7A–22 HEATING AND VENTILATION SYSTEM
DAEWOO M-150 BL2
D18A515A
HEATER HOSES
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Tool Required
DW100–020 Hose Remover/Installer.
Removal Procedure
1. Disconnect the negative battery cable.
2. Drain the coolant.
3. Remove the heater inlet hoses.
Remove the air cleaner housing.
Raise and suitably support the vehicle.
Disconnect the hose from the heater module using
a hose remover DW100–020 (1).
D108A516
Lower the vehicle.
Disconnect the hose from the thermostat (2).
D18A517A
4. Remove the heater outlet hoses.
Raise and suitably support the vehicle.
Disconnect the hose from the heater module using
a hose remover DW100–020 (1).
Disconnect the B
+ terminal from the starter. Refer
to Section 1E, Engine Electrical.
D108A518
Disconnect the heater hose from the engine (2).
HEATING AND VENTILATION SYSTEM 7A–23
DAEWOO M-150 BL2
D108A521
Installation Procedure
1. Install the heater outlet hoses.
Connect the heater hose to the engine (1).
Connect the B
+ terminal to the starter. Refer to
Section 1E, Engine Electrical.
D18A522A
Connect the hose to the heater module using a
hose installer DW100–020 (2).
Lower the vehicle.
D108A519
2. Install the heater inlet hoses.
Connect the hose to the thermostat (1).
Raise and suitably support the vehicle.
DW100–020
D18A520A
Connect the hose to the heater module using a
hose installer DW100–020 (2).
Lower the vehicle.
Install the air cleaner housing.
3. Refill the coolant. Refer to Section 1D, Engine Cool-
ing.
4. Connect the negative battery cable.
9A–10 BODY WIRING SYSTEM
DAEWOO M-150 BL2
FUSE CHART
FuseRating/ SourceCircuit
Ef1 (Engine Fuse)50ABATABS
Ef240ABATIgnition Switch, Instrument Panel Fuse Block
(F5, F11 ~ F13)
Ef310ABATFuel cut-off Switch (Inertia Switch)
Ef410AIGN 1Fuel, EBCM, Generator, VSS, Fuel Pump Relay, Main Relay,
Ignition Coil
Ef5––Not Used
Ef620ABATBlower Motor
Ef715ABATRear Window Defogger
Ef810ABATHeadlamp Hi Beam, Right Side
Ef910ABATHeadlamp Hi Beam, Left Side
Ef1010ABATHeadlamp Lo Beam, Right Side
Ef1110ABATHeadlamp Lo Beam, Left Side
Ef1210A58Tail and Illumination Lamps, Right Side
Ef1310A58Tail and Illumination Lamps, Left Side
Ef1410ABATA/C Compressor
Ef1530ABATRadiator Fan
Ef1610A–Spare
Ef1710ABATHorn
Ef1820ABATHeadlamp Relay, Hi Beam Passing, DRL Module
Ef1915ABATECM, Main Relay
Ef2015ABATFront Fog Lamp
Ef2115A–Spare
F1 (Fuse)10AIGN 1Cluster, Clock, IMMO, Anti-Theft Control Unit,
DRL Relay
F210AIGN 1SDM
F325AIGN 1Hazard Switch, DRL Module
F410AIGN 1Turn Signal Lamp
F515ABATStop Lamp
F610AACCAudio
F720AACCCigar Light
F815AIGN 2Wiper
F915AIGN 2Rear Wiper Motor, Front & Rear Washer, Backup Lamp
F1010AIGN 2Auto Miror Switch
F1110AEf2IMMO, Audio, Room Lamp
F1215AEf2Hazard, Clock
F1320AEf2Anti-Theft Control Unit, Door Lock
F1420ASTStarter Motor
