power steering fluid CHRYSLER SEBRING CONVERTIBLE 2006 2.G Owners Manual

MAINTAINING YOUR VEHICLE
CONTENTS

2.4L Engine..........................213

2.7L Engine..........................214

Onboard Diagnostic System — OBD II......215

Emissions Inspection And Maintenance
Programs
............................216

Replacement Parts.....................217

Dealer Service........................217

Maintenance Procedures.................218
▫Engine Oil..........................218
▫Crankcase Emission Control System........224
▫Maintenance-Free Battery................225
▫Air Conditioner......................226▫Power Steering — Fluid Check............227
▫Suspension Ball Joints..................228
▫Body Mechanism Lubrication.............228
▫Windshield Wiper Blades................229
▫Windshield Washers...................230
▫Exhaust System......................231
▫Cooling System.......................232
▫Hoses And Vacuum/Vapor Harnesses.......236
▫Brakes.............................236
▫Fuel System Hoses....................239
▫Automatic Transmission................239
7

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
“DaimlerChrysler Dealership”.
Before removing the reservoir cap, wipe the outside of
the cap and reservoir so that no dirt can fall into the
reservoir.
WARNING!
Fluid level should be checked on a level surface with
the engine off to prevent injury from moving parts,
and to insure accurate fluid level reading. Do not
overfill. Use only manufacturer’s recommended
fluid.
Power Steering Fluid Reservoir
MAINTAINING YOUR VEHICLE 227
7

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You may not have your full
braking capacity in an emergency.
Brake and Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, checking, tears, cuts, abrasion, and excessive
swelling suggest deterioration of the rubber. Particular
attention should be made to examining those hose sur-
faces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Insure nylon tubing in these areas has not melted or
collapsed.
NOTE:Often, fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before hose is replaced based
on leakage.
NOTE:Inspection of brake hoses should be done
whenever the brake system is serviced and every engine
oil change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
MAINTAINING YOUR VEHICLE 237
7

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transaxle MoparATF+4 Automatic Transmission Fluid.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake fluid
is not available, then DOT 4 is acceptable. Use only recommended brake flu-
ids.
Power Steering Reservoir MoparPower Steering Fluid + 4, MoparATF+4 Automatic Transmission
Fluid.
Steering Gear & Linkage, Ball
Joints, Prop Shafts & Yokes, Wheel
BearingsMoparMulti-Purpose Lubricant NLGI Grade 2 or equivalent.
MAINTAINING YOUR VEHICLE 259
7

Miles 57,000 60,000 63,000 66,000 69,000 72,000
(Kilometers) (95 000) (100 000) (105 000) (110 000) (115 000) (120 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX X
Inspect theair cleaner filterand replace if neces-
sary.*XXXXX
Replace theair cleaner filter.X
Inspect and check tension for power steering belt
(2.4 Liter Engine). Adjust or replace if required.X
Inspect the front and rear brake pads, linings, ro-
tors, rear drums and shoes.XX
Replace theignition cableson 2.4 liter engine. X
Replace the accessory drive belts on the 2.7 liter
engine.X
Replace thespark plugson the 2.4 liter engine. X
Check and replace, if necessary, thePCV valve.*‡ X
Change the automatic transmission fluid and fil-
ter.X
Rotate the tires. X X X
Flush and replace engine coolant at 60 months, if
not done at 100,000 miles.X
SCHEDULE “B” 269
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Cooling............................ 232
Exhaust Gas Caution.................. 180
Fails to Start......................... 148
Fuel Requirements.................178,257
Oil ..........................218,257,258
Oil Change Interval................... 219
Oil Selection......................220,257
Oil Synthetic......................... 221
Overheating......................... 198
Timing Belt.......................... 224
Engine Oil Viscosity..................... 257
Entry System, Illuminated................. 12
Exhaust Gas Caution...............43,180,231
Exhaust System........................ 231
Exterior Light Service.................... 251
Filters
Air Cleaner.......................... 222
Automatic Transaxle................... 240
Engine Fuel......................... 223
Engine Oil.......................221,258
Engine Oil Disposal................... 221Flashers
Hazard Warning...................... 198
Turn Signal.......................... 90
Flash-To-Pass........................... 69
Flat Tire Changing...................... 199
Flexible Fuel Vehicles
Cruising Range....................... 182
Engine Oil.......................... 182
Fuel Requirements.................181,182
Maintenance......................... 183
Replacement Parts.................... 183
Starting............................ 182
Floor Console.......................... 55
Fluid, Brake........................... 259
Fluid Capacities........................ 257
Fluid Leaks............................ 44
Fluid Level Checks
Automatic Transaxle................... 240
Capacities........................... 257
Cooling System....................... 232
Engine Oil.......................... 218
Power Steering....................... 227
Fluids............................... 258
292 INDEX

Onboard Diagnostic System............215,216
Opener, Garage Door (HomeLink) .......... 75
Operator Manual (Owner’s Manual).......... 4
Overdrive............................ 152
Overheating, Engine..................... 198
Owner’s Manual (Operator Manual).......4,283
Paint Care............................ 241
Paint Damage......................... 241
Panic Alarm........................... 17
Parking Brake......................... 153
Parking On Hill........................ 154
Passing Light........................... 69
Pets.................................. 42
Pets, Transporting....................... 42
Placard, Tire and Loading Information....... 163
Power
Brakes............................. 155
Distribution Center.................... 248
Door Locks.......................... 12
Outlet (Auxiliary Electrical Outlet)......... 79
Seats............................... 60
Steering............................ 157Steering, Checking.................... 227
Windows............................ 21
Power Steering Fluid.................... 259
Pregnant Women and Seat Belts............. 28
Preparation for Jacking................... 200
Pretensioners
Seat Belts............................ 26
Programmable Electronic Features.........75,79
Programming Transmitters
(Remote Keyless Entry)...............17,75,79
Radial Ply Tires........................ 170
Radiator Cap (Coolant Pressure Cap)........ 234
Radio Broadcast Signals................... 99
Radio Operation...............109,115,127,129
Radio Remote Controls.................. 126
Radio, Satellite......................... 123
Radio (Sound Systems).............100,109,114
Rear Window Defroster.................. 139
Rearview Mirrors........................ 56
Reformulated Gasoline................... 178
Refrigerant............................ 227
Reminder, Lights On..................... 68
INDEX 297
10