steering DODGE CALIBER 2006 1.G Owner's Guide

TOWING A DISABLED VEHICLE
With Ignition Key
Automatic And Manual Transaxle
Front-wheel-drive vehicles must have the front wheels
elevated; all-wheel-drive vehicles must be hauled on a
flatbed truck.
All Transaxles
CAUTION!
If the vehicle being towed requires steering, the
ignition switch must be in the ACCESSORY posi-
tion, not in the LOCK position.
Do not attempt to use sling type equipment when
towing. When securing vehicle to flat bed truck, do not
attach to front or rear suspension components. Damage
to your vehicle may result from improper towing.
If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transaxle remains in NEUTRAL.
Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. A dolly should be
used under the front wheels if the rear wheels are raised.
Proper towing equipment is necessary to prevent dam-
age to the vehicle.
Battery power is required to release the brake/
transmission interlock system. There is a removable plug
in the right side of the shifter housing that allows you to
insert your finger to override the system.
Towing This Vehicle Behind Another Vehicle (Flat
Towing With All Four Wheels On The Ground)
CAUTION!
DO NOT flat tow this vehicle. Damage to the driv-
etrain will result.
238 WHAT TO DO IN EMERGENCIES

MAINTAINING YOUR VEHICLE
CONTENTS
mEngine Compartment Ð Gasoline Engines...241
mOnboard Diagnostic System Ð OBD II......242
NLoose Fuel Filler Cap Message............242
mEmissions Inspection And Maintenance
Programs
............................243
mReplacement Parts.....................244
mDealer Service........................244
mMaintenance Procedures.................245
NEngine Oil..........................245
NEngine Oil Requirements Ð Diesel Engines . . . 248
NDrive Belt Ð Check Condition............249
NSpark Plugs.........................249NIgnition Wiring System.................249
NCatalytic Converter....................249
NCrankcase Emission Control System........250
NFuel Filter..........................251
NAir Cleaner Element (Filter)..............251
NMaintenance-Free Battery................251
NAir Conditioner Maintenance.............253
NPower Steering Ð Fluid Check............253
NFront Suspension Ball Joints..............254
NBody Lubrication.....................254
NWindshield Wiper Blades................254
7

Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an Authorized Dealer at the
start of each warm season. This service should include
cleaning of the condenser fins and a performance test.
Drive belt tension should also be checked at this time.
WARNING!
²Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer
to Section 3 of the Warranty Information book for
further warranty information.
²The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.
Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
Power Steering Ð Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
MAINTAINING YOUR VEHICLE 253
7

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid types.
Front Suspension Ball Joints
There are two front suspension lower ball joints that are
permanently lubricated. Inspect these ball joints when-
ever under vehicle service is done. Damaged seals and
their corresponding potentially damaged ball joints must
be replaced.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors, liftgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth and a
mild non abrasive cleaner or use the washer solvent. This
will remove accumulations of salt, waxes or road film
and help reduce streaking and smearing.
254 MAINTAINING YOUR VEHICLE

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn't have your full
braking capacity in an emergency.
Brake And Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Insure nylon tubing in these areas has not melted or
collapsed.
NOTE:Often, fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before a hose is replaced
based on leakage.
NOTE:Inspection of brake hoses should be done
whenever the brake system is serviced and at every
engine oil change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
MAINTAINING YOUR VEHICLE 261
7

Cavity Cartridge
FuseMini
FuseDescription
1 40 Amp
GreenPower Top Feed
2 20 Amp
YellowAWD ECU Feed
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
6 10 Amp
RedIOD Sw/Pwr Mir/
Ocm Steering Cntrl
Sdar/Hfm
7 30 Amp
GreenIOD Sense1
8 30 Amp
GreenIOD Sense2
9 40 Amp
GreenPower SeatsCavity Cartridge
FuseMini
FuseDescription
10 20 Amp
YellowCCN Power Locks
11 15 Amp
Lt BluePower Outlet
12 20 Amp
YellowIgn Run/Acc Inverter
13 20 Amp
YellowPwr run/Acc Outlet
RR
14 10 Amp
RedIOD CCN/ Interior
Lighting
15 40 Amp
GreenRAD Fan Relay Bat-
tery Feed
16 15 Amp
Lt. BlueIGN Run/Acc Cigar
Ltr/Sunroof
17 10 Amp
RedIOD Feed Mod-Wcm
18 40 Amp
GreenASD Relay Contact
PWR Feed
19 20 Amp
YellowPWR Amp 1 & Amp
2 Feed
270 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transaxle Fluid MopartCVTF + 4
Manual Transaxle Fluid MopartATF+4 MS9602
Rear Drive Assembly (RDA) MopartGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Power Transfer Unit (PTU) MopartGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Brake Master Cylinder MopartDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids or equivalent.
Power Steering Reservoir MopartPower Steering Fluid +4 or MopartATF+4 Automatic Transmis-
sion Fluid.
280 MAINTAINING YOUR VEHICLE

