key DODGE CALIBER 2007 1.G Service Manual

3. Turn off the heater, radio and all unnecessary electrical
loads.
4. Remove the air intake duct covering the battery, using
the two finger screws on the cover.
5. Connect one end of a jumper cable to the positive
terminal of the booster battery. Connect the other end of
the jumper cable to the positive terminal of the dis-
charged battery.WARNING!
Battery fluid is a corrosive acid solution; do not
allow battery fluid to contact eyes, skin or clothing.
Don’t lean over battery when attaching clamps or
allow the clamps to touch each other. If acid splashes
in eyes or on skin, flush the contaminated area
immediately with large quantities of water.
A battery generates hydrogen gas which is flam-
mable and explosive. Keep flame or spark away
from the vent holes. Do not use a booster battery or
any other booster source with an output that exceeds
12 volts.
6. Connect the other cable, first to the negative terminal
of the booster battery and then to the negative terminal of
the discharged battery. Make sure you have a good
contact.
7. If the vehicle is equipped with Sentry Key Immobi-
lizer, turn the ignition switch to the ON position for 3
seconds before moving the ignition switch to the START
position.
WHAT TO DO IN EMERGENCIES 273
6

TOWING A DISABLED VEHICLE
With Ignition Key
Automatic And Manual Transaxle
Front-wheel-drive vehicles must have the front wheels
elevated; all-wheel-drive vehicles must be hauled on a
flatbed truck.
All Transaxles
CAUTION!
If the vehicle being towed requires steering, the
ignition switch must be in the ACCESSORY posi-
tion, not in the LOCK position.
Do not attempt to use sling type equipment when
towing. When securing vehicle to flat bed truck, do
not attach to front or rear suspension components.
Damage to your vehicle may result from improper
towing.
If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transaxle remains in NEUTRAL.
WHAT TO DO IN EMERGENCIES 275
6

Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. A dolly should be
used under the front wheels if the rear wheels are raised.
Proper towing equipment is necessary to prevent dam-
age to the vehicle.
Battery power is required to release the brake/
transmission interlock system. There is a removable plug
in the right side of the shifter housing that allows you to
insert your finger to override the system.
Towing This Vehicle Behind Another Vehicle (Flat
Towing With All Four Wheels On The Ground)
CAUTION!
DO NOT flat tow this vehicle. Damage to the driv-
etrain will result.
276 WHAT TO DO IN EMERGENCIES

This might indicate a damaged cap. If the problem is
detected twice in a row, the system will turn on the
Malfunction Indicator Light (MIL). Resolving the prob-
lem will turn the MIL light off.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.
For states, which have an I/M (Inspection and
Maintenance) requirement, this check verifies the
following: the MIL (Malfunction Indicator Light)
is functioning and is not on when the engine is running,
and that the OBD (On Board Diagnostic) system is ready
for testing.
Normally, the OBD system will be ready. The OBD
system maynotbe ready if your vehicle was recently
serviced, if you recently had a dead battery, or a battery
replacement. If the OBD system should be determined
not ready for the I/M test, your vehicle may fail the test.Your vehicle has a simple ignition key actuated test,
which you can use prior to going to the test station. To
check if your vehicle’s OBD system is ready, you must do
the following:
1. Insert your ignition key into the ignition switch.
2. Turn the ignition to the ON position, but do not crank
or start the engine.
3. If you crank or start the engine, you will have to start
this test over.
4. As soon as you turn your key to the ON position, you
will see your MIL symbol come on as part of a normal
bulb check.
5. Approximately 15 seconds later, one of two things will
happen:
a. The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn off
the ignition key or start the engine. This means that
your vehicle’s OBD system isnot readyand you
shouldnotproceed to the I/M station.
MAINTAINING YOUR VEHICLE 281
7

b. The MIL will not flash at all and will remain fully
illuminated until you turn off the ignition key or
start the engine. This means that your vehicle’s OBD
system isreadyand you can proceed to the I/M
station.
If your OBD system isnot ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle’s OBD system is
ready or not ready, if the MIL symbol is illuminated
during normal vehicle operation, you should have your
vehicle serviced before going to the I/M station. The I/M
station can fail your vehicle because the MIL symbol is on
with the engine running.
REPLACEMENT PARTS
Use of genuine Moparparts for normal/scheduled
maintenance and repairs is highly recommended to in-
sure the designed performance. Damage or failures
caused by the use of non-Moparparts for maintenance
and repairs will not be covered by the manufacturer’s
warranty.
DEALER SERVICE
Your dealer has the qualified service personnel, special
tools, and equipment to perform all service operations in
an expert manner. Service Manuals are available which
include detailed service information for your vehicle.
Refer to these manuals before attempting any procedure
yourself.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
282 MAINTAINING YOUR VEHICLE

