clutch CHRYSLER VOYAGER 2000 Diagnostic Manual

Symptom:
P-0743 TORQUE CONVERTER CLUTCH SOLENOID CIRCUIT
When Monitored and Set Condition:
P-0743 TORQUE CONVERTER CLUTCH SOLENOID CIRCUIT
When Monitored: With the ignition key on.
Set Condition: An open or shorted condition is detected in the Torque Converter Clutch
Solenoid Control Circuit.
POSSIBLE CAUSES
FUSED IGNITION SWITCH OUTPUT CIRCUIT OPEN
TORQUE CONVERTER CLUTCH SOLENOID DEFECTIVE
TCC SOLENOID CIRCUIT W/H INTERMITTENT DEFECT
TCC SOLENOID CIRCUIT W/H OBSERVABLE DEFECT
TCC SOLENOID CONTROL CIRCUIT OPEN
TCC SOLENOID CONTROL CIRCUIT SHORT TO GROUND
PCM DEFECTIVE (TCC SOLENOID CONTROL CIRCUIT)
TEST ACTION APPLICABILITY
1 Ignition On, Engine Not Running
With the DRB, read codes.
Is the Global Good Trip displayed and equal to 0?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Go To 2
No®Go To 7
2 Ignition Off
Disconnect the TCC Solenoid Connector.
Note: Check connectors - Clean/repair as necessary.
Key on.
With the Voltmeter, probe the voltage of the Fused Ignition Switch Output Circuit at
Solenoid Connector.
Is the voltage above 10.0 volts?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Go To 3
No®Repair the open Fused Ignition Switch Output Circuit..
Perform Powertrain Verification Test VER-5A.
304
TRANSMISSION
ProCarManuals.com

TEST ACTION APPLICABILITY
3 Ignition Off
Disconnect the Powertrain Control Module.
Note: Check connectors - Clean/repair as necessary.
Key on.
With the voltmeter, probe the TCC Solenoid Control Circuit at the PCM connector.
Is the voltage above 10.0 volts?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Go To 4
No®Replace the TCC Solenoid.
Perform Powertrain Verification Test VER-5A.
4 Ignition Off
Disconnect the Powertrain Control Module Connector.
Disconnect the TCC Solenoid Connector.
Note: Check connectors - Clean/repair as necessary.
Using an Ohmmeter, measure the TCC Solenoid Control Circuit from the TCC
Solenoid Connector to the PCM Connector.
Is the resistance below 5.0 ohms?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Go To 5
No®Repair the open TCC Solenoid Control Circuit.
Perform Powertrain Verification Test VER-5A.
5 Ignition Off
Disconnect the Powertrain Control Module Connector.
Disconnect the TCC Solenoid Connector.
Note: Check connectors - Clean/repair as necessary.
With the DRB in ohmmeter mode, measure between the TCC Solenoid Control
Circuit and ground.
Is the resistance below 5.0 ohms?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Repair the TCC Solenoid Control Circuit short to ground.
Perform Powertrain Verification Test VER-5A.
No®Go To 6
6 If there are no potential causes remaining, the PCM is assumed to be defective.
View repair options.TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Repair
Replace the Powertrain Control Module.
Perform Powertrain Verification Test VER-5A.
7 Ignition On, Engine Not Running
With the DRB, erase codes.
Turn ignition off for 10 seconds, then turn ignition on.
With the DRB actuate the TCC Solenoid.
With the DRB, read codes.
Wiggle Wiring Harness from the Solenoid to PCM.
Does the TCC Solenoid Control Circuit code return?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Repair as necessary where wiggling caused problem to appear.
Perform Powertrain Verification Test VER-5A.
No®Go To 8
305
TRANSMISSION
P-0743 TORQUE CONVERTER CLUTCH SOLENOID CIRCUIT ÐContinued
ProCarManuals.com

TEST ACTION APPLICABILITY
8 Ignition Off
Using the schematic as a guide, inspect the Wiring and Connectors.
Were any problems found?TRANSMISSION -
AUTOMATIC
3-SPD, 31TH
Ye s®Repair as necessary.
Perform Powertrain Verification Test VER-5A.
No®Test Complete.
306
TRANSMISSION
P-0743 TORQUE CONVERTER CLUTCH SOLENOID CIRCUIT ÐContinued
ProCarManuals.com

