ECU CHRYSLER VOYAGER 2022 Workshop Manual

SERVICING AND MAINTENANCE253
6. After removing the snaps, lift up the compartment cover to gain access to the fresh
air inlet.

Cabin Air Filter Cover

7. Remove the filter cover by prying back each of the retaining tabs from their hooking points,
and then pulling the filter cover out to expose
the cabin air filter. Remove the air filter by
pulling it straight out of the housing.
8. Install the new air filter with the arrow on the filter pointing toward the floor. 9. Once the filter is replaced, reinstall the filter
cover, making sure the retaining tabs are fully
secured into their housings.
10. Close the cabin air filter compartment cover, and reinsert the snaps into their slots. Push
the snap lids until fully attached.
11. Push the glove compartment door to the near closed position to reengage the glove
compartment travel stops. Finally, pull the
glove compartment tension tether clip down
and slide it back into the slot on the side of the
glove compartment door.
BODY LUBRICATION
Locks and all body pivot points, including such
items as seat tracks, door hinge pivot points and
rollers, liftgate, tailgate, decklid, sliding doors and
hood hinges, should be lubricated periodically. Use
a lithium-based grease, such as Mopar® Spray
White Lube to ensure quiet, easy operation and to
protect against rust and wear. Prior to the
application of any lubricant, the parts concerned should be wiped clean to remove dust and grit;
after lubricating, excess oil and grease should be
removed. Particular attention should also be given
to hood latching components to ensure proper
function. When performing other underhood
services, the hood latch release mechanism, and
safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated
twice a year, preferably in the Autumn and Spring.
Apply a small amount of a high quality lubricant,
such as Mopar® Lock Cylinder Lubricant directly
into the lock cylinder.
WINDSHIELD WIPER BLADES
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove
accumulations of salt or road film.
Operation of the wipers on dry glass for long
periods may cause deterioration of the wiper
blades. Always use washer fluid when using the
wipers to remove salt or dirt from a dry windshield.
Avoid using the wiper blades to remove frost or ice
from the windshield. Keep the blade rubber out of
contact with petroleum products such as engine
oil, gasoline, etc.
1 — Filter Cover
2 — Retaining Tabs
CAUTION!
The cabin air filter is identified with an arrow to
indicate airflow direction through the filter.
Failure to properly install the filter will result in
the need to replace it more often.
8

22_RUVG_OM_EN_USC_t.book Page 253

SERVICING AND MAINTENANCE261
(Continued)
BRAKE SYSTEM
In order to ensure brake system performance, all
brake system components should be inspected
periodically. For the proper maintenance intervals
Úpage 244.
Brake Master Cylinder
The fluid in the master cylinder should be checked
when performing under hood services or
immediately if the “Brake Warning Light” is
illuminated. Be sure to clean the top of the master cylinder area
before removing the cap. If necessary, add fluid to
bring the fluid level up to the requirements
described on the brake fluid reservoir. With disc
brakes, fluid level can be expected to fall as the
brake pads wear. Brake fluid level should be
checked when pads are replaced. However, low
fluid level may be caused by a leak and a checkup
may be needed.
Use only manufacturer recommended brake fluid
Úpage 300.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting
or riding on the brake pedal can result in
abnormally high brake temperatures, excessive
lining wear, and possible brake damage. You
would not have your full braking capacity in an
emergency.
WARNING!
Use only manufacturer recommended brake
fluid Úpage 300. Using the wrong type of
brake fluid can severely damage your brake
system and/or impair its performance. The
proper type of brake fluid for your vehicle is
also identified on the original factory installed
hydraulic master cylinder reservoir.
To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep
the master cylinder reservoir cap secured at
all times. Brake fluid in a open container
absorbs moisture from the air resulting in a
lower boiling point. This may cause it to boil
unexpectedly during hard or prolonged
braking, resulting in sudden brake failure. This
could result in a collision.
Overfilling the brake fluid reservoir can result
in spilling brake fluid on hot engine parts,
causing the brake fluid to catch fire. Brake
fluid can also damage painted and vinyl
surfaces, care should be taken to avoid its
contact with these surfaces.
Do not allow petroleum-based fluid to contam -
inate the brake fluid. Brake seal components
could be damaged, causing partial or
complete brake failure. This could result in a
collision.
WARNING!
8

