oil level DACIA SUPERNOVA 2004 User Guide

AIR CONDITIONING
62
62 - 9
PRESSURE CONTROLLER
(low pressure, high pressure, medium pressure, in accordance
with the specification) or pressure capture
- low pressure – disconnect when the pressure in the low pressure circuit is lower than
1,96 +/-0,2 bar , reestablishing at a higher pressure than 2,16 +/- 0,2 bar; - higher pressure – disconnect when the pressure in the high pressure circuit is higher than
31,4 +/-2 bar , reestablishing at a higher pre ssure than 25,5 +/-2 bar; - medium pre ssure - start s the bl ower on t he second level speed, when t he pressure i s
higher than 17,7+/-1bar and stops the blower at a lower pressure 13,7+/- 1,2.
Thermostatic expansion valve allows the reduction of the refrigerant liquid pressure which is
coming from t he condenser, passing through the tank filter and i s continuously adjusting the
refrigerant flow from the evaporator, to reach the compressor in vapor condition. PRESSURE CONTROLLER
The good operation of the air conditioning unit is ensured by a dryer filter tank that ha s the
purpose to protect the unit. The filter’s purpose is to absorb the eventually solid particles found
in the oil and refrigerant liquid circulation.
The interception is needed as they might block the operation of the thermostatic expansion
valve or may produce the compressor mobile parts worn or gripping.
DETECTION OF REFRIGERANT F LUID LEAKAGE
In order to detect the refrigerant liquid leakage, it is used a detector, calibrated to detect
leakage of 9gr. /year.
vnx.su

83
INSTRUMENT PANEL
CONNECTOR C
1. Instrum ent panel lighting
2. Ground
3. Anti starting indicator
4. Supply (+ IC)
5. Free
6. Injection failure indicator
CO NNECTOR D
1. Battery charging circuit failure indicator
2. Fuel minimum level warning
3. Free
4. Free
5. Free
6. Free
7. Free
8. Free
83-2
The corresponden
ce between the positions from A,B,C,D connectors of the instrument panel
and the components of the vehicle electric equipment is the following :
CONNECTOR A
1. Free
2. Rear window defrosting indicator
3. RPM
4. Cooling fluid temperature indicator
5. Oil pressure warning
6. Cooling fluid temperature warning
7. Left turning indicator
8. Left turning indicator
9. Hazard lights indicator
10. Instrument panel ground
CONNECTOR B
1. High beam indicator
2. Free
3. Free
4. Right turning indicator
5. Right turning indicator
6. Supply ()+DC)- after contact
7. Hand brake, braking system failure warning
8. Brake pads wear indicator
9. Free CO
NNECTORS ( until 01.06.2001)
vnx.su

83
INSTRUMENT PANEL
83-4
CO
NNECTOR X
1. Low beam indicator
2. Anti starting indicator
3. Supply(+IC) anti starting indicator
4. Injection failure indicator
5. Oil pressure warning
6. Water temperature indicator
NOTE
In case of the interventions on the instrument panel, check the existence of the
rubbe r i solati ng ele ments on the windsc re en lower c ross bar, pl ac e d behi nd the
instrument panel. For the vehicles corresponding to the pollution norm EURO 2000, at the X c onnector,
position 4 is “ OBD anti-pollution failure indicator”. The i nstrument panel is provided with thre e connectors having the following pl ugs
correspondence:
CONNECTOR V
1. Instrum ent panel lighting
2. Ground
3. Rear window defrosting indicator
4. High beam indicator
5. RPM
6. Supply (+DC) after contact
7. Free
8. Ground
9. Right turning indicator
10. Left turning indicator CONNECTOR Z
1. Hazard indicator
2. Water temperature warning
3. Supply (+DC) after contact
4. Ground
5. ICP and handbrake warning
6. Brake pads wear warning
7. Fuel level indicator
8. Fuel level minimum warning
9. Battery charging indicator
CO
NNECTORS(after 01.06.2001)
vnx.su

