oil filter Citroen BERLINGO MULTISPACE RHD 2015 2.G Owner's Manual
[x] Cancel search | Manufacturer: CITROEN, Model Year: 2015, Model line: BERLINGO MULTISPACE RHD, Model: Citroen BERLINGO MULTISPACE RHD 2015 2.GPages: 276, PDF Size: 12.21 MB
Page 14 of 276

12
Berlingo_2_VP_en_Chap01_vue-ensemble_ed02-2014
tEcHnIcAL dAtA - MAI nt E n A nc E
Identification markings, serial number
,  paint  code,  tyres  188
Snow
 chains Â
167
Windscreen
 /  headlamp  wash, Â
levels
144
Changing bulbs,
lighting
Â
168-172 Checks
Â
145-146
-
battery
,
-
gearbox,
-
air filter/passenger compartment filter,- oil filter,
-  particle  filter,
-
Â
parking
 brake,
-
Â
brake
 pads,
-
Â
brake
 drums,  discs.
Engine
 fuses Â
173,
 176
o
pening the bonnet, stay
140 Levels
143-144
-
d iesel additive,
- Â
engine
 oil  dipstick,
- Â
power
 steering  fluid,
- Â
brake
 fluid,
- Â
coolant.
Bleeding
 water,  Diesel  filter Â
146
W
arning
Â
lamps
Â
30-37
Under the bonnet-
d iesel
142
-
petrol
141
Fuel
 cut-off,  Diesel  priming Â
148
AdBlue
 additive Â
149-156
Dimensions
Â
180-183
Petrol
Â
engines
Â
/
Â
Weights
Â
184-185
Diesel
Â
engines
Â
/
Â
Weights
Â
184,
Â
186-187
Location
Page 19 of 276

17
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest
items in  the  bottom  of  the  boot,  as  close  as  possible  to  the Â
rear
 seats.
Limit
 the  loads  carried  in  the  vehicle  and  reduce  wind Â
resistance
 (roof  bars,  roof  rack,  bicycle  carrier,  trailer...). Â
Use
 a  roof  box  in  preference.
Remove
 roof  bars  and  roof  racks  after  use.
At
 the  end  of  winter,  remove  snow  tyres  and  refit  your Â
summer
 tyres.
Observe the recommendations on maintenance
Check the tyre pressures regularly, when cold, referring to the label  in  the  door  aperture,  driver's  side.
Carry
 out  this  check  in  particular:
-
Â
before
 a  long  journey,
-
at each change of season,
-
Â
after
 a  long  period  out  of  use.
d
on't forget the spare wheel and the tyres on any trailer or
caravan.
Have
 your  vehicle  serviced  regularly  (engine  oil,  oil  filter, Â
air
 filter,  passenger  compartment  filter...)  and  observe  the Â
schedule
 of  operations  recommended  in  the  maintenance Â
and
 warranty  guide.
With
 a  Blue  HDi  Diesel  engine,  if  the  SCR  system  is Â
faulty
 your  vehicle  becomes  polluting;  go  to  a  CITROËN Â
dealer
 or  a  qualified  workshop  without  delay  to  have  the Â
emissions
 of  nitrous  oxides  brought  back  to  the  legal  level.
When refuelling, do not continue after the third cut-off of
the
 nozzle  to  avoid  any  overflow.
At
 the  wheel  of  your  new  vehicle,  it  is  only  after  the  first Â
1
 800  miles  (3  000  kilometres)  that  you  will  see  the  fuel Â
consumption
 settle  down  to  a  consistent  average.
2
EcO-drIVInG
Motoring & Environment
Page 143 of 276

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
141
PEtrOL EnGInE
1. Screenwash reservoir.
2. Â
Fusebox.
3.
Â
Engine
 coolant  header  tank.
Battery
 connections:
+
 Positive  terminal.
-
 Negative  point  (earth).
Take
 care  when  working  under  the  bonnet.
4.  Brake  and  clutch  fluid  reservoir.
5. Â
Air
 filter.
6.
Â
Engine
 oil  dipstick.7.
 Engine  oil  filler  cap.
8. Â
Power
 steering  fluid  reservoir.
Under the bonnet
CHECkS
7
Page 144 of 276