22_RUVG_OM_EN_USC_t.book Page 261

SERVICING AND MAINTENANCE263
FUSES
General Information
The fuses protect electrical systems against
excessive current.
When a device does not work, you must check the
fuse element inside the blade fuse for a break/
melt.
Also, please be aware that when using power
outlets for extended periods of time with the
engine off may result in vehicle battery discharge.

Blade Fuses
Underhood Fuses
The Power Distribution Center (PDC) is located in
the engine compartment near the battery. This
center contains cartridge fuses, mini-fuses,
micro-fuses, circuit breakers and relays. A label
that identifies each component is printed on the
inside of the cover.
Before any procedure is done on the PDC, make
sure engine is turned off.
Remove the cover by unlatching the two locks
located at each side of the PDC cover, avoid using
screwdrivers or any other tool to remove the cover,
since they may apply excessive force and result in
a broken/damaged part.
After service is done, secure the cover with its two
locks.
NOTE:The function and amperage of these fuses are
different, depending on vehicle trim level and
content.
WARNING!
When replacing a blown fuse, always use an
appropriate replacement fuse with the same
amp rating as the original fuse. Never replace
a fuse with another fuse of higher amp rating.
Never replace a blown fuse with metal wires or
any other material. Do not place a fuse inside
a circuit breaker cavity or vice versa. Failure to
use proper fuses may result in serious
personal injury, fire and/or property damage.
Before replacing a fuse, make sure that the
ignition is off and that all the other services
are switched off and/or disengaged.
If the replaced fuse blows again, contact an
authorized dealer.
If a general protection fuse for safety systems
(air bag system, braking system), power unit
systems (engine system, transmission
system) or steering system blows, contact an
authorized dealer.1 — Fuse Element
2 — Blade Fuse with a good/functional fuse
element
3 — Blade fuse with a bad/not functional fuse
element (blown fuse)8

22_RUVG_OM_EN_USC_t.book Page 263

SERVICING AND MAINTENANCE267
F41 ––Not Used
F42 40 Amp Green –Folding Seat Module *
F43 –20 Amp Yellow Fuel Pump Motor
F44 30 Amp Pink –CBC Feed #1 (Interior Lights)
F45 30 Amp Pink –Power Inverter *
F46 30 Amp Pink –Driver Door Module
F47 30 Amp Pink –Passenger Door Module
F48 ––Not Used
F49 25 Amp Clear –RR Sliding Door Module-LT *
F50 25 Amp Clear –RR Door Module-RT *
F51 30 Amp Pink –Front Wiper
F52 30 Amp Pink –Brake Vacuum Pump
F53 ––Not Used
F54 40 Amp Green –ESP-ECU And Valves
F55A –15 Amp BlueRadio Frequency HUB/ Keyless
Ignition System (KIN) / (Electronic Steering Lock-BUX ONLY) *
F55B –15 Amp BlueDVD / Video Routing Module (VRM) *
F56A –10 Amp Red
Front and Rear HVAC Control Module /
Occupant Classification Module (OCM)/ Electronic Steering Lock (ESL)

Cavity Cartridge Fuse Blade FuseDescription
* If Equipped
8

22_RUVG_OM_EN_USC_t.book Page 267

270SERVICING AND MAINTENANCE
F85 –20 Amp Yellow Cigar Lighter
F86 ––Not Used
F87 ––Not Used
F88 –20 Amp Yellow Front Heated Seats *
F89 –20 Amp Yellow Rear Heated Seats *
F90 ––Not Used
F91 –15 Amp BlueFront Ventilated Seats/Heated
Steering Wheel *
F92 –5 Amp Tan Security Gateway
F93 ––Not Used
F94 40 Amp Green –ESC Motor Pump
F95A –10 Amp RedUSB Charge Port — ACC RUN
F95B –10 Amp RedSelectable Fuse Location – USB IP
(Direct) B+
Cavity Cartridge Fuse Blade FuseDescription
* If Equipped

