brake fluid DODGE AVENGER 2009 2.G User Guide

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Master Cylinder - Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the brake system warning light indicates system fail-
ure.
Check the fluid level in the master cylinder when per-
forming underhood services.Clean the top of the master cylinder area before removing
the cap. If necessary, add fluid to bring the fluid level up
to the requirements described on the brake fluid reser-
voir.
Overfilling of fluid is not recommended because it may
cause leaking in the system.
Fluid level can be expected to fall as the brake pads wear.
Brake fluid level should be checked when pads are
replaced. However, low fluid level may be caused by a
leak and a checkup may be needed.
Use only manufacturer’s recommended brake fluid. Re-
fer to “Fluids, Lubricants, and Genuine Parts” in this
section for the correct fluid type.
MAINTAINING YOUR VEHICLE 391
7

WARNING!
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
•Use of a brake fluid that has a lower initial boiling
point than the recommended MOPARDOT 3
product or a brake fluid that is unidentified as to
FMVSS specification may result in sudden brake
failure during hard prolonged braking. You could
have an accident.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter or
moisture.
CAUTION!
Do not allow petroleum base fluid to contaminate the
brake fluid, all brake seal components could be
damaged causing partial or complete brake failure.
Automatic Transaxle
The automatic transaxle and differential assembly are
contained within a single housing.
The fluid level in the automatic transaxle should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transaxle and the fluid.
392 MAINTAINING YOUR VEHICLE

Fluid Level Check — Vehicles with 2.4L and 2.7L
Engines
Use the following procedure to check the automatic
transaxle fluid level properly:
1. Park the vehicle on level ground.
2. Run the engine at curb idle speed for a minimum of
60 seconds.
3. Apply the parking brake fully.
4. Place the shift lever momentarily into each gear posi-
tion ending with the lever in PARK.
5. Wipe the area around the dipstick clean to eliminate
the possibility of dirt entering the transaxle.
6. Remove the dipstick and determine if the fluid is hot
or cold. Hot fluid is approximately 180°F (82° C), which
is the normal operating temperature after the vehicle isdriven at least 15 miles (24 km). Hot fluid cannot be held
comfortably between the fingertips. Cold fluid is at a
temperature below 80°F (27° C).
7. Wipe the dipstick clean and reinsert until seated. Then,
remove dipstick and note the reading.
a. If the fluid is hot, the reading should be in the
crosshatched area marked “HOT” (between the upper
two holes in the dipstick).
b. If the fluid is cold, the fluid level should be between
the lower two holes in the area marked “COLD.”
If the fluid level is low, add sufficient fluid through the
filler (dipstick) tube to bring it to the proper level. Do not
overfill.
MAINTAINING YOUR VEHICLE 393
7

Component Fluid, Lubricant, or Genuine Part
Fuel Selection (2.4L and
2.7L Engines)87 Octane
Fuel Selection (2.7L - EX-
CEPT CALIFORNIA EMIS-
SION STATES)E-85 Ethanol
Fuel Selection (3.5L Engine) 89 Octane
* PZEV = Partial Zero Emission Vehicle
Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transaxle MOPARATF+4 Automatic Transmission Fluid
Brake Master CylinderMOPARDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not avail-
able, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering Reservoir MOPARATF+4 Automatic Transmission Fluid
MAINTAINING YOUR VEHICLE 419
7

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
424 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

60,000 Miles (100,000 km) or 60 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏Rotate tires.
❏Replace the engine air cleaner filter.
❏Replace the spark plugs (2.4L Engine except PZEV*).
❏Inspect the brake linings, and replace as necessary.
❏Replace the air conditioning filter (if equipped).
❏Change the automatic transaxle fluid & filter if using your vehicle for any of the following:
police, taxi, fleet, or frequent trailer towing.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
66,000 Miles (110,000 km) or
66 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏Rotate tires.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 429
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

