radiator cap CHRYSLER SEBRING 2010 3.G Owners Manual
[x] Cancel search | Manufacturer: CHRYSLER, Model Year: 2010, Model line: SEBRING, Model: CHRYSLER SEBRING 2010 3.GPages: 444, PDF Size: 7.84 MB
Page 323 of 444
NOTE:There are steps that you can take to slow down
an impending overheat condition:
•If your air conditioner (A/C) is on, turn it off. The A/C
system adds heat to the engine cooling system and
turning the A/C off can help remove this heat.
•You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
Engine Oil Overheating (2.4L Engine Only) —
If Equipped
During sustained high-speed driving or trailer tow up
long grades on a hot day, the engine oil temperature may
become too hot. If this happens, the “HOTOIL” message
flashes in the odometer and the vehicle speed will be
reduced to 53 mph (85 km/h) until the engine oil
temperature is reduced.
NOTE: The vehicle speed is reduced to a maximum of
53 mph (85 km/h). You may of course, reduce your
vehicle speed further if needed.
322 WHAT TO DO IN EMERGENCIES
Page 362 of 444
Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the LOCK position. The fan is tempera-
ture controlled and can start at anytime the igni-
tion switch is in the ON position.
•You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the
hood, do not open the hood until the radiator has
had time to cool. Never try to open a cooling
system pressure cap when the radiator is hot.
Coolant Checks
Check engine coolant (antifreeze) protection every
12 months (before the onset of freezing weather, where
applicable). If the engine coolant (antifreeze) is dirty orrusty in appearance, the system should be drained,
flushed, and refilled with fresh engine coolant (anti-
freeze). Check the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts, and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
Cooling System – Drain, Flush, and Refill
If the engine coolant (antifreeze) is dirty or contains a
considerable amount of sediment, clean and flush with a
reliable cooling system cleaner. Follow with a thorough
rinsing to remove all deposits and chemicals. Properly
dispose of the old engine coolant (antifreeze).
Refer to “Maintenance Schedule” for further information.
7
MAINTAINING YOUR VEHICLE 361
Page 364 of 444
replacement. To prevent reducing this extended mainte-
nance period, it is important that you use the same
engine coolant (antifreeze) throughout the life of your
vehicle.
Please review these recommendations for using Hybrid
Organic Additive Technology (HOAT) engine coolant
(antifreeze). When adding engine coolant (antifreeze):
•The manufacturer recommends using MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula
HOAT (Hybrid Organic Additive Technology) or
equivalent.
•Mix a minimum solution of 50% HOAT engine coolant
and distilled water. Use higher concentrations (not to
exceed 70%) if temperatures below34°F (37°C) are
anticipated.
•Use only high purity water such as distilled or deion-
ized water when mixing the water/engine coolant (antifreeze) solution. The use of lower quality water
will reduce the amount of corrosion protection in the
engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE: Mixing engine coolant (antifreeze) types will
decrease the life of the engine coolant (antifreeze) and
will require more frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that the engine coolant
(antifreeze) will return to the radiator from the coolant
recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.7
MAINTAINING YOUR VEHICLE 363
Page 366 of 444
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, the contents of
the coolant recovery bottle must also be protected
against freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
7
MAINTAINING YOUR VEHICLE 365
Page 367 of 444
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance, poor gas
mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to “Maintenance Schedule” for further information.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the brake system warning light indicates system fail-
ure.
Check the fluid level in the master cylinder when per-
forming underhood services.
