oil change DODGE CALIBER 2008 1.G User Guide

NOTE:Inspection of brake hoses should be done when-
ever the brake system is serviced and at every engine oil
change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Brake Master Cylinder
The fluid level in the master cylinder should be checked
when performing under hood services, or immediately if
the brake system warning light is on.
Be sure to clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the
fluid level up to the requirements described on the brakefluid reservoir. Fluid level can be expected to fall as the
brake pads wear. The brake fluid level should be checked
when the pads are replaced. However, low fluid level
may be caused by a leak and a checkup may be needed.
NOTE:If your vehicle is equipped with amanual
transaxle, the brake fluid reservoir supplies fluid to both
the brake system and the clutch release system. The two
systems are separated in the reservoir, and a leak in one
system will not affect the other system. Themanual
transaxleclutch release system should not require fluid
replacement during the life of the vehicle. If the brake
fluid reservoir is low and the brake system does not
indicate any leaks or other problems, it may be a result of
a leak in the hydraulic clutch release system. See your
local authorized dealer for service.
Use only manufacturer’s recommended brake fluid. Re-
fer to “Fluids, Lubricants, and Genuine Parts” under
Section 8.
342 MAINTAINING YOUR VEHICLE

Frequency Of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life of
the vehicle. Fluid changes are not necessary lubricant has
become contaminated with water.
NOTE:If contaminated with water, the fluid should be
changed immediately.
Rear Drive Assembly (RDA) – AWD/4WD Models
Only
Lubricant Selection
Use only the manufacturer’s recommended fluid. Refer
to “Fluids, Lubricants and Genuine Parts” under Section
8.
Fluid Level Check
Visually inspect the unit at each oil change for leakage. If
leakage is detected, check the fluid level by removing thefill plug. The fluid level should be maintained between the
bottom of the fill hole to 1/8 in (4 mm) below the fill hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule” under Section 8.
Power Transfer Unit (PTU) – AWD/4WD Models
Only
Lubricant Selection
Use only the manufacturer’s recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” under Section
8.
Fluid Level Check
Visually inspected the unit at each oil change for leakage.
If leakage is detected, Check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 1/8 in (4 mm) below
the fill hole.
MAINTAINING YOUR VEHICLE 345
7

EMISSIONS CONTROL SYSTEM MAINTENANCE
The Scheduled Maintenance services listed inbold type
must be done at the times or mileages specified to ensure
the continued proper functioning of the emission control
system. These, and all other maintenance services in-
cluded in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions, such as dusty areas and very short trip
driving.
Inspection and service should also be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sions control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part that has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
The oil change indicator system will remind you that it is
time to take your vehicle in for scheduled maintenance.
On Electronic Vehicle Information Center (EVIC)
equipped vehicles, “Oil Change Required” will be dis-
played in the EVIC and a single chime will sound,
indicating that an oil change is necessary.
On Non-EVIC equipped vehicles, “Change Oil” will flash
in the instrument cluster odometer and a single chime
will sound, indicating that an oil change is necessary.
Based on engine operation condition, the oil change
indicator message will illuminate; this means that service
is required for your vehicle. Have your vehicle serviced
as soon as possible, within the next 500 mi (805 km).
NOTE:
•The oil change indicator message will not monitor the
time since the last oil change. Change your vehicles oil
364 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