ABS (Anti-Lock Brake System)............. 220
Accelerator Pedal....................... 213
Adding Engine Coolant (Antifreeze)......... 295
Adding Fuel.......................... 252
Adding Washer Fluid.................108,133
Additives, Fuel........................ 250
Air Cleaner, Engine
(Engine Air Cleaner Filter)................ 288
Air Conditioner Maintenance.............. 290
Air Conditioning Controls................ 198
Air Conditioning, Operating Tips........... 203
Air Conditioning Refrigerant...........290,291
Air Conditioning System..............198,290
Air Pressure, Tires...................... 234
Airbag................................ 39
Airbag Deployment...................... 49
Airbag Light...................... 52,62,145
Airbag Maintenance...................... 51
Airbag, Side........................... 47
Alarm System (Security Alarm).......... 24,145
Alignment and Balance.................. 240
All Wheel Drive (AWD).................. 217
Alterations/Modifications, Vehicle............ 6Antenna, Satellite Radio.................. 195
Antifreeze (Engine Coolant).........294,316,317
Capacities........................... 316
Disposal............................ 296
Anti-Lock Brake System (ABS).......... 117,220
Anti-Theft Security Alarm (Theft Alarm)...... 24
Appearance Care....................... 303
Automatic Door Locks.................. 16,17
Automatic Transaxle........... 9,208,210,267,301
Fluid Level Check..................... 301
Interlock System.................... 14,212
Overheating......................... 267
Selection Of Lubricant................. 301
Shifting............................ 212
Special Additives..................... 301
Autostick ............................. 214
BallJoints ............................ 291
Battery ............................... 289
Keyless Transmitter Replacement (RKE)..... 23
Belts,Drive ........................... 286
Beverage Cooler........................ 134
Body Mechanism Lubrication.............. 292
346 INDEX

Gasoline (Fuel).....................248,316
Gasoline, Reformulated.................. 249
Gauges
Coolant Temperature.................. 144
Fuel............................... 144
Odometer........................... 147
Tachometer.......................... 144
Gearshift............................. 212
General Information................. 13,93,246
General Maintenance.................... 283
Glass Cleaning......................... 306
Glove Compartment..................... 134
GrossAxleWeightRating ................. 255
GrossVehicleWeightRating ............254,255
Hands-Free Phone (UConnect™)............ 72
Hazard Warning Flasher.................. 266
Head Restraints......................... 96
Headlights............................ 311
Cleaning............................ 306
High Beam.......................105,150
High Beam/Low Beam Select Switch...... 105
Passing............................. 106Replacing........................... 311
Switch ............................. 103
Heated Seats........................... 97
Hitches
TrailerTowing ....................... 256
HomeLink
(Garage Door Opener) Transmitter.......... 112
Hood Release.......................... 101
Hoses............................... 298
Ignition................................ 9
Key ................................. 9
Ignition Key Removal..................... 9
Immobilizer (Sentry Key)................ 11,25
InfantRestraint ......................... 54
Information Center, Vehicle............... 152
Inside Rearview Mirror................... 69
Instrument Cluster...................142,144
Instrument Panel and Controls............. 141
Instrument Panel Cover.................. 307
Instrument Panel Lens Cleaning............ 307
Integrated Power Module (Fuses)........... 307
Interior Appearance Care................. 305
INDEX 351
10