366 MAINTAINING YOUR VEHICLE
Page 427 of 444
Caps, FillerFuel ............................... 303
Oil (Engine) .................. 341,342,343,350
Power Steering ........................ 253
Radiator (Coolant Pressure) ............... 363
Car Washes ............................ 372
Carbon Monoxide Warning ...............81,298
Cargo Area Features ...................... 134
Cargo Compartment ...................... 134
Cargo Load Floor ........................ 134
Cargo (Vehicle Loading) ................... 134
Cellular Phone ........................ 93,219
Center High Mounted Stop Light ............ 391
Chains, Tire ............................ 283
Changing A Flat Tire ..................... 323
Chart, Tire Sizing ........................ 268
Check Engine Light
(Malfunction Indicator Light) ............... 345
Checking Your Vehicle For Safety ............. 80Checks, Safety
........................... 80
Child Restraint .................... 69,71,75,78
Child Restraint Tether Anchors .............73,75
Child Safety Locks ........................ 32
Cigar Lighter ........................... 131
Clean Air Gasoline ....................... 295
Cleaning Wheels ............................. 373
Windshield Wiper Blades ................ 357
Climate Control ......................... 219
Clock .................. 169,171,186,187,190,200
Coin Holder ........................... 135
Compact Disc (CD) Maintenance ............. 218
Compact Spare Tire ...................... 279
Compass .............................. 163
Compass Calibration ..................... 164
Compass Variance ....................... 165
Computer, Trip/Travel .................. 20,162
Console ............................ 103,135
426 INDEX
Page 428 of 444
Console, Floor....................... 103,135
Contract, Service ........................ 417
Coolant Pressure Cap (Radiator Cap) .......... 363
Cooling System ......................... 361
Adding Coolant (Antifreeze) .............. 362
Coolant Capacity ...................... 392
Coolant Level ...................... 361,364
Disposal of Used Coolant ................ 364
Drain, Flush, and Refill .................. 361
Inspection ........................... 364
Points to Remember .................... 365
Pressure Cap ......................... 363
Radiator Cap ......................... 363
Selection of Coolant (Antifreeze) ......362,392,393
Corrosion Protection ..................... 371
Crankcase Ventilation Module ............... 20
Cruise Control (Speed Control) .............. 117
Cruise Light ........................... 152
Cupholders ...................... 103,132,376Customer Assistance
..................... 415
Customer Programmable Features ............ 166
Daytime Running Lights ................... 109
Dealer Service .......................... 346
Deck Lid, Power Release ................... 36
Defroster, Rear Window ................... 138
Defroster, Windshield ................82,221,227
Delay (Intermittent) Wipers ...............29,113
Diagnostic System, Onboard ................ 344
Dimmer Switch, Headlight ................. 108
Dipsticks Automatic Transaxle ................. 369,370
Oil (Engine) .......................... 348
Power Steering ........................ 253
Disabled Vehicle Towing ................... 335
Disposal Antifreeze (Engine Coolant) ............... 364
Engine Oil ........................... 351
10
INDEX 427
Page 437 of 444
Phone, Cellular.......................... 93
Phone, Hands-Free (Uconnect™) .............. 93
Placard, Tire and Loading Information ......... 272
Power Deck Lid Release ....................... 36
Door Locks ........................... 30
Mirrors .............................. 90
Outlet (Auxiliary Electrical Outlet) .......... 129
Seats ................................ 97
Steering ............................. 253
Sunroof ............................. 126
Windows ............................. 33
Pregnant Women and Seat Belts .............. 52
Preparation for Jacking .................... 324
Pretensioners Seat Belts ............................ 47
Programmable Electronic Features ............ 166
Programming Transmitters
(Remote Keyless Entry) .................... 25 Radial Ply Tires
......................... 279
Radiator Cap (Coolant Pressure Cap) .......... 363
Radio Operation ........................ 219
Radio Remote Controls .................... 216
Radio, Satellite (Uconnect studios)........... 210
Rear Cupholder ......................... 132
Rear Seat, Folding .................... 102,103
Rear Window Defroster ................... 138
Rear Window Features .................... 138
Rearview Mirrors ........................ 89
Recreational Towing ...................... 318
Reformulated Gasoline .................... 295
Refrigerant ............................ 355
Reminder, Seat Belt ....................... 51
Remote Control Door Locks ........................... 20
Security Alarm ......................... 18
Remote Keyless Entry (RKE) ................. 20
Remote Keyless Entry (Sedan) ............... 20
436 INDEX