Latches
Hood............................... 76
Lead Free Gasoline...................... 211
Life of Tires........................... 204
Liftgate (Sedan)......................... 26
Liftgate Window Wiper/Washer............ 101
Light Bulbs........................... 272
Lights..............................61,77
Airbag.........................50,61,112
Back-Up............................ 274
Brake Warning....................... 117
Bulb Replacement..................... 273
Cargo ............................... 96
Center Mounted Stop.................. 277
Daytime Running...................... 78
Dimmer Switch, Headlight............... 77
Electronic Stability Program (ESP) Indicator . . 88
Engine Temperature Warning............ 113
Fog ...........................79,116,273
Headlight Switch...................... 78
Headlights........................... 78
High Beam Indicator................... 117
Instrument Cluster..................... 78License............................. 276
Lights On Reminder.................... 79
Low Fuel........................... 112
Malfunction Indicator (Check Engine)...... 114
Map Reading......................... 77
Oil Pressure......................... 112
Rear Fog............................ 119
Seat Belt Reminder.................... 112
Security Alarm (Theft Alarm)............. 25
Theft Alarm (Security Alarm)............ 112
Traction Control....................... 88
Turn Signal...................77,79,116,274
Voltage............................. 112
Warning (Instrument Cluster Description) . . . 111
Loading Vehicle........................ 217
Tires ............................... 194
Locks
Child Protection....................... 18
Door............................... 14
Power Door.......................... 15
Steering Wheel........................ 13
Lubrication, Body....................... 254
Luggage Rack (Roof Rack)................ 102
314 INDEX

Onboard Diagnostic System............242,243
Operator Manual (Owner's Manual).......... 4
Outside Air Intake...................... 169
Overdrive............................ 178
Overheating, Engine..................... 228
Owner's Manual (Operator Manual).......4,303
Paint Care............................ 265
Panic Alarm........................... 21
Parking Brake......................... 183
Passing Light........................... 80
Personal Settings....................... 122
Pets.................................. 59
Placard, Tire and Loading Information....... 194
Power
Distribution Center (Fuses).............. 269
Door Locks.......................... 15
Mirrors............................. 67
Outlet (Auxiliary Electrical Outlet)......... 93
Steering.........................188,253
Steering, Checking.................... 253
Sunroof............................. 91
Transfer Unit........................ 265Windows............................ 27
Power Steering Fluid.................... 280
Power Transfer Unit..................... 265
Pregnant Women and Seat Belts............. 38
Preparation for Jacking................... 231
Pretensioners
Seat Belts............................ 37
Programmable Electronic Features.......... 122
Programming Transmitters (Remote Keyless
Entry)................................ 22
Radial Ply Tires........................ 201
Radio Broadcast Signals.................. 127
Radio Operation...............129,136,147,163
Radio, Satellite......................... 158
Radio (Sound Systems).............129,136,147
Rear Axle (Differential)................... 264
Rear Drive Assembly.................... 264
Rear Fog Lights........................ 119
Rear Liftgate (Sedan)..................... 26
Rear Seat, Folding....................... 74
Rear Window Defroster.................. 102
Rear Window Features................... 101
316 INDEX

Heated.............................. 72
Lumbar Support....................... 71
Rear Folding......................... 74
Rear Folding (Sedan)................... 74
Seatback Release....................... 71
Tilting.............................. 71
Security Alarm (Theft Alarm)............... 24
Sentry Key (Immobilizer)................ 11,25
Sentry Key Programming.................. 12
Service and Maintenance................. 282
Service Assistance...................... 300
Service Contract........................ 302
Service Manuals........................ 303
Setting the Clock..............129,131,137,148
Settings, Personal....................... 122
Shift Speeds, Manual Transaxle............ 181
Shoulder Belts.......................... 30
Side Airbag............................ 47
Side Window Demisters (Defrosters)......... 169
Signals, Turn.......................... 274
Slippery Surfaces, Driving On............. 236
Snow Tires............................ 209
Spare Tire.......................201,202,230Spark Plugs........................... 249
Speed Control (Cruise Control)...........83,115
Speedometer.......................... 111
Speedometer and Odometer............... 109
Starting.............................. 174
Automatic Transmission................ 174
Engine Fails to Start................... 175
Manual Transmission.................. 174
Starting Procedures..................... 174
Steering
Power...........................188,253
Tilt Column.......................... 82
Wheel Lock.......................... 13
Steering Wheel Mounted Sound System
Controls............................ 161
Storage.............................. 272
Stuck, Freeing......................... 237
Sun Roof.............................. 91
Sun Visor Extension...................... 69
Supplemental Restraint System - Airbag....... 39
Synthetic Engine Oil..................... 247
Tachometer............................ 111
318 INDEX