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
142
dIESEL EnGInE
4. Brake and  clutch  fluid  reservoir.
5. Â
Air
 filter.
6.
Â
Engine
 oil  dipstick. 7.
 Engine  oil  filler  cap.
8. Â
Power
 steering  fluid  reservoir.
9.
Â
Priming
 pump.
1.
 Screenwash
Â
reservoir.
2.
Â
Fusebox.
3.
Â
Engine
Â
coolant
Â
header
Â
tank.
Battery
 connections:
+
 Positive  terminal.
-
 Negative  point  (earth).
Take
Â
care
Â
when
Â
working
Â
under
Â
the
Â
bonnet.
Under the bonnet
Page 146 of 276

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
144
cooling system
Only use the fluid recommended by the manufacturer.
Otherwise,
 you  risk  seriously  damaging Â
your
 engine.
When
 the  engine  is  warm,  the Â
temperature
 of  the  coolant  is  controlled Â
by
 the  engine  fan. Â
As
 this  fan  can Â
operate
 with  the  ignition  key  removed Â
and
 because  the  cooling  system  is Â
pressurised, wait for at least one hour
after the engine has stopped before
carrying
 out  any  work.
Slacken
 the  cap  by  1/4  of  a  turn  to Â
release the pressure to prevent any
risk
 of  scalding.  When  the  pressure Â
has
 dropped,  remove  the  cap  and  top Â
up
 the  level  with  coolant.
If
 fluid  has  to  be  added  frequently, Â
this
 indicates  a  fault  which  must  be Â
checked
 by  a  CITROËN  dealer  as Â
soon
 as  possible.
Power steering fluid level
The vehicle must be parked on level ground with  the  engine  cold.  Unscrew Â
the cap integrated with the gauge and
check
 the  level  which  must  be  between Â
the
 MIN  and  MAX  marks. In
 order  to  regenerate  the  filter,  you  are advised to drive at a speed higher
than
 40  mph  (60  km/h)  for  at  least  five  minutes
 as  soon  as  possible,  when Â
traffic
 conditions  permit  (until  the Â
message
 disappears  and  the  service Â
warning
 lamp  goes  off).
d
uring regeneration of the particle
emission
 filter,  the  noise  of  a  relay Â
operating
 may  be  heard  under  the Â
dashboard.
If
 the  message  is  still  displayed  and Â
if
 the  service  warning  lamp  remains Â
on, contact a CITR
o Ë n dealer or a
qualified
 workshop.
topping up
The
Â
level
Â
must
Â
be
Â
between
Â
the
Â
MIN
Â
and
Â
MAX
Â
marks
Â
on
Â
the
Â
expansion
Â
bottle.
Â
If
Â
more
Â
than
Â
1
Â
litre
Â
of
Â
fluid
Â
is
Â
required
Â
to
Â
top
Â
up
Â
the
Â
level,
Â
have
Â
the
Â
system
Â
checked
Â
by
Â
a
Â
CITROËN
Â
dealer
Â
or
Â
a
Â
qualified
Â
workshop.
Screenwash and headlamp
wash level
For best quality cleaning and for your safety , we would advise that you use
products
 of  the  CITROËN  range.
For
 optimum  cleaning  and  to  avoid Â
freezing,
 this  fluid  must  not  be  topped Â
up
 or  replaced  with  plain  water.
Capacity
 of  the  screenwash  reservoir: Â
approximately
 3  litres.
If
 your  vehicle  is  fitted  with  headlamp Â
washers, the capacity of the reservoir
is
 6  litres.
diesel additive level
( d iesel with particle
emission filter)
topping up
This  additive  must  be  topped  up  by Â
a
 CITROËN  dealer  or  a  qualified Â
workshop
 without  delay.
Waste products
avoid prolonged contact of used oil
with  the  skin.
Brake
 fluid  is  harmful  to  health  and Â
very
 corrosive.
Do
 not  dispose  of  used  oil,  brake  fluid Â
or coolant into drains or into the ground
but into the containers dedicated to this
use at a CITR
o Ë n dealer (France) or
an
 authorised  waste  disposal  site.
The
Â
minimum
Â
level
Â
of
Â
this
Â
additive
Â
is indicated by lighting of the service
warning
Â
lamp,
Â
accompanied
Â
by
Â
an
Â
audible
Â
signal
Â
and
Â
a
Â
message
Â
in
Â
the
Â
screen.
When this occurs with the engine
running it is due to the start of
saturation
Â
of
Â
the
Â
particle
Â
emission
Â
filter
Â
(exceptionally prolonged urban type
driving
Â
conditions:
Â
low
Â
speed,
Â
long
Â
traffic
Â
jams,
Â
...).
Levels
Page 147 of 276