9.0 CONNECTOR PINOUTS
A/C COMPRESSOR CLUTCH - BLACK 2 WAYCAV CIRCUIT FUNCTION
1 C3 18DB/BK A/C CLUTCH COMPRESSOR RELAY OUTPUT
2 Z1 18BK GROUND
AMBIENT TEMPERATURE SENSOR - GRAY 2 WAYCAV CIRCUIT FUNCTION
1 G31 20VT/LG AMBIENT TEMPERATURE SENSOR SIGNAL
2 G32 20BK/LB SENSOR GROUND
AMBIENT TEMPERATURE SENSOR (SENSOR SIDE) 2 WAYCAV CIRCUIT FUNCTION
1 - AMBIENT TEMPERATURE SENSOR SIGNAL
2 - SENSOR GROUND
BRAKE LAMP SWITCH - GRAY 6 WAYCAV CIRCUIT FUNCTION
1 K29 20WT/PK BRAKE SWITCH SENSE
2 Z1 20BK GROUND
3 V32 20YL/RD SPEED CONTROL ON/OFF SWITCH SENSE
4 V30 20DB/RD SPEED CONTROL BRAKE SWITCH OUTPUT
5 L50 18WT/TN BRAKE LAMP SWITCH OUTPUT
6 F32 18PK/DB FUSED B(+)
C
O
N
N
E
C
T
O
R
P
I
N
O
U
T
S
333
CONNECTOR PINOUTS
ProCarManuals.com

CLOCKSPRING C3 - BLACK 2 WAYCAV CIRCUIT FUNCTION
1 X10 20RD/DB RADIO MUX
2 X20 20RD/BK RADIO CONTROL MUX
CLUTCH INTERLOCK SWITCH (MTX) - BLACK 2 WAYCAV CIRCUIT FUNCTION
1 F45 20YL/RD (RHD) IGNITION SWITCH OUTPUT (START)
1 F45 20YL (LHD) IGNITION SWITCH OUTPUT (START)
2 T141 20YL/RD IGNITION SWITCH OUTPUT (START)
CLUTCH INTERLOCK SWITCH JUMPER (EATX) - BLACK 2 WAYCAV CIRCUIT FUNCTION
1 T141 20YL/RD (RHD) IGNITION SWITCH OUTPUT (START)
1 T141 20YL (LHD) IGNITION SWITCH OUTPUT (START)
2 T141 20YL/RD (RHD) IGNITION SWITCH OUTPUT (START)
2 T141 20YL (LHD) IGNITION SWITCH OUTPUT (START)
CRANKSHAFT POSITION SENSOR - BLACK 3 WAYCAV CIRCUIT FUNCTION
1 K7 18OR 8V SUPPLY
2 K4 18BK/LB SENSOR GROUND
3 K24 18GY/BK CRANKSHAFT POSITION SENSOR SIGNAL
C
O
N
N
E
C
T
O
R
P
I
N
O
U
T
S
335
CONNECTOR PINOUTS
ProCarManuals.com

FUSESFUSE
NO.AMPS FUSED CIRCUIT FEED CIRCUIT
1 15A INTERNAL A0 6RD
2 20A (GAS/EATX) INTERNAL A0 6RD
3 20A INTERNAL A0 6RD
4 10A INTERNAL A0 6RD
5 10A INTERNAL A0 6RD
6 15A F41 20PK/VT A0 6RD
7 20A INTERNAL A0 6RD
8 20A L43 18VT INTERNAL
9 15A L44 20VT/RD INTERNAL
10 25A A20 12RD/DB A0 6RD
11 20A F32 18PK/DB A0 6RD
12 10A A22 12BK/OR F23 18DB/YL
13 10A F14 18LG/YL INTERNAL
14 20A L9 18BK/VT A0 6RD
15 10A M1 20PK A0 6RD
16 - SPARE A0 6RD
17 - SPARE A0 6RD
18 10A L33 20RD INTERNAL
19 10A L34 20RD/OR A0 6RD
19 10A L34 20RD/OR A0 6RD
101 40A INTERNAL A0 6RD
102 40A A10 12RD/DG A0 6RD
103 40A A2 12PK/BK A0 6RD
104 40A A1 12RD A0 6RD
105 40A (DIESEL) A17 12RD/BK A0 6RD
106 40A A16 12GY A0 6RD
107 40A INTERNAL A0 6RD
108 40A A4 12BK/RD A0 6RD
109 30A INTERNAL A0 6RD
A/C COMPRESSOR CLUTCH RELAYCAV CIRCUIT FUNCTION
30 INTERNAL FUSED B(+)
85 C13 18DB/OR A/C COMPRESSOR CLUTCH RELAY CONTROL (GAS)
85 C13 20DB/OR A/C COMPRESSOR CLUTCH RELAY CONTROL (DIESEL)
86 F87 18WT/BK FUSED IGNITION SWITCH OUTPUT (ST-RUN) (GAS)
86 A142 18DG/OR DIESEL POWER RELAY OUTPUT (DIESEL)
87 C3 18DB/BK A/C COMPRESSOR CLUTCH RELAY OUTPUT
87A --
AUTOMATIC SHUT DOWN RELAY (GAS)CAV CIRCUIT FUNCTION
30 INTERNAL FUSED B(+)
85 K51 18DB/YL AUTOMATIC SHUT DOWN RELAY CONTROL
86 A0 6RD B(+)
87 A142 18DG/OR AUTOMATIC SHUT DOWN RELAY OUTPUT
87A --
CIGAR LIGHTER/ACCESSORY RELAYCAV CIRCUIT FUNCTION
30 INTERNAL FUSED B(+)
85 Z1 18BK GROUND
86 F1 20DB FUSED IGNITION SWITCH OUTPUT (RUN-ACC)
87 F30 16RD CIGAR LIGHTER/ACCESSORY RELAY OUTPUT
87A --
C
O
N
N
E
C
T
O
R
P
I
N
O
U
T
S
346
CONNECTOR PINOUTS
ProCarManuals.com