83
INSTRUMENT PANEL
OIL PRESSURE WARNING LIGHT STILL ON
AFTER ENGINE STARTING
Check the oil pressure
The pressure is correct.
Replace the oil pressure switch. The pressure is not correct.
There is a failure in the oil circuit.
OIL PRESSURE WARNING LIGHT IS NOT ON
WHEN CONTACT SWITCH ON
Place the wire from the oil pressure switch to the ground.
Wa r ning light is not on.
Check if the bulb is not burnt.
Warning light is on. Replace the oil pressure
switch.
Burnt bulb. Replace it. Bulb is not burnt . Check the bulb
supply wiring and fix it.
FUEL LEVEL INDICATOR
SHOWING ALWAYS FULL
Disconnect the connection wire t o the probe.
The indicator comes back
to zero. Re place the probe. The indicator
does not come to zero.Is there
any ground short-circuit of the connection
wi re to the probe?
Yes. Fix the wiring layout. No. Replace the indicator.
83-7
DIAGNOSTIC
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 11
39HANDBRAKE INDICATOR AND BRAKING SYSTEM FAILURE S S S
40 FUEL LEVEL INDICATOR CIRCUIT S S S
41 OIL PRESSURE INDICATOR CIRCUIT S S S
42 DIAG NOSTIC SOCKET S S S
43 INSTRUMENT PANEL AE1 S
44 INSTRUMENT PANEL AE2, AE3 S S
45 WA TER TEMPERATURE INDICATOR CIRCUIT S S S
46 BRAKE PADS WEAR INDICATOR CIRCUIT S S S
47 VEHICLE SPEED S S S
48 SOUND W ARNING S S S
49 REAR WINDOW DEFROSTING S S S
50 WINDSCREEN WIPER-WASHING S S S
51 REAR FOG LAMP S S S
52 FOG HEADLIGHTS AE2, AE3 S S
53 MEETING LIGHTS S S S
54 REVERSE DRIVING LIGHTS S S S
55 PA R K I N G LIGHTS S S S
56 ROAD LIGHTS S S S
57 STOP LIGHTS AE1, AE2 S S
58 STOP LIGHTS AE2(aileron) O
59 STOP LIGH TS AE2(CA), AE3 O S
60 TURNING AND HAZARD LIGHTS AE1 S
61 TURNING AND HAZARD LIGHTS AE2, AE3 S S
Note : these electr ic diagrams are valid for vehicle manufactured until 01.06.2001; AE1
( Confort), AE2 (Rapsodie), AE3 (Clima) represent equipping levels of the vehicle.
FUNCTIONAL DIAGRAMS LIST
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 13
191
192
193
194
195
196
199
205
209
210
212Cooling blower low speed control relay
Ignition coil
FLASH relay
Hatchback contact separation diode
Upstream oxygen sensor
C
hock sensor
Anti-intrusion indicator LED
Braking system ICP
AC pressure sensor (pressure controller)
Front ashtray lighting
Climate control blower control relay
700
778
857
871
887
927
993
109 1
120 2
133 5
142 8Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel level transmitter and electric pump
Oil pressure contact
Lights, turning lights and horn switch
Electronic clock
Windscreen wiper motor
ELECTRIC COMPONENTS INDEX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 16
Windscreen wiper timer
FLASH relay
Climate control lighting
AC starting button
AC relay ( on board)
Right front door actuator
Right rear door actuator
Right front door loud speaker
Right rear loudspeaker
Fuel level transmitt er and electric pump
Trunk lighting la mp
Left rear loud speaker
Left rear door actuator
Left fron t door actuator
Left fr ont door loud speaker
Right front door contact
Right volumetric sensor
Left vo lumetric sensor
Right front ceiling lamp
Hatchb ack contacts
Handbrake contact
Anti-starting bushing
Le ft front ceiling lamp
Anti-intrusion indicator LED
Left fron t door contact
UCE d ecoder
Siren
Vehicle speed transducer
Engine hood contact
Doors closing switch
UCE anti-intrusion
( until 01.06.2001)
Inje ctor 1
Inje ctor 2
Inje ctor 3
Inje ctor 4
Atmospheric pressure sensor
Detonation sensor
Starter
In jection air temperature sensor
Valve potentiometer
Step-by step engine
Alternator
Ignition c oil
Canister purging valve
AC pressure sensor(pressure controller)
Diagnostic socket
AC compressor clutch
Upstream oxygen sensor