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
145
cHEcKS
c
arbon filter and passenger compartment filterParticle filter (
d iesel)
Maintenance of the particle filter must be carried  out  by  a  CITROËN  dealer.
o
n acceleration after the vehicle has
been running for a prolonged period
at
 very  low  speed  or  at  idle,  you  may, Â
in
 exceptional  circumstances,  notice Â
the
 emission  of  water  vapour  at  the Â
exhaust.
Â
This
 water  vapour  does  not Â
have any adverse ef
fect on vehicle
handling
 or  the  environment.
Battery
At the start of summer or winter, have your battery  checked  by  a  CITROËN Â
dealer
 or  a  qualified  workshop.
Brake pads
Brake pad wear depends on the style of driving, in particular for vehicles
which are used in town, over short
distances.
 It  may  be  necessary  to Â
check
 the  thickness  of  the  pads,  even Â
between
 services.
Unless
 there  is  a  leak  on  the  circuit,  a Â
drop
 in  the  brake  fluid  level  indicates Â
that
 the  brake  pads  are  worn.
Brake disc / drum wear
For information on checking the brake disc /  drum  wear,  contact  a  CITROËN Â
dealer
.
Parking brake
Where the parking brake travel is too great or there is a reduction in the
performance
 of  the  system,  the  parking
 brake
 should  be  adjusted,  even  between
 services.
Have
 the  system  checked  by  a  CITROËN
 dealer
 or  a  qualified  workshop.
Oil filter
Change the filter regularly in accordance with  the  manufacturer's Â
servicing
 schedule.
An
Â
access
Â
flap
Â
allows
Â
replacement
Â
of
Â
the
Â
filters.
The
Â
carbon
Â
filter
Â
permits
Â
continuous
Â
and
Â
effective
Â
filtering
Â
of
Â
dust.
If
Â
the
Â
passenger
Â
compartment
Â
filter
Â
becomes
Â
blocked,
Â
this
Â
may
Â
reduce
Â
the
Â
performance
Â
of
Â
the
Â
air
Â
conditioning
 system
Â
and
Â
generate
Â
unpleasant
 odours.
W
e
Â
recommend
Â
the
Â
use
Â
of
Â
a
Â
combined
Â
passenger
Â
compartment
Â
filter.
Â
By
Â
means
Â
of
Â
its
Â
second
Â
special
Â
active
Â
filter
,
Â
it
Â
contributes
Â
to
Â
the
Â
purification
Â
of the air breathed by the occupants
and the cleanness of the passenger
compartment
Â
(reduction
Â
of
Â
allergic
Â
symptoms,
Â
unpleasant
Â
odours
Â
and
Â
greasy
Â
deposits).
Refer to theservicing and warranty
booklet
Â
for
Â
the
Â
replacement
Â
interval
Â
for
Â
these
Â
components. Depending
 on  the  environment  (dusty Â
atmosphere...)
 and  the  use  of  the Â
vehicle
 (urban  driving...),  change  them Â
twice
 as  often  if  necessary.
Checks
CHECkS
7
Page 148 of 276