22_RUVG_OM_EN_USC_t.book Page 270

305

INDEX
A
About Your Brakes..........................................295Adding Engine Coolant (Antifreeze).................259Additives, Fuel................................................. 298AdjustDown............................................................ 42Forward......................................................... 42Rearward...................................................... 42Up................................................................. 42Air Bag.............................................................185Air Bag Operation........................................187Air Bag Warning Light....................... 185, 187Driver Knee Air Bag..................................... 191Enhanced Accident Response.......... 195, 242Event Data Recorder (EDR).........................242Front Air Bag............................................... 187If Deployment Occurs................................. 194Knee Impact Bolsters................................. 191Maintaining Your Air Bag System................ 196Maintenance............................................... 196Redundant Air Bag Warning Light...............185Side Air Bags............................................... 192Transporting Pets........................................214Air Bag Light................................... 95, 185, 214Air Cleaner, Engine
(Engine Air Cleaner Filter)................................250
Air Conditioner Maintenance.......................... 251Air Conditioner Refrigerant.................... 251, 252Air Conditioner System................................... 251Air Conditioning Filter.............................. 66, 252Air Conditioning, Operating Tips.........................65Air Filter.......................................................... 250Air PressureTires........................................................... 283AlarmArm The System............................................19Disarm The System.......................................19Security Alarm...............................................98Alterations/ModificationsVehicle............................................................ 8Antifreeze (Engine Coolant)................... 258, 299Disposal..................................................... 260Anti-Lock Brake System (ABS)........................ 158Anti-Lock Warning Light.....................................98Assist, Hill Start.............................................. 162Audio Jack.........................................................69Audio Systems (Radio).................................... 140Auto Up Power Windows....................................73Automatic Dimming Mirror.................................48Automatic Headlights........................................55Automatic Transaxle....................................... 111Automatic Transmission................................. 113
Adding Fluid...................................... 262, 300Fluid And Filter Change............................... 262Fluid Change...............................................262Fluid Level Check........................................ 262Fluid Type......................................... 262, 300Special Additives........................................ 262AutoPark.........................................................105AUX Cord........................................................... 69Auxiliary Electrical Outlet (Power Outlet)........... 70Axle Lubrication...............................................300
B
Back-Up Camera.............................................126Battery..................................................... 95, 248Charging System Light.................................. 95Jump Starting.............................................234Keyless Key Fob Replacement..................... 13Battery Saver Feature....................................... 57Belts, Seat.......................................................214Blind Spot Monitoring.....................................164Body Mechanism Lubrication..........................253B-Pillar Location.............................................. 279Brake Assist System........................................ 159Brake Control System, Electronic....................159Brake Fluid...................................................... 300Brake System........................................ 261, 295Anti-Lock (ABS)...........................................295