Cooling blower and AC
Blower resistance for AC
Oil pressure contact
Injec tion computer
RPM sensor
Reverse driving contact
AC compressor clutch control relay (E)
Water temperature sensor
Blower lower speed control relay (B)
E ngine compartment fuse and relays box
Motor fan control relay ( C)
Fog headlamps control relay(A)
Fuel pump control relay (H)
Actuators relay(D)
Chock sensor
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32 33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
LOCATION OF ELECTRIC COUPLING ON THE VEHICLE
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 25
196 INJECTOR 489-106
199 FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP 89-146
200 REAR WINDOW DEFROSTING 89-149
205 OIL PRESSUR E CONTAC T 89-98
209 CLIGHTS, TURNING LIGHTS, HORN SWITCH 89-114
210 ELECTRONIC CLOC K 89-128
212 WINDSCREEN WIPER MOTOR 89-112
216 RIGHT FRONT BRAKE PAD 89-127
217 LEFT FRONT BRAKE PAD 89-127
221 WINDSCREEN WASHING PUMP 89-125
222 VALVE POTENTIOMETER 89-104
225 DIAGNOSTIC SOCKET 89-135
226 RIGHT HEADLAMP 89-125
227 LEFT HEADLAMP 89-125
244 WATER TEMPERATURE SENSOR 89-99
247 INSTRUMENT PANEL 89-135
250 SPEED TRANSDUC ER 89-117
255 RIGHT FRONT TURNING LAMP 89-126
256 LEFT FRONT TURNING LAMP 89-126
260 COCKPIT FUSE AND RELAYS BOX 89-119
261 R ADIO 89-128
262 COOLING MOTOR FAN (for vehicles with AC) 89-107
267 RIGHT SIDE SIGNALING LAMP 89-126
268 LEFT SIDE SIGNALING LAMP 89-127
272 INJECTION AIR TEMPERATURE SENSOR 89-103
298 CLIMATE CONTROL LIGHTING 89-131
319 AC STARTING BUTTON 89-131
321 MOTOR FAN RESISTANCE ( for vehicles with AC) 89-108
328 LEFT FRONT CEILING LAMP 89-149
329 RIGHT FRONT CEILING LAMP 89-149
371 CANISTER PURGING VALVE 89-101
427 UCE ANT I-INTRUSION 89-143
438 ENGINE HOOD CONTACT 89-118
442 SIREN 89-118
454 RIGHT VOLUMETRIC SENSOR(Rx) 89-142
454 LEFT VOLUMETRIC SENSOR (Tx) 89-142
474 AC R ELAY (on board) 89-129
503 UCE DECODER 89-115
560 HATCHBAC K C ONTACT 89-146
597 ENGINE RELAYS AND FUSE BOX ( for vehicles without AC) 89-94
597 ENGINE RELAYS AND FUSE BOX ( for vehicles with AC) 89-96
600 CLIMATE CONTROL B LOWER 89-130
639 STOP-S3 LAMP (on roof) 89-150
639 STOP[ -S3 LAMP (in aileron) 89-150
649 STEP-BY-STEP ENGINE 89-103
654 ANTI-STARTING BUSHING 89-116
778 IGNITION COIL 89-100
857 FLASH RELAY 89-116
887 SUPSTREAM OXYGEN SENSOR 89-100
927 CHOCK SENSOR 89-102
993 ANTI-INTRUSION INDICATOR LED 89-142
WIRE FUNCTIONS INDEX IN CONNECTORS AND COUPLINGS
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 91
Position SectioningDestination
A1 0,5 64D RIGHT TURNI
NG LIGHTS CONTROL
A2 0,35 31A WATER TEMPERATURE W ARNING
A3 0,35 28A OIL PRESSURE W ARNING
A4
A5 0,35 42A WATER TEMPERA TURE SIGNAL
A6 0,35 H7 RPM-METER SIGNAL > INJECTION COMPUTER
A7 0,35 15A REAR WINDOW DEFROSTING INDICATOR-CONTROL
B1 0,75 AP10
+ AFTER PROTECTED CONTACT > FUSE OUTLET F01
B2 0,35 RPD PROTECTED RIGHT HIGH BEAM
B3 0,35 64DR IGHT TURNI NG LIGHTS CONTROL
B4 0,35 38AS
AIR-CONDI TIONING COMPRESSOR CONNECTION SIGNAL
B50,35 H1HANDBRAKE INDICATOR-CONTROL
B5 0 , 35 H1 I CP INDICATOR-CONTROL
B6 0,35 H12BRAKE PADS WEAR INDICA TOR-CONTROL
B7 0,62 JD + ALTERNATOR EXCITA TION
C1 0,35 47A - FUEL MINIMAL LEVEL WARNING
C2 0,35 41A SIGNAL + FUEL LEVEL TRANSMITTER
C3 0,35 3FHI NJECTION FAILURE INDICATOR-CONTROL
C4 0 , 35 8 0 T ANTI-STARTING IN DICATOR-CONTROL
C5 0,35 HKDIAGNOSIS SIGNAL LINE K > INJECTION COMPUTER
C5 0,35 HKDIAGNOSIS SIGNAL LINE K > UCE DECODER
C6 0,35 HLDIAGNOSIS SIGNAL LINE L > IN JECTION COMPUTER
C6 0,35 HLDIAGNOSIS SIGNAL LINE L > UCE DECODER
C7 0 , 35 MMASS
DASHBOAR D/FRONT W IRING CONNEC TION
FRONT WIRING C ONNECTION
CONNECTIONSB4101
12 3 56 7
C
B
A
MA
47A
X
AP10
R-G
41A
X

