coolant temperature CHRYSLER TOWN AND COUNTRY 2008 5.G Owners Manual

19. Malfunction Indicator Light
This light is part of an onboard diagnostic system
called OBD that monitors engine and automatic
transmission control systems. The light will illu-
minate when the key is in the ON position before engine
start. If the bulb does not come on when turning the key
from OFF to ON, have the condition checked promptly.
Certain conditions such as a loose or missing gas cap,
poor fuel quality, etc. may illuminate the light after
engine start. The vehicle should be serviced if the light
stays on through several of your typical driving cycles. In
most situations the vehicle will drive normally and will
not require towing.
If the Malfunction Indicator Light flashes when the
engine is running, serious conditions may exist that
could lead to immediate loss of power or severe catalytic
converter damage. The vehicle should be serviced as
soon as possible if this occurs.20. Airbag Light
This light turns on and remains on for seven
seconds as a bulb check when the ignition
switch is first turned ON. If the light is not on
during starting, stays on, or turns on while
driving, have the system inspected by an authorized
dealer as soon as possible.
21. Temperature Gauge
The temperature gauge shows engine coolant tem-
perature. Any reading within the normal range
indicates that the engine cooling system is operat-
ing satisfactorily.
The gauge pointer will likely indicate a higher tempera-
ture when driving in hot weather, up mountain grades,
or when towing a trailer. It should not be allowed to
exceed the upper limits of the normal operating range.
UNDERSTANDING YOUR INSTRUMENT PANEL 233
4

CAUTION!
Driving with a hot engine cooling system could
damage your vehicle. If temperature gauge reads
ªHª, pull over and stop the vehicle. Idle the vehicle
with the air conditioner turned off until the pointer
drops back into the normal range. If the pointer
remains on the ªHº, and you hear continuous chimes,
turn the engine off immediately, and call your autho-
rized dealership for service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call an authorized dealer-
ship for service if your vehicle overheats. If you
decide to look under the hood yourself, see Section 7
of this manual. Follow the warnings under the Cool-
ing System Pressure Cap paragraph.
22. Trip/Odometer Display Reset Button Ð Base
Cluster
To reset a trip odometer, display the trip odometer to be
reset then push and hold the button until the display
resets (approximately two seconds). The odometer must
be in TRIP mode to reset it.
234 UNDERSTANDING YOUR INSTRUMENT PANEL

When rear controls are locked by the front system, the
LOCK symbol on the temperature knob is illuminated
and any rear overhead adjustments are ignored.
Rear Mode Control
AUTO Mode
The rear system automatically maintains the correct
mode and comfort level desired by the rear seat occu-
pants.
FLOOR Mode
Air comes from the floor outlets.
BI-LEVEL Mode
Air comes from both the headliner outlets and the
floor outlets.
NOTE:In many temperature positions, the BI-LEVEL
mode is designed to provide cooler air out of the head-
liner outlets and warmer air from the floor outlets.HEADLINER Mode
Air comes from the outlets in the headliner. Each of
these outlets can be individually adjusted to direct
the flow of air. Moving the air vanes of the outlets to one
side will shut off the airflow.SUMMER OPERATION
The engine cooling system in air conditioned vehicles
must be protected with a high-quality antifreeze coolant
to provide proper corrosion protection and to protect
against engine overheating. A 50% solution of ethylene
glycol antifreeze coolant in water is recommended. Refer
to section 7, ªMaintenance Proceduresº, of this manual
for proper coolant selection.
WINTER OPERATION
To ensure the best possible heater and defroster perfor-
mance, make sure the engine cooling system is function-
ing properly and the proper amount, type, and concen-
tration of coolant is used. Refer to section 7,
UNDERSTANDING YOUR INSTRUMENT PANEL 319
4

the fan control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads ªHº, pull
over and stop the vehicle. Idle the vehicle with the air
conditioner turned off until the pointer drops back
into the normal range. If the pointer remains on the
ªHº, turn the engine off immediately, and call for
service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, see Section 7, Maintenance, of this
manual. Follow the warnings under the Cooling
System Pressure Cap paragraph.
WHAT TO DO IN EMERGENCIES 411
6

COOLING SYSTEM
WARNING!
²When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at anytime the ignition
switch is in the ON position.
²You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don't open the
hood until the radiator has had time to cool. Never
try to open a cooling system pressure cap when the
radiator is hot.
Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
coolant. Check the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the engine coolant (antifreeze) will begin to
454 MAINTAINING YOUR VEHICLE