11

22_RUVG_OM_EN_USC_t.book Page 305

306

Fluid Check
....................................... 261, 300Master Cylinder........................................... 261Parking....................................................... 109Warning Light................................................ 95Brake/Transmission Interlock.........................113Brightness, Interior Lights................................. 58Bulb Replacement................................. 272, 274Bulbs, Light.................................. 215, 272, 274
C
Camera........................................................... 126Camera, Rear..................................................126Capacities, Fluid..............................................299Caps, Filler Fuel.............................................................127Oil (Engine)................................................. 247Radiator (Coolant Pressure)........................259Car Washes..................................................... 292Carbon Monoxide Warning..............................216CargoVehicle Loading
............................................ 77Cargo Area Cover.............................................. 77Cargo CompartmentLuggage Carrier............................................ 77Cargo Load Floor............................................... 77Cargo Tie-Downs............................................... 77Cellular Phone................................................. 157Certification Label........................................... 128Chains, Tire..................................................... 289Change Oil Indicator.......................................... 87
Changing A Flat Tire........................................ 220Chart, Tire Sizing............................................. 276Check Engine Light
(Malfunction Indicator Light)........................... 103Checking Your Vehicle For Safety................... 213Checks, Safety................................................ 213Child Restraint................................................ 197Child RestraintsBooster Seats............................................. 200Center Seat LATCH..................................... 206Child Seat Installation....................... 208, 210How To Stow An unused ALR Seat Belt................................................ 207Infant And Child Restraints........................ 198Lower Anchors And Tethers For Children................................................. 201Older Children And Child Restraints........... 199Seating Positions....................................... 201Using The Top Tether Anchorage................ 211Clean Air Gasoline.......................................... 296CleaningWheels....................................................... 288Climate Control..................................................60Manual..........................................................60Rear..............................................................64Cold Weather Operation................................. 107Compact Spare Tire........................................ 287Computer, Trip/Travel........................................94Contract, Service............................................ 302Cooling Pressure Cap (Radiator Cap).............. 259
Cooling System...............................................258Adding Coolant (Antifreeze)........................259Coolant Level.............................................. 260Cooling Capacity.........................................299Disposal Of Used Coolant........................... 260Drain, Flush, And Refill............................... 258Inspection......................................... 258, 260Points To Remember..................................260Pressure Cap.............................................. 259Radiator Cap...............................................259Selection Of Coolant (Antifreeze)...... 258, 299Corrosion Protection.......................................292Cruise Control.................................................119Cruise Light.....................................................101Customer Assistance...................................... 301Cybersecurity.................................................. 140
D
Daytime Brightness, Interior Lights................... 58Daytime Running Lights.................................... 54
Dealer Service.................................................249Defroster, Windshield.....................................214Delay (Intermittent) Wipers............................... 58Diagnostic System, Onboard........................... 102Dimmer SwitchHeadlight...................................................... 54DipsticksOil (Engine).................................................248Disable Vehicle Towing...................................240

22_RUVG_OM_EN_USC_t.book Page 306

309

Bulb Replacement
............................ 272, 274Cruise......................................................... 101Daytime Running.......................................... 54Dimmer Switch, Headlight............................ 54Engine Temperature Warning....................... 97Exterior............................................. 215, 274Fog................................................................ 56Headlights............................................. 54, 55High Beam/Low Beam Select....................... 54Instrument Cluster........................................ 54Intensity Control............................................ 58Interior.......................................................... 57Lights On Reminder............................... 54, 56Malfunction Indicator (Check Engine)........... 99Parade Mode (Daytime Brightness).............. 58Park............................................................101Passing.................................................. 54, 55Reading........................................................ 57Seat Belt Reminder....................................... 97Security Alarm............................................... 98Service........................................................272Side Marker................................................274Traction Control..........................................162Turn Signals...................... 54, 101, 215, 274Warning Instrument Cluster Descriptions........................ 97, 101Load Floor, Cargo.............................................. 77Load Shed Battery Saver Mode......................... 93Load Shed Battery Saver On............................. 93Load Shed Electrical Load Reduction................ 93
Load Shed Intelligent Battery Sensor................93Loading Vehicle....................................... 77, 128Tires........................................................... 279Low Tire Pressure System............................... 171Lubrication, Body............................................ 253Lug Nuts......................................................... 295Luggage Carrier.................................................77
M
Maintenance Free Battery.............................. 248Maintenance Schedule................................... 243Malfunction Indicator Light
(Check Engine)........................................ 99, 103ManualPark Release.............................................. 238Service....................................................... 304Map/Reading Lights..........................................57Marker Lights, Side......................................... 274Media Hub.........................................................69Memory Seat.....................................................49Methanol........................................................ 297Mini-Trip Computer............................................94Mirrors...............................................................48Automatic Dimming.......................................48Electric Remote.............................................49Exterior Folding.............................................50Heated..........................................................48Outside...................................................48, 49Rearview............................................. 48, 217Vanity............................................................48
Modifications/AlterationsVehicle............................................................ 8Monitor, Tire Pressure System........................171Mopar Parts.................................................... 303MP3 Control...................................................... 69Multi-Function Control Lever............................. 54
N
New Vehicle Break-In Period........................... 108
O
Occupant Restraints.......................................174Octane Rating, Gasoline (Fuel).............. 296, 299Oil Change Indicator.......................................... 87Reset............................................................ 87Oil Filter, Change.............................................250Oil Filter, Selection.......................................... 250Oil Pressure Light.............................................. 97Oil, Engine............................................. 249, 299Capacity...................................................... 299Checking.....................................................248Dipstick.......................................................248Disposal...................................................... 250Filter................................................. 250, 299Filter Disposal.............................................250Identification Logo...................................... 249Materials Added To.....................................250Pressure Warning Light................................. 97Recommendation............................. 249, 299Synthetic.....................................................250

