ECU CHRYSLER SEBRING SEDAN 2008 3.G Service Manual

WARNING!
To avoid possible personal injury, handle the wheel
covers with care to avoid contact with any sharp
edges.
7. Lower the vehicle by turning the jack screw to the left.
8. Finish tightening the nuts. Push down on the wrench
while tightening the wheel nuts. Alternate nuts, until
each nut has been tightened twice. Correct wheel nut
torque is 100 ft. lbs (135 N·m). If you doubt that you have
tightened the nuts correctly, have them checked with a
torque wrench by your dealer or at a service station.
9. Remove the wheel blocks and lower the jack until it is
free. Reassemble the lug wrench to the jack assembly and
stow it in the spare tire area. Secure the assembly using
the means provided.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided. Have the deflated (flat) tire
repaired or replaced immediately.
10. Place the deflated (flat) tire in the cargo area andhave
the tire repaired or replaced as soon as possible.
11. Check the spare tire pressure as soon as possible.
Correct pressure as required.
WHAT TO DO IN EMERGENCIES 363
6

The A/C Air Filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter:
1. Open the glove box and remove all contents.
2. Push in on the sides of the glove box and lower the
door.
3. Disconnect the glove box door dampener from the slot
on the side of the box. This is done by grasping the
dampener connector (on the outside of the box) and the
end of the connector pin (on the inside of the box) with
your thumb and forefinger and pulling outward while
lightly lifting upward on the door with your other hand.
Once disconnected, the dampener will retract under-
neath the instrument panel if you release it.
4. Pivot the glove box downward.
5. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing and remove the cover.6. Remove the A/C Air Filter by pulling it straight out of
the housing.
7. Install the A/C Air Filter with the arrow on the filter
pointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
A/C Air Filter Replacement
390 MAINTAINING YOUR VEHICLE

Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsed
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.
Fuel System
Electronic Fuel Injection high-pressure fuel systems are
designed with tubes and special connects, connections,
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufactures-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the “Mainte-
nance Schedule” in this manual.
400 MAINTAINING YOUR VEHICLE

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake And Power Steering Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and brittle
rubber, cracking, tears, cuts, abrasions, and excessive swell-
ing suggest deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
NOTE:
•Often, fluids such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to ease the assembly of hoses to couplings. Therefore,
oil wetness at the hose-coupling area is not necessarily
an indication of leakage. Actual dripping of hot fluid
when systems are under pressure (during vehicle
operation) should be noted before a hose is replaced
based on leakage.
•Inspect the brake hoses whenever the brake system is
serviced and at every engine oil change. Inspect hy-
draulic brake hoses for surface cracking, scuffing, or
worn spots. If there is any evidence of cracking,
scuffing, or worn spots, the hose should be replaced
immediately! Eventual deterioration of the hose can
take place resulting in a possibility of a burst failure.
MAINTAINING YOUR VEHICLE 401
7

4. Pull the bulb out of the socket and replace the bulb.
5. If the bulb comes in contact with any oily surface,
clean the bulb with rubbing alcohol.
6. Reinsert the bulb and socket assembly and rotate
clockwise one-quarter turn to secure.Head Light Assembly Removal — Bulb
Replacement
1. Raise and prop open the hood. Remove the headlight
mounting screws.
2. Remove the push-in fasteners by prying under the
head of the fasteners with a flat bladed tool.
Removing Halogen Bulb From Assembly
Mounting Screw Location
420 MAINTAINING YOUR VEHICLE

ABS (Anti-Lock Brake System).............. 282
Accessory Delay, Power.................... 13
Adding Engine Coolant (Antifreeze).......... 396
Adding Fuel........................... 332
Adding Washer Fluid..................140,393
Additives, Fuel......................... 326
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 385
Air Conditioner Maintenance............... 388
Air Conditioning........................ 243
Air Conditioning Controls................. 243
Air Conditioning Filter.................256,389
Air Conditioning, Operating Tips............ 257
Air Conditioning Refrigerant.............388,389
Air Conditioning System.............243,248,388
Air Pressure, Tires....................... 304
Airbag.............................. 52,61
Airbag Deployment....................... 62
Airbag Light................... 53,60,65,79,173
Airbag Maintenance....................... 64Airbag, Side........................ 54,59,61
Airbag, Window (Side Curtain)........... 55,59,61
Alarm (Security Alarm).................... 18
Alarm System (Security Alarm)............ 18,173
Alignment and Balance................... 312
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 235
Antifreeze (Engine Coolant)...........395,396,429
Disposal............................ 398
Anti-Lock Brake System (ABS).............. 282
Anti-Lock Warning Light.................. 282
Anti-Theft Security Alarm (Theft Alarm)........ 18
Appearance Care........................ 406
Ashtray............................... 156
Assistance Towing....................... 102
Audio Systems (Radio).................222,225
Auto Down Power Windows................ 35
Auto Unlock, Doors....................... 32
Auto Up Power Windows................ 36,153
452 INDEX