120,000 Miles (200,000 km) or 120 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏Rotate tires.
❏Replace the engine air cleaner filter.
❏Replace the spark plugs (2.4L Engine except PZEV*).
❏Inspect the brake linings, and replace as necessary.
❏Replace the air conditioning filter (if equipped).
❏Inspect the CV joints.
❏Inspect the exhaust system.
❏Inspect the front suspension, tie rod ends and boot seals, and replace if necessary.
❏Change the automatic transaxle fluid & filter.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
126,000 Miles (210,000 km) or
126 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏Rotate tires.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
434 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes....................... 282
ABS (Anti-Lock Brake System).............. 286
Adding Engine Coolant (Antifreeze).......... 387
Adding Fuel........................... 331
Adding Washer Fluid..................... 382
Additives, Fuel......................... 326
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 377
Air Conditioner Maintenance............... 379
Air Conditioning........................ 250
Air Conditioning Controls................. 250
Air Conditioning Filter.................261,380
Air Conditioning, Operating Tips............ 262
Air Conditioning Refrigerant.............379,380
Air Conditioning System.............250,254,379
Air Pressure, Tires....................... 304
Airbag..............................52,61
Airbag Deployment....................... 63
Airbag Light...................53,60,66,81,178
Airbag Maintenance....................... 65Airbag, Side........................55,60,61
Airbag, Window (Side Curtain)...........56,60,61
Alarm System (Security Alarm)............19,178
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 240
Antifreeze (Engine Coolant)...........386,387,417
Disposal............................ 388
Anti-Lock Brake System (ABS).............. 286
Anti-Lock Warning Light.................. 286
Anti-Theft Security Alarm (Theft Alarm)........ 19
Appearance Care........................ 395
Ashtray............................... 159
Assistance Towing....................... 105
Auto Down Power Windows................ 36
Auto Unlock, Doors....................... 33
Auto Up Power Windows................37,155
Automatic Dimming Mirror................. 88
Automatic Door Locks...................32,33
Automatic Oil Change Indicator........181,191,422
450 INDEX

Automatic Temperature Control (ATC)......... 254
Automatic Transaxle.................13,270,392
Adding Fluid...................393,394,419
Filter............................... 394
Fluid and Filter Changes................. 394
Fluid Level Check...................393,394
Interlock System....................... 272
Reset Mode.......................... 275
Selection Of Lubricant................... 419
Shifting............................. 273
Special Additives...................... 394
Autostick............................. 276
Battery............................... 378
Gas Caution.......................... 378
Keyless Transmitter Replacement (RKE)....... 26
Location............................ 378
Beverage Cooler........................ 168
Body Mechanism Lubrication............... 381B-Pillar Location........................ 299
Brake Assist System...................... 290
Brake, Parking.......................... 282
Brake System........................284,390
Anti-Lock (ABS)....................... 286
Fluid Check.......................391,419
Master Cylinder....................... 391
Parking............................. 282
Warning Light........................ 187
Brakes.............................284,390
Brake/Transmission Interlock............... 271
Break-In Recommendations, New Vehicle........ 79
Bulb Replacement.....................409,410
Bulbs, Light............................ 409
Calibration, Compass..................... 194
Capacities, Antifreeze (Engine Coolant)......... 21
Capacities, Fluid........................ 417
INDEX 451
10

Overheating.......................... 348
Temperature Gauge..................... 177
Engine Oil Viscosity...................... 375
Enhanced Accident Response Feature.......... 63
Entry System, Illuminated.................. 21
Ethanol............................... 324
Event Data Recorder...................... 66
Exhaust Gas Caution................80,327,383
Exhaust System......................... 383
Extender, Seat Belt........................ 51
Fabric Care.........................397,398
Filler Location Fuel....................177,331
Filters
Air Cleaner.......................... 377
Air Conditioning....................261,380
Automatic Transaxle.................... 394
Engine Oil........................377,418
Engine Oil Disposal.................... 376Flashers.............................. 348
Hazard Warning....................... 348
Turn Signal.......................... 413
Flash-To-Pass........................... 137
Flat Tire Stowage........................ 357
Flexible Fuel Vehicles..................... 328
Cruising Range........................ 331
Engine Oil........................... 330
Fuel Requirements..................328,329
Maintenance.......................328,331
Replacement Parts..................... 331
Starting............................. 330
Flooded Engine Starting................... 268
Floor Console.......................... 164
Fluid Capacities......................... 417
Fluid Leaks............................. 81
Fluid Level Checks
Automatic Transaxle.................393,394
Brake............................391,419
INDEX 455
10