engine coolant CHRYSLER SEBRING SEDAN 2010 3.G User Guide

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposalrules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
Four-Cylinder Engines —
the coolant bottle provides a
quick visual method for determining that the engine
coolant (antifreeze) level is adequate. With the engine
idling and warm to normal operating temperature, the
level of the engine coolant (antifreeze) in the bottle
should be between the “ADD” and “FULL” lines, shown
on the bottle.
Six-Cylinder Engines — the level of the engine coolant
(antifreeze) in the pressurized coolant bottle should be
between the “COLD” and “FULL” range on the bottle
when the engine is cold.
358 MAINTAINING YOUR VEHICLE

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, the contents of
the coolant recovery bottle must also be protected
against freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
7
MAINTAINING YOUR VEHICLE 359

FLUIDS AND CAPACITIES
U.S.Metric
Fuel (Approximate)
All Engines — (Except 2.4L PZEV) 16.9 Gallons64 Liters
2.4L PZEV (Partial Zero Emissions Vehicle) 18.5 Gallons70 Liters
Engine Oil with Filter
2.4L Engine (SAE 5W-20, API Certified) 4.5 Quarts4.4 Liters
2.7L Engine (SAE 5W-20, API Certified) 5.5 Quarts5.2 Liters
3.5L Engine (SAE 10W-30, API Certified) 5.5 Quarts5.2 Liters
Cooling System*
2.4L Engine (MOPARAntifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 7.7 Quarts
7.3 Liters
2.7L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 9.8 Quarts
9.3 Liters
3.5L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 11.6 Quarts
11 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
386 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT
(Hybrid Organic Additive Technology) or equivalent.
Engine Oil (2.4L and 2.7L Engines) Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your engine oil filler
cap for correct SAE grade.
Engine Oil (3.5L Engine) Use API Certified SAE 10W-30 Engine Oil, meeting Chrysler Material
Standard MS-6395. Refer to your engine oil filler cap for correct SAE
grade.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs (2.4L Engine except PZEV*) ZFR5F-11 (Gap 0.043 in [1.11 mm])
Spark Plugs (2.4L with PZEV*) ZFR5AP (Gap 0.031 in [0.8 mm])
Spark Plugs (2.7L Engine) TE10PMC5 (Gap 0.050 in [1.27 mm])
Spark Plugs (3.5L Engine) ZFR5LP-13G (Gap 0.050 in [1.27 mm])
Fuel Selection (2.4L and 2.7L Engines) 87 Octane
Fuel Selection (3.5L Engine) 87 Octane Acceptable – 89 Octane Recommended
* PZEV = Partial Zero Emission Vehicle
7
MAINTAINING YOUR VEHICLE 387

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S392 MAINTENANCE SCHEDULES

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the spark plugs (2.4L PZEV*,
2.7L and 3.5L Engines).
❏ Replace the timing belt (3.5L Engine).
❏ Flush and replace the engine coolant.
❏ Inspect accessory drive belt, replace if
necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and
replace if necessary.
❏ Inspect the brake linings, and replace as necessary.
❏ Replace the air conditioning filter (if equipped).
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 401

About Your Brakes....................... 252
ABS (Anti-Lock Brake System) .............. 254
Adding Engine Coolant (Antifreeze) .......... 356
Adding Fuel ........................... 299
Adding Washer Fluid ..................... 352
Additives, Fuel ......................... 293
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 346
Air Conditioner Maintenance ............... 348
Air Conditioning ........................ 218
Air Conditioning Controls ................. 218
Air Conditioning Filter .................229,349
Air Conditioning, Operating Tips ............ 230
Air Conditioning Refrigerant .............348,349
Air Conditioning System .............218,222,348
Air Pressure, Tires ....................... 273
Airbag .............................. 54,64
Airbag Deployment ....................... 65
Airbag Light ................... 55,62,68,83,147
Airbag Maintenance ....................... 67 Airbag, Side
........................ 57,61,64
Airbag, Window (Side Curtain) ...........58,61,64
Alarm System (Security Alarm) ............18,154
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 210
Antifreeze (Engine Coolant) ...........355,356,386
Disposal ............................ 358
Anti-Lock Brake System (ABS) .............. 254
Anti-Lock Warning Light .................. 254
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Appearance Care ........................ 365
Ashtray ............................... 131
Auto Down Power Windows ................ 34
Auto Unlock, Doors ....................... 31
Auto Up Power Windows ................35,128
Automatic Dimming Mirror ................. 90
Automatic Door Locks ................... 30,31
Automatic Oil Change Indicator ........152,162,390
Automatic Temperature Control (ATC) ......... 222
418 INDEX