Intermittent Wipers (Delay Wipers)......... 108
Introduction............................ 4
Jack Location.......................... 268
Jack Operation......................268,269
Jacking Instructions..................... 269
Jump Starting......................... 272
Key, Programming....................... 12
Key, Replacement....................... 12
Key, Sentry (Immobilizer).................. 11
Key-In Reminder........................ 10
Keyless Entry System (Sedan).............. 19
Keys.................................. 9
Lane Change and Turn Signals..........149,312
Lap/Shoulder Belts...................... 29
Latches
Hood.............................. 101
Lead Free Gasoline...................... 248
LifeofTires ........................... 239
Liftgate (Sedan)......................... 26
Liftgate Window Wiper/Washer............ 132LightBulbs ........................... 310
Lights ............................. 63,102
Airbag ......................... 52,62,145
Back-Up............................ 312
BrakeWarning ....................... 150
Bulb Replacement..................... 311
Cargo .............................. 128
Center Mounted Stop.................. 315
Daytime Running..................... 106
Dimmer Switch, Headlight.............. 103
Electronic Stability Program
(ESP) Indicator.................... 119,121
Engine Temperature Warning............ 146
Fog ..........................104,149,311
Headlight Switch..................... 103
Headlights.......................... 103
High Beam Indicator................... 150
Instrument Cluster.................... 103
License............................. 314
Lights On Reminder................... 104
Low Fuel........................... 145
Malfunction Indicator (Check Engine)...... 148
Map Reading........................ 102
352 INDEX

Sunroof............................ 122
Transfer Unit........................ 303
Windows............................ 27
Power Steering Fluid.................... 318
Power Transfer Unit..................... 303
Pregnant Women and Seat Belts............. 39
Preparation for Jacking................... 269
Pretensioners
Seat Belts............................ 37
Programmable Electronic Features..... 113,116,155
Programming Transmitters
(Remote Keyless Entry).............. 22,113,116
Radial Ply Tires........................ 236
Radio Broadcast Signals.................. 160
Radio, Navigation...................... 192
Radio Operation...............162,169,180,198
Radio, Satellite......................192,193
Radio (Sound Systems).............162,169,180
Rear Axle (Differential)................... 302
Rear Drive Assembly.................... 302
Rear Fog Lights........................ 152
Rear Liftgate (Sedan)..................... 26Rear Seat, Folding....................... 99
Rear Window Defroster.................. 134
Rear Window Features................... 132
Rear Wiper/Washer..................... 132
Recorder, Event Data..................... 52
Recreational Towing..................... 264
Refrigerant ............................ 291
Reminder, Seat Belt...................... 37
Remote Control
Door Locks.......................... 19
Security Alarm........................ 24
Remote Keyless Entry (Sedan).............. 19
Remote Sound System (Radio) Controls...... 196
Replacement Bulbs...................... 310
Replacement Keys....................... 12
Replacement Parts...................... 282
Replacement Tires...................... 239
Reporting Safety Defects................. 341
Restraints,Child ...................... 54,59
Restraints,Infant ........................ 54
Retractable Cargo Area Cover.............. 130
Roof Rack (Luggage Rack)................ 134
Rotation,Tires ......................... 247
INDEX 355
10

Safety Checks Inside Vehicle............... 62
Safety Checks Outside Vehicle.............. 62
Safety Defects, Reporting................. 341
Safety Information, Tire.................. 225
SafetyTips ............................. 61
Satellite Radio......................192,193
Satellite Radio Antenna.................. 195
Schedule, Maintenance................... 320
Seat Belt Maintenance................... 307
Seat Belt Reminder...................... 37
Seat Belts
Adjustable Shoulder Belt................ 33
Adjustable Upper Shoulder Anchorage...... 33
And Pregnant Women.................. 39
Child Restraint........................ 54
Front Seat............................ 29
Pretensioners......................... 37
Rear Seat............................ 29
Reminder........................... 145
Seat Belts (Sedan)....................... 28
Seats................................. 94
Adjustment.......................... 94
Cleaning............................ 305Head Restraints....................... 96
Heated.............................. 97
Lumbar Support....................... 95
Rear Folding......................... 99
Rear Folding (Sedan)................... 99
Seatback Release....................... 96
Tilting.............................. 96
Security Alarm (Theft Alarm)............... 24
SelectionofOil ........................ 285
Sentry Key (Immobilizer)................ 11,25
Sentry Key Programming.................. 12
Service and Maintenance................. 320
Service Assistance...................... 338
ServiceContract ........................ 340
Service Manuals........................ 341
Setting the Clock...........162,164,170,181,192
Settings, Personal....................... 155
Shift Speeds, Manual Transaxle............ 216
Shoulder Belts.......................... 29
Side Airbag............................ 47
Side Window Demisters (Defrosters)......... 204
Signals, Turn.......................... 312
Slippery Surfaces, Driving On............. 224
356 INDEX