transmission oil DODGE CALIBER 2006 1.G Owners Manual

WARNING!
Driving a vehicle with the brake light on is danger-
ous. Part of the brake system may have failed. It will
take longer to stop the vehicle. You could have an
accident. Have the vehicle checked immediately.
Vehicles equipped with Anti-Lock brakes (ABS), are also
equipped with Electronic Brake Force Distribution (EBD).
In the event of an EBD failure, the Brake Warning Light
will turn on along with the ABS Light. Immediate repair
to the ABS system is required.
The operation of the Brake Warning Light can be checked
by turning the ignition switch from the OFF position to
the ON position. The light should illuminate for approxi-
mately two seconds. The light should then turn off unless
the parking brake is applied or a brake fault is detected.
If the light does not illuminate, have the light inspected
by an authorized dealer.
The light also will turn on when the parking brake is
applied with the ignition switch in the ON position.
NOTE:This light shows only that the parking brake is
applied. It does not show the degree of brake application.
28. Electronic Vehicle Information Center (EVIC)
ButtonÐIf Equipped
Pushing this button will switch between the different
EVIC functions.
29. Electronic Vehicle Information Center
DisplayÐIf Equipped
When the appropriate conditions exist, this display
shows the Electronic Vehicle Information Center (EVIC)
messages.
30. Transmission Over Temp Light
During sustained high speed driving on hot
days, the automatic transaxle oil may be-
come too hot. If this happens, the transmis-
sion overheat indicator light will come on
and the vehicle will slow slightly until the automatic
transaxle cools down enough to allow a return to the
requested speed. If the high speed is maintained, the
overheating will reoccur as before in a cyclic fashion.
118 UNDERSTANDING YOUR INSTRUMENT PANEL

NOTE:There are steps that you can take to slow down
an impending overheat condition. If your air conditioner
is on, turn it off. The air conditioning system adds heat to
the engine cooling system and turning off the A/C
removes this heat. You can also turn the Temperature
control to maximum heat, the Mode control to floor, and
the fan control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads ªHº, pull
over and stop the vehicle with the engine at idle,
when safe. Turn the air conditioner off and wait until
the pointer drops back into the normal range. After
appropriate action has been taken, if the pointer
remains on the ªHº, turn the engine off immediately,
and call for service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, refer to Section 7, Maintenance, of
this manual. Follow the warnings under the Cooling
System Pressure Cap paragraph.
AUTOMATIC TRANSAXLE OVERHEATING
During sustained high speed driving or trailer towing up
long grades on hot days, the automatic transaxle oil may
become too hot. If this happens, the transmission over-
heat indicator light will come on and the vehicle will
slow slightly until the automatic transaxle cools down
enough to allow a return to the requested speed. If the
high speed is maintained, the overheating will reoccur as
before in a cyclic fashion.
WHAT TO DO IN EMERGENCIES 229
6

Special Additives
Do not add any materials (other than leak detection dyes)
to Automatic Transmission Fluid (ATF). ATF is an engi-
neered product and its performance may be impaired by
supplemental additives.
Manual Transaxle
Lubricant Selection
Use only manufacturers recommended transmission
fluid. Refer to Fluids, Lubricants and Genuine Parts for
correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more that 3/16º (4.7 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life of
the vehicle. Fluid changes are not necessary unless the
following conditions exist:
²The lubricant has become contaminated with water. If
contaminated with water, the fluid should be changed
immediately.
²If severe usage has occurred, refer to Maintenance
Schedule ªBº in Section 8 of this manual.
Rear Drive Assembly (RDA)± AWD Models Only
Lubricant Selection
Use only manufacturers recommended fluid. Refer to
Fluids, Lubricants and Genuine Parts for correct fluid
type.
Fluid Level Check
Visually inspected the unit at each oil change for leakage.
If leakage is detected, Check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 1/8 inch (4 mm)
below the fill hole.
Add fluid, if necessary, to maintain the proper level.
264 MAINTAINING YOUR VEHICLE

²Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
²Check all lights and all other electrical items for correct
operation.
At Each Oil Change
²
Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints (if equipped) and front suspen-
sion components.
²Check the manual transmission fluid level (if
equipped).
²Check the coolant level, hoses, and clamps.
CAUTION!
Do not check the automatic transaxle fluid. It must
be check by a trained service technician every 15,000
miles and if required only the recommended fluid
be added. Refer to the section ªFluids, Lubricants
And Genuine Partsº for the proper fluid.
284 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Brake Fluid........................... 280
Brake, Parking......................... 183
Brake System.......................185,260
Anti-Lock (ABS)....................86,186
Hoses.............................. 261
Master Cylinder...................... 262
Parking............................ 183
Warning Light....................... 117
Brakes............................185,260
Brake/Transmission Interlock.............. 177
Break-In Recommendations, New Vehicle...... 59
Bulb Replacement...................272,273
Bulbs, Light........................... 272
Calibration, Compass.................... 127
Capacities, Antifreeze (Engine Coolant)...... 278
Capacities, Fluid....................... 278
Caps, Filler
Fuel............................... 214
Oil (Engine)......................241,247
Car Washes........................... 266
Carbon Monoxide Warning............... 213
Cargo Area Cover....................... 98Cargo Area Features..................... 96
Cargo Compartment
Light............................... 96
Luggage Carrier...................... 102
Cargo Light............................ 96
Cargo Load Floor....................... 99
Cargo Tie-Downs........................ 99
Carrier, Luggage....................... 102
Catalytic Converter..................... 249
Caution, Exhaust Gas..................... 60
CD (Compact Disc) Player..........129,136,147
CD (Compact Disc) Player Maintenance...... 163
Cellular Phone......................... 163
Center High Mounted Stop Light........... 277
Chains, Tire........................... 209
Changing A Flat Tire.................... 230
Chart, Tire Sizing....................... 191
Check Engine Light (Malfunction Indicator
Light)............................... 243
Child Restraint......................... 52
Child Restraint Tether Anchors............. 56
Child Restraint with Automatic Belts......... 55
Child Safety Locks....................... 18
INDEX 309
10

Heated.............................. 72
Lumbar Support....................... 71
Rear Folding......................... 74
Rear Folding (Sedan)................... 74
Seatback Release....................... 71
Tilting.............................. 71
Security Alarm (Theft Alarm)............... 24
Sentry Key (Immobilizer)................ 11,25
Sentry Key Programming.................. 12
Service and Maintenance................. 282
Service Assistance...................... 300
Service Contract........................ 302
Service Manuals........................ 303
Setting the Clock..............129,131,137,148
Settings, Personal....................... 122
Shift Speeds, Manual Transaxle............ 181
Shoulder Belts.......................... 30
Side Airbag............................ 47
Side Window Demisters (Defrosters)......... 169
Signals, Turn.......................... 274
Slippery Surfaces, Driving On............. 236
Snow Tires............................ 209
Spare Tire.......................201,202,230Spark Plugs........................... 249
Speed Control (Cruise Control)...........83,115
Speedometer.......................... 111
Speedometer and Odometer............... 109
Starting.............................. 174
Automatic Transmission................ 174
Engine Fails to Start................... 175
Manual Transmission.................. 174
Starting Procedures..................... 174
Steering
Power...........................188,253
Tilt Column.......................... 82
Wheel Lock.......................... 13
Steering Wheel Mounted Sound System
Controls............................ 161
Storage.............................. 272
Stuck, Freeing......................... 237
Sun Roof.............................. 91
Sun Visor Extension...................... 69
Supplemental Restraint System - Airbag....... 39
Synthetic Engine Oil..................... 247
Tachometer............................ 111
318 INDEX