fuel filter Citroen C4 PICASSO RHD 2014.5 1.G Owner's Manual

8
Maintenance - Technical data
Petrol weights 330 -331
Diesel   weights  3 35 -337
Running
 
out
 
of
 
fuel,
 
Diesel
 
3

12
Checking
 
levels
 
3

13 -316
-
 
o

il
-
 
b

rake
 
fluid
-
 c

oolant
-
 
s

creenwash/headlamp
 
wash
 
fluid
Checking
 
components
 
3

17-318
-
 
a

ir
 
filter
-
 p

assenger
 c

ompartment
 f

ilter
-
 
o

il
 
filter
-
 
e

lectric
 
parking
 
brake
-
 
b

rake
 
pads
 
/
 
discs
Changing
 bu

lbs
 2

72-280
-
 
f

ront
-
 
r

ear Opening
 
the
 
bonnet
 
3

05
Under
 
the
 
bonnet,
 
petrol
 
3

06
Under
 
the
 
bonnet,
 
Diesel
 
3

07
Petrol
 
engines
 
3

28 -329
Diesel
 
engines
 
3

32-334
AdBlue
® additive 3 19 -327Identification
 ma
rkings
 3
40
Dimensions
 33
8-339
12V
 
battery  
2
88 -290
Load
 
reduction,   economy   mode  
2
91
Engine
 c

ompartment
 
f

uses
 28
1-282,
 28
6-287
over view

10
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   manufacturer's   service   schedule.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrous   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(

3 000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down  
t

o a   consistent   average.
Eco-driving

307
The various caps and covers allow access for checking   the   levels   of   the   various   fluids,   for  
r

eplacing   certain   components   and   for   priming  
t

he   fuel   system.
Diesel engines
1. Screenwash   and   headlamp   wash   reservoir.
2. C oolant r eservoir.
3.
 B

rake   fluid   reservoir.
4.
 B

attery   /   Fuses.
5.
 F

usebox.
6.
 A

ir   filter.
7.
 E

ngine   oil   dipstick.
8.
 E

ngine   oil   filler   cap.
9.
 P

riming
 pu
mp*.
*
  According   to   engine.
8
Checks

316
Avoid prolonged contact of used oil or fluids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do
  not   discard   used   oil   or   fluids   into  
s

ewers   or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive level
(Diesel with particle filter)
The additive reservoir low level is indicated   by   fixed   illumination   of  
t

his   warning   lamp,   accompanied   by  
a

n   audible   signal   and   a   message  
t

hat   the   particle   filter   additive   level  
i

s   too   low.
The
 
warning
 
lamp
 
comes
 
on
 
when
 
the
 
ignition
 
i

s
 
switched
 
on,
 
or
 
every
 
time
 
the
 
stalk
 
is
 
o

perated,
 
until
 
the
 
reservoir
 
is
 
refilled.
Next
 
time
 
you
 
stop,
 
refill
 
the
 
screenwash
 
/
 
h

eadlamp
 
wash
 
reservoir.
Screenwash/headlamp
wash level low
In the case of vehicles fitted with h eadlamp   washers,   when   the   fluid r

eservoir   low   level   is   reached   this
 w

arning   lamp   comes   on   in   the
 i

nstrument   panel,   accompanied   by   an
 a

udible   signal   and   a   message.
Checks

319
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing u
rea,
 
a
 
catalytic
 
converter
 
turns
 
up   to   85%  
o

f
 
nitrous
 
oxides
 
(NOx)
 
into
 
nitrogen   and  
w

ater,
 
which
 
are
 
harmless
 
to
 
health   and   the  
e

nvironment. The
  AdBlue
® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
8
Checks