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
146
Bleeding water from the diesel
filter Manual gearbox
Have the level checked in accordance with the
 manufacturer's  servicing  schedule.
Only use products recommended by CITRo Ë n or products
of
 equivalent  quality  and Â
specification.
In
Â
order  to  optimise  the  operation Â
of
Â
units  as  important  as  the  braking Â
system,
 CITROËN  selects  and  offers Â
specific
 products.
In
Â
order  to  avoid  damaging  the Â
electrical units, high pressure washing
to
Â
clean  the  engine  compartment  is Â
strictly
 prohibited.
After
 washing  the  vehicle  dampness, Â
or
Â
in
 winter,  ice  may  form  on  the  brake Â
discs
 and  pads:  braking  efficiency  may Â
be
Â
reduced.  Make  some  light  brake Â
applications to dry and de-ice the
brakes.
If
Â
this
Â
warning
Â
lamp
Â
comes
Â
on,
Â
bleed
Â
the
Â
filter.
Â
Otherwise
Â
bleed
Â
regularly
Â
each
Â
time
Â
the
Â
engine
Â
oil
Â
is
Â
changed.
H
d
i engines use advanced
technology.
 All
Â
work
Â
requires
 special training, which is assured
by
Â
a
Â
CITROËN
Â
dealer.
Depending
Â
on
Â
country
Â
of
Â
sale.
To drain the water, unscrew the bleed
screw
Â
located
Â
on
Â
the
Â
filter.
o
perate until all of the water no longer
flows
Â
in
Â
the
Â
transparent
Â
pipe,
Â
then
Â
tighten
Â
the
Â
bleed
Â
screw.
checks
Page 187 of 276

185
Berlingo_2_VP_en_Chap09_Caract-technique_ed02-2014
Petrol Engines / Weights
5-seatEngine Gearbox GearsEngine oil
capacity* (litres)
u
nbraked
trailer (kg)
r
ecommended nose
weight (kg)
1.6 90 hp Manual 53.25 735 50
1.6 110 hp Manual53.25 750 55
1.6 V
t
i 100 hp Manual 54.25 690 70
1.6 V
t
i 120 hp Manual 54.25 690 70
7-seat Engine Gearbox GearsEngine oil
capacity*
(litres)
u
nbraked
trailer (kg)
r
ecommended nose
weight (kg)
1.6 110 hp Manual53.25 750 70
1.6 V
t
i 120 hp Manual 54.25 750 70
*
 Capacity  with  filter  replacement.
TECHnICaL daTa
9
Weights
Page 188 of 276

186
Berlingo_2_VP_en_Chap09_Caract-technique_ed02-2014
diesel Engines / Weights
5-seatEngine Gearbox GearsEngine oil
capacity* (litres)
u
nbraked
trailer (kg)
r
ecommended nose
weight (kg)
1.6 H
d i 75 hp Manual 5-740 50
1.6 H
d i 75 hp FAP Manual 5-715 70
1.6 H
d i 90 hp Manual 53.75 740 55
1.6 H
d i 90 hp FAP Manual 53.75 750 55
1.6 H
d i 92 hp E c OManual 53.75 715 70
1.6 H
d i 92 hp FAP Manual 53.75 715 70
1.6 e-H
d I 92 hp
E
c O Manual
5
3.75 690
70
Electronic 6 75070
1.6 e-H
d i 92 hp FAP Manual
5
3.75 690
70
Electronic 6 75070
1.6 H
d i 110 hp FAP Manual 53.75 750 55
1.6 H
d i 112 hp FAP Manual 53.75 735 70
FAP:
 particle  filter.
e-H
d i: Â
model
 equipped  with  Stop  &  Start.
*
 Capacity  with  oil  filter  replacement.
Weights
Page 189 of 276

 187
Berlingo_2_VP_en_Chap09_Caract-technique_ed02-2014
7-seatEngine Gearbox GearsEngine oil
capacity* (litres)
u
nbraked
trailer (kg)
r
ecommended nose
weight (kg)
1.6 H
d i 90 hp Manual 53.75 750 70
1.6 H
d i 90 hp FAP Manual 53.75 750 70
1.6 H
d i 92 hp FAP Manual 53.75 750 70
1.6 e-H
d I 92 hp FAP Manual 53.75 750 70
1.6 H
d i 110 hp FAP Manual 53.75 750 70
1.6 H
d i 112 hp FAP Manual 53.75 750 70
FAP:
 particle  filter.
e-H
d i: Â
model
 equipped  with  Stop  &  Start.
*
 Capacity  with  oil  filter  replacement..
tEcHnIcAL dAtA
9
Weights