Adding Coolant
Your vehicle has been built with an improved engine
coolant that allows extended maintenance intervals. This
coolant can be used up to five years or 102,000 mi (170
000 km) before replacement. To prevent reducing this
extended maintenance period, it is important that you
use the same coolant throughout the life of your vehicle.
Please review these recommendations for using Hybrid
Organic Additive Technology (HOAT) coolant.
When adding coolant, a minimum solution of 50% rec-
ommended MopartAntifreeze/ Coolant Five Year/
100,000 mi (160 934 km) Formula HOAT (Hybrid Organic
Additive Technology), or equivalent, in water should be
used. Use higher concentrations (not to exceed 70%) if
temperatures below234ÉF (237ÉC ) are anticipated.
Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant solution.The use of lower quality water will reduce the amount of
corrosion protection in the engine cooling system.
Please note that it is the owner's responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to ensure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
456 MAINTAINING YOUR VEHICLE

WARNING!
²The warning words ªDO NOT OPEN HOTº on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
²Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol-based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for yourcommunity. To prevent ingestion by animals or children
do not store ethylene glycol-based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine cold, the level of the coolant in the coolant
recovery bottle should be between the ranges indicated
on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
MAINTAINING YOUR VEHICLE 457
7

Emission Control System Maintenance......436,490
Engine........................92,432,433,434
Air Cleaner.......................... 443
Block Heater......................... 329
Break-In Recommendations................ 92
Checking Oil Level..................... 439
Compartment......................433,434
Coolant (Antifreeze).................... 487
Cooling............................. 454
Exhaust Gas Caution..................51,383
Flooded, Starting...................... 328
Fuel Requirements..................379,486
Oil ...........................439,486,487
Oil Change Interval.................... 440
Oil Disposal.......................... 442
Oil Filler Cap......................432,441
Oil Filter Disposal...................... 442
Oil Selection.......................440,486
Oil Synthetic......................... 442Operation............................ 92
Overheating.......................... 410
Starting............................. 326
Temperature Gauge..................... 233
Enhanced Accident Response Feature.......... 74
Event Data Recorder...................... 77
Exhaust Gas Caution..............51,94,383,446
Exhaust System......................... 446
Extender, Seat Belt........................ 65
Exterior Folding Mirrors................... 102
Fabric Care.........................468,469
Filler Location Fuel...................... 239
Filters
Air Cleaner.......................... 443
Air Conditioning....................321,449
Engine Oil........................442,487
Engine Oil Disposal.................... 442
INDEX 513
10

Requirements......................379,486
System Hoses......................... 459
Tank Capacity........................ 486
Fuel, Flexible.............See Flexible Fuel Vehicles
Fuel System Caution..................... 382
Fueling............................... 383
Fuses................................ 472
Garage Door Opener (HomeLinkt) ........... 183
Gas Cap (Fuel Filler Cap)...............383,385
Gasoline, Clean Air...................... 380
Gasoline (Fuel)......................... 379
Gasoline, Reformulated................... 380
Gauges
Coolant Temperature.................... 233
Fuel................................ 226
Speedometer......................... 229
Tachometer.......................... 232
Gearshift.............................. 332General Information...............18,27,131,378
Glass Cleaning.......................... 470
Grocery Bag Retainer..................... 153
Gross Axle Weight Rating...............391,395
Gross Vehicle Weight Rating.............391,394
Hands-Free Phone (UConnectŸ).......104,285,286
Hard Drive (HDD)....................282,285
Hazard
Driving Through Flowing, Rising, or
Shallow Standing Water................. 349
Hazard Warning Flasher................... 410
Head Restraints......................... 133
Headlights..........................161,481
Bulb Replacement...................... 481
Cleaning............................ 470
High Beam/Low Beam Select Switch........ 168
Lights On Reminder.................... 164
On With Wipers....................... 163
INDEX 515
10

Storing Your Vehicle...................... 479
Stow8n Go (Fold in Floor) Seats............. 137
Sun Roof.............................. 189
Sunglasses Storage....................... 181
Sunroof Maintenance..................... 192
Supplemental Restraint System - Airbag........ 66
Swivel8n Go Seats....................... 146
Synthetic Engine Oil...................... 442
System, Navigation...................... 285
System, Remote Starting.................... 27
Tachometer............................ 232
Temperature Control, Automatic (ATC)........ 311
Temperature Gauge, Engine Coolant........233,411
Tether Anchor, Child Restraint............... 85
Tilt Steering Column..................... 169
Tip Start............................... 14
Tire and Loading Information Placard......... 355
Tire Identification Number (TIN)............. 354Tire Markings.......................... 351
Tire Safety Information.................... 351
Tires ............................94,359,505
Aging (Life of Tires).................... 366
Air Pressure.......................... 359
Alignment........................... 367
Chains.............................. 368
Changing............................ 412
Compact Spare........................ 362
Flat Changing........................ 421
General Information.................... 359
High Speed.......................... 362
Inflation Pressures..................... 360
Jacking...........................412,415
Life of Tires.......................... 366
Load Capacity.....................355,356
Pressure Monitor System (TPMS)........... 370
Quality Grading....................... 505
Radial.............................. 362
524 INDEX