fuel pressure DODGE CALIBER 2008 1.G User Guide

•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Ensure nylon tubing in these areas has not melted or
collapsed.Inspect all hose connections such as clamps and cou-
plings, to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.Fuel System Connections
Electronic Fuel Injection high pressure fuel systems are
designed with tubes and special connects, connections
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufacturer’s-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
340 MAINTAINING YOUR VEHICLE

if it has been six months since your last oil change and
even if the oil change indicator message is NOT
illuminated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 mi (10 000 km) or six months, whichever
comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If this
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Oil Change
Required” in “Use Factory Settings” of the EVIC section
in this manual or under “Odometer/Trip Odometer” in
the Instrument Cluster Descriptions section of this
manual.At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check the tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
MAINTENANCE SCHEDULES 365
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System).............. 247
Adding Engine Coolant (Antifreeze).......... 337
Adding Fuel........................... 284
Adding Washer Fluid..................124,153
Additives, Fuel......................... 283
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 328
Air Conditioner Maintenance............... 331
Air Conditioning Controls................. 219
Air Conditioning, Operating Tips............ 225
Air Conditioning Refrigerant.............331,332
Air Conditioning System................219,331
Air Pressure, Tires....................... 263
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light....................... 57,70,165
Airbag Maintenance....................... 57
Airbag, Side............................ 54
Airbag, Window (Side Curtain)............... 49
Alarm System (Security Alarm)............ 19,165Alignment and Balance................... 270
All Wheel Drive (AWD)................... 244
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 216
Antifreeze (Engine Coolant)...........336,360,361
Capacities........................... 360
Disposal............................ 338
Anti-Lock Brake System (ABS)............128,247
Anti-Theft Security Alarm (Theft Alarm)........ 19
Appearance Care........................ 346
Assistance Towing........................ 93
Automatic Door Locks................... 28,29
Automatic Transaxle........... 13,233,235,304,343
Fluid Level Check...................... 344
Interlock System....................... 237
Overheating.......................... 304
Selection Of Lubricant................... 343
Shifting ............................. 237
Special Additives...................... 344
382 INDEX

Airbag.......................... 57,70,165
Back-Up............................. 356
Brake Warning........................ 172
Bulb Replacement...................... 355
Cargo .............................. 147
Center Mounted Stop................... 359
Daytime Running...................... 121
Dimmer Switch, Headlight................ 117
Electronic Stability Program (ESP)
Indicator.........................132,133
Engine Temperature Warning.............. 166
Fog .......................... 119,171,356
Headlight Switch...................... 118
Headlights........................... 118
High Beam Indicator.................... 172
Instrument Cluster..................... 118
License............................. 358
Lights On Reminder.................... 119
Low Fuel............................ 165Malfunction Indicator (Check Engine)........ 169
Map Reading......................... 117
Oil Pressure.......................... 166
Seat Belt Reminder..................... 165
Security Alarm (Theft Alarm).............. 19
Theft Alarm (Security Alarm).............. 165
Traction Control....................... 132
Turn Signal.................. 117,120,171,356
Voltage............................. 165
Warning (Instrument Cluster Description)..... 164
Loading Vehicle......................... 287
Tires ............................... 258
Locks
Child Protection........................ 31
Door................................ 26
Power Door........................... 28
Steering Wheel......................... 15
Lubrication, Body....................... 333
Luggage Rack (Roof Rack)................. 153
390 INDEX

Lumbar Support........................ 109
Maintenance Free Battery.................. 329
Maintenance, General..................... 322
Maintenance Procedures................... 322
Maintenance Schedule.................... 364
Malfunction Indicator Light (Check Engine) . . 169,320
Manual, Service......................... 377
Manual Transaxle..................233,242,344
Downshifting......................... 243
Fluid Level Check...................344,345
Frequency of Fluid Change............345,346
Lubricant Selection..................344,345
Map/Reading Lights..................... 117
Master Cylinder (Brakes).................. 342
Mirrors ................................ 77
Electric Powered....................... 78
Outside.............................. 77
Rearview............................. 77Vanity ............................... 80
Modifications/Alterations, Vehicle............. 7
Monitor, Tire Pressure System............... 271
Mopar Parts.........................321,376
Multi-Function Control Lever............... 117
Navigation Radio........................ 210
Navigation System....................... 210
New Vehicle Break-In Period................ 69
Occupant Restraints (Sedan)................. 35
Octane Rating, Gasoline (Fuel).............. 281
Odometer............................. 168
Trip .............................168,170
Oil Change Indicator..................... 168
Oil, Engine.........................322,360
Capacity............................ 360
Change Interval....................... 324
Checking............................ 322
INDEX 391
10