R PD
X
3FH
X

64D
X
80T
X

38AS
X N-G
2JD
X
R
107 HK HL M
H1 2
H1
X
64D 31A 28A H715A
XX X X X X
CO
NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 92
DASH
BOARD WIRING CONNECTION
CONNECTIONSB41
01
Position Sectioning Destination
A1 0,35 64D RIGHT TURNING LIGHTS CONTROL
> INDICATOR
A2 0,35 31A INSTRUME NT PANEL > WATER TEMPERATURE WARNING
A3 0,35 28A INSTRUMENT PANEL > OIL PRESSURE W ARNING
A4
A5 0,35 42A SIGNAL + WATER TEMPERA TURE
A6 0,35 H7 RPM-METER SIGNAL
A7 0,35 15A REAR WINDOW DEFROSTING INDICATOR-CONTROL
B1 0,75 AP10 + AFTER PROTECTED CONT ACT
B2 0,35 RPD PROTECTED RIGHT HIGH BEAM > INDICATO R
B3 0,35 64DRIGHT TURNING LIGHTS CONTROL > INDICATOR
B4 0,35 38AS
AIR-CONDITIONING COMPRESSOR CONNECTION SIGNA L > RELAY
B5 0,35 H1ICP HANDBRAKE INDICATOR-CONTROL
B6 0,35 H12BRAKE PADS WEAR INDICA TOR-CONTROL
B7 0,62 JD + ALTERNATOR EXCITA TION > INSTRUMENT PANEL
C1 0,35 47A - FUEL MINIMAL LEVEL WARNING
C2 0,35 41A SIGNAL + FUEL LEVEL TRANSMITTER
C3 0,35 3FHI NJECTION FAILURE INDICATOR-CONTROL
C4 0 , 35 80T A N TI-STARTING IN DICATOR-CONTROL
C5 0,35 HKDIAGNOSIS SIGNAL LINE K
C6 0,35 HLDIAGNOSIS SIGNAL LINE L
C7 0 , 35 MMASS
MA
76 5 32 1
C
B
A
R 107
M HL HK 8 0T 3FH 41A 47A
2JD H1 2 H1 38AS 64D RPD AP10
15A H7 42A 2 8 A 3 1 A 6 4 D
N X X X X X X
XX X X X X R-G
X X X X X X
CO NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su