POWERTRAIN CONTROL MODULE C2 - GRAY 40 WAYCAV CIRCUIT FUNCTION
41 V37 18RD/LG SPEED CONTROL SWITCH SIGNAL
42 C18 18DB A/C PRESSURE SIGNAL
43 K4 18BK/LB SENSOR GROUND
44 K7 18OR 8V SUPPLY
45 - -
46 A14 18RD/WT FUSED B(+)
47 - -
48 K40 18BR/WT IDLE AIR CONTROL NO. 3 DRIVER
49 K60 18L/BK IDLE AIR CONTROL NO. 2 DRIVER
50 Z12 18BK/TN GROUND
51 K141 18TN/WT OXYGEN SENSOR 1/2 SIGNAL
52 - -
53 - -
54 - -
55 - -
56 V36 18TN.RD (EXCEPT
3.0L)SPEED CONTROL VACUUM SOLENOID CONTROL
57 K39 18GY/RD IDLE AIR CONTROL NO. 1 DRIVER
58 K59 18VT/BK IDLE AIR CONTROL NO. 4 DRIVER
59 D1 18VT/BR CCD BUS (+)
60 D2 18WT/BK CCD BUS (-)
61 K6 18VT/WT 5V SUPPLY
62 K29 18WT/PK BRAKE SWITCH SENSE
63 T10 18YL/DG (EATX) TORQUE MANAGEMENT REQUEST SENSE
64 C13 18DB/OR A/C COMPRESSOR CLUTCH RELAY CONTROL
65 D21 18PK SCI TRANSMIT
66 G7 18WT/OR VEHICLE SPEED SENSOR SIGNAL
67 K51 18DB/YL AUTOMATIC SHUT DOWN RELAY CONTROL
68 K52 18PK/BK DUTY CYCLE EVAP/PURGE SOLENOID CONTROL
69 - -
70 K70 18VT/RD (EXCEPT
3.0L)PULSE WIDTH MODULATED PURGE SENSE
71 - -
72 K107 18DB/WT (3.3L/3.8L) LEAK DETECTION PUMP SWITCH SENSE
72 K107 18YL/BK (2.4L ATX) LEAK DETECTION PUMP SWITCH SENSE
73 K173 14LG/DB RADIATOR FAN RELAY CONTROL
74 K31 18BR FUEL PUMP RELAY CONTROL
75 D20 18LG SCI RECEIVE
76 T41 18BK/WT (2.4L ATX) TRS T41 SENSE
76 T41 18BR/YL (EATX) TRS T41 SENSE
77 K106 18WT/DG (EXCEPT
3.0L)LEAK DETECTION PUMP SOLENOID CONTROL
78 K54 18OR/BK (2.4L ATX) TORQUE CONVERTER CLUTCH SOLENOID CONTROL
78 V36 18TN/RD (3.0L) SPEED CONTROL VACUUM SOLENOID CONTROL
79 - -
80 V35 18LG/RD SPEED CONTROL VENT SOLENOID CONTROL
RADIATOR FAN NO. 1 - BLACK 2 WAYCAV CIRCUIT FUNCTION
1 C23 12DG LOW SPEED RADIATOR FAN RELAY OUTPUT
2 Z1 12BK GROUND
C
O
N
N
E
C
T
O
R
P
I
N
O
U
T
S
350
CONNECTOR PINOUTS
ProCarManuals.com

THROTTLE POSITION SENSOR (EXCEPT 2.0L) - NATURAL 3 WAYCAV CIRCUIT FUNCTION
1 K4 18BK/LB SENSOR GROUND
2 K22 18OR/DB THROTTLE POSITION SENSOR SIGNAL
3 K6 18VT/WT 5V SUPPLY
TORQUE CONVERTER CLUTCH SOLENOID (ATX)-3WAYCAV CIRCUIT FUNCTION
1- -
2 F87 18WT/BK FUSED IGNITION SWITCH OUTPUT (ST-RUN)
3 K54 18OR/BK TORQUE CONVERTER CLUTCH SOLENOID CONTROL
C
O
N
N
E
C
T
O
R
P
I
N
O
U
T
S
352
CONNECTOR PINOUTS
ProCarManuals.com