328
Petrol engineV Ti 120e -THP 130 THP 15 0
Gearbox Manual
(5-speed) Manual
(5-speed) Manual
(6-speed)
Model code:
3D... 3E... 3A... 5FS0/1
HNYM/1S
  -   M/2SM5FV8
  -   8/1
Cubic capacity (cc) 1
  5981
  1991
  598
Bore
  x   stroke   (mm) 77
  x   85.875
  x   90.577
  x   85.8
Max
  power*:   EU   standard   (kW) 8896115
Max
  power   engine   speed   (rpm) 6
  0005
  5006
  000
Max
  torque:   EU   standard   (Nm) 160230 240
Max
  torque   engine   speed   (rpm) 4
  2501
  7501
  400
Fuel UnleadedUnleadedUnleaded
Catalytic converter yesyesyes
Oil capacity (in litres)
(with
  filter   replacement) 4.25
4.254.25
Petrol engines and gearboxes
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

329
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Petrol engine
THP 150 / 165e-THP 165
Gearbox Automatic
(6-speed) Automatic
(6-speed)
Model code:
3D... 3E... 3A... 5 GX
 5
GYA - A /1- A / 2- D -Y-Y/1-Y/ 2
5GX   5GZ A
Cubic capacity (cc) 1   598
1   598
Bore   x   stroke   (mm)
77   x   85.8
77   x   85.8
Max   power*:   EU   standard   (kW)
110   /   121
121
Max   power   engine   speed   (rpm)
6   000
6   000
Max   torque:   EU   standard   (Nm)
240 240
Max   torque   engine   speed   (rpm)
1   400
1   400
Fuel UnleadedUnleaded
Catalytic converter yesyes
Oil capacity (in litres)
(with   filter   replacement)
4.25
4.25
9
Technical data

332
Diesel engineHDi 90e-HDi 90
Airdream BlueHDi 100
Gearbox Manual
(5-speed) Electronic
 g

earbox
(6-speed) Manual
(6-speed)
Model code:
3D... 3E... 3A... 9HP0/1
9HP8/1PS/2PS BHY6/1S
  -   6/2SM
Cubic capacity (cc) 1
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.3
Max
  power*:   EU   standard   (kW) 6873
Max
  power   engine   speed   (rpm) 4
  0003
  750
Max
  torque:   EU   standard   (Nm) 230254
Max
  torque   engine   speed   (rpm) 1
  7501
  750
Fuel
die

sel
die
sel
Catalytic converter yesyes
Particle filter yesyes
Oil capacities (in litres)
(with
  filter   replacement) 3.75
3.75
.../S:
  e-HDi   model   fitted   with   Stop   &   Start.
3D...:
 

CITROËN   C4   Picasso   (5 -seat).
Diesel engines and gearboxes
3E...: CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
*
 
The
 
maximum
 
power
 
corresponds
 
to
 
the
 
value
 
type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

333
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
HDi 115e-HDi 115
Airdream
Gearbox Manual
(6-speed) Manual
(6-speed) Electronic
(6-speed)
Model code:
3D... 3E... 3A... 9HC-8/1
9HC8/1S9HC8/1PS   -   8/2PS
Cubic capacity (cc) 1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
85 85
Max   power   engine   speed   (rpm)
3   600
3   600
Max   torque:   EU   standard   (Nm)
270 270   -   285
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel
die
sel
die
sel
Catalytic converter yesyes
Particle filter noyes
Oil capacities (in litres)
(with   filter   replacement)
3.75
3.75
*   The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
9
Technical data

334
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
BlueHDi 115/120BlueHDi 135/15 0
Gearbox Manual
(6-speed) Manual
(6-speed) Automatic
(6-speed)
Model code :
3D... 3E... 3A... BHZ/BHXM/S-M/1SAHX/AHR/AHV/

AHS   M/S   -   M/1S
AHXT/S   -   T/1S
Cubic capacity (cc) 1   560
1   997
Bore   x   stroke   (mm)
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
85   /   88
11 0
Max   power   engine   speed   (rpm)
3   500
3   750
Max   torque:   EU   standard   (Nm)
300 370
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel
die
sel
die
sel
Catalytic converter yesyes
Particle filter yesyes
Oil capacities (in litres)
(with   filter   replacement)
-
6 .1
*   The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data