Automatic Transaxle..............12,235,239,362
Adding Fluid ................... 363,364,388
Filter ............................... 364
Fluid and Filter Changes ................. 364
Fluid Level Check ................... 363,364
Interlock System .................... 240,241
Reset Mode .......................... 245
Selection Of Lubricant ................... 388
Shifting ............................. 239
Special Additives ...................... 364
Autostick ............................. 246
Back-Up Lights ......................... 381
Battery ............................... 346
Gas Caution .......................... 347
Jump Starting ......................... 29
Keyless Transmitter Replacement (RKE) ....... 25
Location ............................ 346
Belts, Seat .............................. 83 Body Mechanism Lubrication
............... 350
B-Pillar Location ........................ 268
Brake Assist System ...................... 257
Brake, Parking .......................... 252
Brake System ........................... 360
Anti-Lock (ABS) ....................... 254
Fluid Check ....................... 360,388
Master Cylinder ....................... 360
Parking ............................. 252
Warning Light ........................ 148
Brakes ............................... 360
Brake/Transaxle Interlock .................. 240
Break-In Recommendations, New Vehicle ........ 81
Bulb Replacement ....................... 377
Bulbs, Light .......................... 84,377
Calibration, Compass ..................... 165
Capacities, Antifreeze (Engine Coolant) ......... 20
Capacities, Fluid ........................ 386
10
INDEX 419

Caps, FillerFuel ............................... 299
Oil (Engine) .................. 335,336,337,344
Power Steering ........................ 251
Radiator (Coolant Pressure) ............... 357
Car Washes ............................ 366
Carbon Monoxide Warning ...............82,294
Cargo Area Features ...................... 134
Cargo Compartment ...................... 134
Cargo Load Floor ........................ 134
Cargo (Vehicle Loading) ................... 134
Cellular Phone ........................ 93,217
Center High Mounted Stop Light ............ 385
Chains, Tire ............................ 279
Changing A Flat Tire ..................... 318
Chart, Tire Sizing ........................ 265
Check Engine Light
(Malfunction Indicator Light) ............... 339
Checking Your Vehicle For Safety ............. 82Checks, Safety
........................... 82
Child Restraint .................... 70,71,76,79
Child Restraint Tether Anchors .............74,76
Child Safety Locks ........................ 32
Cigar Lighter ........................... 131
Clean Air Gasoline ....................... 291
Cleaning Wheels ............................. 367
Windshield Wiper Blades ................ 351
Climate Control ......................... 217
Clock ..................... 169,172,186,189,198
Coin Holder ........................... 136
Compact Disc (CD) Maintenance ............. 217
Compact Spare Tire ...................... 275
Compass .............................. 164
Compass Calibration ..................... 165
Compass Variance ....................... 165
Computer, Trip/Travel .................. 20,162
Console ............................ 104,136
420 INDEX

Console, Floor....................... 104,136
Contract, Service ........................ 411
Coolant Pressure Cap (Radiator Cap) .......... 357
Cooling System ......................... 354
Adding Coolant (Antifreeze) .............. 356
Coolant Capacity ...................... 386
Coolant Level ...................... 355,358
Disposal of Used Coolant ................ 358
Drain, Flush, and Refill .................. 355
Inspection ........................... 358
Points to Remember .................... 359
Pressure Cap ......................... 357
Radiator Cap ......................... 357
Selection of Coolant (Antifreeze) ......355,386,387
Corrosion Protection ..................... 365
Crankcase Ventilation Module ............... 20
Cruise Control (Speed Control) .............. 117
Cruise Light ........................... 152
Cupholders ...................... 104,132,370Customer Assistance
..................... 409
Customer Programmable Features ............ 167
Daytime Running Lights ................... 110
Dealer Service .......................... 341
Deck Lid, Power Release ................... 37
Defroster, Rear Window ................... 139
Defroster, Windshield ................84,220,226
Delay (Intermittent) Wipers ...............29,113
Diagnostic System, Onboard ................ 338
Dimmer Switch, Headlight ................. 109
Dipsticks Automatic Transaxle ................. 363,364
Oil (Engine) .......................... 342
Power Steering ........................ 251
Disabled Vehicle Towing ................... 329
Disposal Antifreeze (Engine Coolant) ............... 358
Engine Oil ........................... 345
10
INDEX 421