspect the tie rod ends and boot seals (Pacifica, Minivan,
PT Cruiser, SRT-4 and SX 2.0 only).
Inspect the brake hoses.
Check the automatic transaxle fluid level.
Check the manual transaxle fluid level and fill-plug condition
(SX 2.0, SRT-4 and PT Cruiser only, if equipped).
Check the coolant level, hoses and clamps.
Inspect the exhaust system.
*The all-wheel-drive power transfer unit fluid and overrunning clutch/re\
ar
carrier fluid must be changed at more frequent intervals than shown in
schedule B if the vehicle is used for trailer tow, taxi, or other type o\
f
commercial service.
Maint enance Service Sc hedule “B”
48,0 00 km