if it has been six months since your last oil change and
even if the oil change indicator message is NOT
illuminated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 mi (10 000 km) or six months, whichever
comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If this
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Oil Change
Required” in “Use Factory Settings” of the EVIC section
in this manual or under “Odometer/Trip Odometer” in
the Instrument Cluster Descriptions section of this
manual.At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check the tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
MAINTENANCE SCHEDULES 365
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
•Check the manual transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
366 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Required Maintenance Intervals
Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the engine oil and engine oil filter. 6,000 10 000 6
Rotate tires. 6,000 10 000 6
If using your vehicle for dusty or off-road conditions,
inspect the engine air cleaner filter; replace if neces-
sary.12,000 20 000 12
Inspect the brake linings; replace if necessary. 12,000 20 000 12
Replace the air conditioning filter. 12,000 20 000 12
Inspect the CV Joints. Perform the first inspection at
12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect Exhaust System. Perform the first inspection at
12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals; replace if necessary.24,000 40 000 24
MAINTENANCE SCHEDULES 367
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Brake Assist System.................... 130
Electronic Stability Program............... 131
Traction Control System................. 131
Electronic Speed Control (Cruise Control)...... 126
Electronic Stability Program (ESP)............ 131
Electronic Vehicle Information Center (EVIC).... 175
Emergency, In Case of
Jacking............................. 304
Jump Starting......................... 310
Towing ............................. 313
Emission Control System Maintenance......320,364
Engine............................. 69,318
Break-In Recommendations................ 69
Checking Oil Level..................... 322
Cooling ............................. 335
Exhaust Gas Caution.................... 284
Fuel Requirements..................... 281
Jump Starting......................... 310
Oil ...........................322,360,361Oil Change Interval.................... 324
Oil Filler Cap......................318,324
OilFilter ............................ 361
Oil Selection.......................... 324
Oil Synthetic......................... 325
Operation............................ 69
Overheating.......................... 302
Temperature Gauge..................... 164
Enhanced Accident Response Feature.......... 56
Event Data Recorder...................... 57
Exhaust Gas Caution.............. 35,69,284,334
Exhaust System......................... 334
Fabric Care............................ 348
Filler Location Fuel...................... 164
Filters
Air Cleaner.......................... 328
Engine Fuel.......................... 328
Engine Oil........................325,361
386 INDEX

Lumbar Support........................ 109
Maintenance Free Battery.................. 329
Maintenance, General..................... 322
Maintenance Procedures................... 322
Maintenance Schedule.................... 364
Malfunction Indicator Light (Check Engine) . . 169,320
Manual, Service......................... 377
Manual Transaxle..................233,242,344
Downshifting......................... 243
Fluid Level Check...................344,345
Frequency of Fluid Change............345,346
Lubricant Selection..................344,345
Map/Reading Lights..................... 117
Master Cylinder (Brakes).................. 342
Mirrors ................................ 77
Electric Powered....................... 78
Outside.............................. 77
Rearview............................. 77Vanity ............................... 80
Modifications/Alterations, Vehicle............. 7
Monitor, Tire Pressure System............... 271
Mopar Parts.........................321,376
Multi-Function Control Lever............... 117
Navigation Radio........................ 210
Navigation System....................... 210
New Vehicle Break-In Period................ 69
Occupant Restraints (Sedan)................. 35
Octane Rating, Gasoline (Fuel).............. 281
Odometer............................. 168
Trip .............................168,170
Oil Change Indicator..................... 168
Oil, Engine.........................322,360
Capacity............................ 360
Change Interval....................... 324
Checking............................ 322
INDEX 391
10

Preparation for Jacking.................... 305
Pretensioners
Seat Belts............................. 45
Programmable Electronic Features............ 179
Programming Transmitters (Remote Keyless
Entry)................................. 23
Radial Ply Tires......................... 265
Radio Broadcast Signals................... 185
Radio, Navigation....................... 210
Radio Operation...................187,195,219
Radio, Satellite.......................210,213
Radio (Sound Systems).................187,195
Rear Axle (Differential).................... 345
Rear Drive Assembly..................... 345
Rear Liftgate (Sedan)...................... 34
Rear Seat, Folding....................... 113
Rear Window Defroster................... 153
Rear Window Features.................... 152Rear Wiper/Washer...................... 152
Recorder, Event Data...................... 57
Recreational Towing...................... 299
Refrigerant............................ 332
Reminder, Seat Belt....................... 46
Remote Control
Door Locks........................... 20
Security Alarm......................... 19
Remote Keyless Entry (Sedan)............... 20
Remote Sound System (Radio) Controls........ 217
Replacement Bulbs....................... 355
Replacement Keys........................ 17
Replacement Parts....................... 321
Replacement Tires....................... 269
Reporting Safety Defects................... 376
Resetting Oil Change Indicator.............. 168
Restraints, Child....................... 60,66
Restraints, Infant......................... 60
Retractable Cargo Area Cover............... 149
INDEX 393
10