11

22_RUVG_OM_EN_USC_t.book Page 309

311

Lap/Shoulder Belt Operation
......................178Lap/Shoulder Belt Untwisting.....................178Lap/Shoulder Belts..................................... 176Operating Instructions................................178Pregnant Women........................................182Pretensioners............................................. 182Rear Seat....................................................176Reminder....................................................175Seat Belt Extender......................................181Seat Belt Pretensioner................................182Untwisting Procedure..................................178Seat Belts Maintenance..................................293Seats................................................... 27, 42, 43Adjustment....................... 27, 28, 29, 30, 42Bench........................................................... 30Heated.......................................................... 43Power............................................................ 41Rear Folding................................................. 27Reclining....................................................... 28Seatback Release........................... 28, 29, 30Stow ‘n Go (Fold in Floor).............................. 36Tilting.............................................. 27, 28, 29Security Alarm................................................... 98Arm The System............................................ 19Disarm The System....................................... 19Selection Of Coolant (Antifreeze)....................299Sentry Key (Immobilizer)................................... 15Service Assistance..........................................301Service Contract..............................................302Service Manuals..............................................304
Shifting Automatic Transmission............................. 113Shoulder Belts................................................ 176Side View Mirror Adjustment.............................48Signals, Turn.......................... 54, 101, 215, 274Snow Chains (Tire Chains).............................. 289Snow Tires...................................................... 286Spare Tire Changing....................................... 220Spare Tire Stowage......................................... 228Spare Tires......................... 221, 286, 287, 288SpecificationsOil............................................................... 299Speed ControlCancel........................................................ 120Resume...................................................... 120Starting.................................................... 17, 104Button...........................................................15Cold Weather............................................. 107Engine Fails To Start.................................. 107Remote.........................................................17Starting And Operating................................... 104Starting Procedures........................................ 104Steering.......................................................... 116Tilt Column....................................................26Wheel, Heated...............................................26Wheel, Tilt.....................................................26Stow ‘n Go (Fold In Floor) Seats.........................36Stuck, Freeing................................................. 239Sunglasses Storage...........................................67Supplemental Restraint System – Air Bag...... 185
Sway Control, Trailer.......................................164Symbol Glossary.................................................. 8Synthetic Engine Oil........................................ 250System, Remote Starting.................................. 17
T
Telescoping Steering Column............................ 26Tie Down Hooks, Cargo..................................... 77Tilt Steering Column.......................................... 26Time DelayHeadlight...................................................... 54Tire And Loading Information Placard............. 279Tire Markings.................................................. 275Tire Safety Information.................................... 275Tire Service Kit................................................ 228Tire Stowage...................................................228Tires...........................215, 282, 286, 287, 291Aging (Life Of Tires).....................................285Air Pressure................................................ 282Chains........................................................ 289Changing.................................................... 220Compact Spare...........................................287General Information................ 282, 286, 287High Speed.................................................283Inflation Pressure.......................................283Jacking.............................................. 220, 223Life Of Tires................................................ 285Load Capacity.............................................279Pressure Monitoring System(TPMS)....................................88, 100, 171

11

22_RUVG_OM_EN_USC_t.book Page 311