Seat Belt Reminder..................... 173
Security Alarm (Theft Alarm).............. 19
Theft Alarm (Security Alarm).............. 173
Tire Pressure Monitoring (TPMS)........... 314
Traction Control....................... 287
Turn Signal..................135,179,422,424
Voltage............................. 173
Warning (Instrument Cluster Description)..... 172
Loading Vehicle......................335,337
Capacities........................... 337
Tires ............................... 299
Locks
Auto Unlock.......................... 32
Child Protection........................ 33
Power Door........................... 31
Low Tire Pressure System.................. 314
Lower Anchors and Tether for CHildren
(LATCH).............................. 73
Lubrication, Body....................... 392Lumbar Support........................ 124
Maintenance Free Battery.................. 387
Maintenance, General..................... 380
Maintenance Procedures................... 380
Maintenance Schedule.................... 434
Malfunction Indicator Light (Check Engine) . . 182,378
Manual, Service......................... 447
Map/Reading Lights..................... 131
Master Cylinder (Brakes).................. 402
Methanol............................. 324
Mini-Trip Computer...................... 186
Mirrors ................................ 85
Automatic Dimming..................... 86
Electric Powered....................... 87
Outside.............................. 88
Rearview............................. 85
Vanity ............................... 89
Modifications/Alterations, Vehicle............. 7
462 INDEX

Radio Operation...................223,226,242
Radio, Satellite..............222,223,225,227,234
Radio (Sound Systems).................222,225
Rear Cup Holder........................ 161
Rear Seat, Folding....................128,129
Rear Wheel Bearings..................... 406
Rear Window Defroster................... 258
Rear Window Features.................... 258
Rearview Mirrors........................ 85
Recorder, Event Data...................... 65
Recreational Towing...................349,369
Reformulated Gasoline.................... 324
Refrigerant............................ 389
Reminder, Seat Belt....................... 49
Remote Control
Door Locks........................... 21
Security Alarm......................... 18
Remote Keyless Entry (RKE)................. 21
Remote Keyless Entry (Sedan)............... 21Remote Sound System (Radio) Controls........ 238
Remote Starting System.................... 27
Remote Trunk Release..................... 38
Replacement Bulbs....................... 417
Replacement Keys........................ 16
Replacement Parts....................... 379
Replacement Tires....................... 310
Reporting Safety Defects................... 446
Resetting Oil Change Indicator...........175,185
Restraint, Head......................... 125
Restraints, Child......................... 67
Restraints, Infant......................... 68
Reverse Lights.......................... 424
Rotation, Tires.......................... 313
Safety Checks Inside Vehicle................. 79
Safety Checks Outside Vehicle............... 80
Safety Defects, Reporting.................. 446
Safety Information, Tire................... 294
INDEX 465
10

Safety Tips............................. 78
Satellite Radio...............222,223,225,227,234
Satellite Radio Antenna................... 235
Schedule, Maintenance.................... 434
Seat Belt Maintenance..................... 411
Seat Belt Reminder....................... 49
Seat Belts
Adjustable Shoulder Belt.................. 48
Adjustable Upper Shoulder Anchorage........ 48
And Pregnant Women................... 51
Child Restraint....................... 67,76
Extender............................. 51
Front Seat.......................... 42,43
Operating Instructions................... 43
Pretensioners.......................... 48
Rear Seat............................. 42
Reminder............................ 173
Untwisting Procedure.................... 47
Seat Belts (Sedan)........................ 40Seats................................. 121
Adjustment.......................... 121
Cleaning.........................129,409
Head Restraints....................... 125
Heated............................. 126
Lumbar Support....................... 124
Power.............................. 124
Rear Folding.......................128,129
Rear Folding (Sedan).................... 162
Reclining ............................ 123
Security Alarm (Theft Alarm)................ 18
Selection of Coolant (Antifreeze)..........395,430
Selection of Oil......................... 382
Sentry Key (Immobilizer)................... 15
Sentry Key Programming................... 17
Service Assistance....................... 443
Service Contract......................... 445
Service Manuals........................ 447
Setting the Clock.............193,196,208,224,227
466 INDEX

Theft Alarm (Security Alarm)................ 18
Theft System (Security Alarm)............... 18
Tilt Steering Column..................... 140
Time Delay, Headlight.................... 133
Tip Start.............................. 266
Tire and Loading Information Placard......... 299
Tire Identification Number (TIN)............. 298
Tire Markings.......................... 294
Tire Safety Information.................... 294
Tires ............................ 80,303,449
Aging(LifeofTires) .................... 309
Air Pressure.......................... 303
Alignment........................... 312
Chains.............................. 312
Changing............................ 356
Compact Spare........................ 307
Flat Changing........................ 363
General Information.................... 303
High Speed.......................... 305Inflation Pressures..................... 304
Jacking............................. 356
LifeofTires .......................... 309
Load Capacity.....................299,300
Pressure Monitor System (TPMS)........... 314
Quality Grading....................... 449
Radial.............................. 306
Replacement......................... 310
Rotation............................. 313
Safety...........................294,303
Sizes ............................... 296
Snow Tires........................... 312
Spare Tire........................... 356
Spinning ............................ 308
Tread Wear Indicators................... 309
Tongue Weight/Trailer Weight.............. 342
Towing ............................... 338
24-Hour Towing Assistance............... 102
Disabled Vehicle....................... 368
468 INDEX