power steering DODGE CALIBER 2008 1.G User Guide

Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, or refrigerants.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through an autho-
rized DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine OFF to prevent injury from moving
parts and to ensure an accurate fluid level reading.
Do not overfill. Use only the manufacturer’s recom-
mended power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to “Fluids, Lubricants, and Genuine
Parts” for correct fluid types.
Front Suspension Ball Joints
There are two front suspension lower ball joints that are
permanently lubricated. Inspect these ball joints when-
ever under-vehicle service is done. Damaged seals and
their corresponding potentially damaged ball joints must
be replaced.
332 MAINTAINING YOUR VEHICLE

Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to “Maintenance Schedule” under Section 8.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
Brake And Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard andbrittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Ensure nylon tubing in these areas has not melted or
collapsed.
NOTE:Often, fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before a hose is replaced
based on leakage.
MAINTAINING YOUR VEHICLE 341
7

Cavity Cartridge
FuseMini-
FuseDescription
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
6 10 Amp
RedIOD Sw/Pwr Mir/
Ocm Steering Cntrl
Sdar/Hands-Free
Phone
7 30 Amp
GreenIOD Sense1
8 30 Amp
GreenIOD Sense2
9 40 Amp
GreenPower SeatsCavity Cartridge
FuseMini-
FuseDescription
10 20 Amp
YellowCCN Power Locks
11 15 Amp
Lt BluePower Outlet
12 20 Amp
YellowIgn Run/Acc Inverter
13 20 Amp
YellowPwr run/Acc Outlet
RR
14 10 Amp
RedIOD CCN/ Interior
Lighting
15 40 Amp
GreenRAD Fan Relay Bat-
tery Feed
16 15 Amp
Lt BlueIGN Run/Acc Cigar
Ltr/Sunroof
17 10 Amp
RedIOD Feed Mod-Wcm
352 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants And Genuine Parts
Automatic Transaxle (CVT) Fluid MoparCVTF + 4
Manual Transaxle Fluid MoparATF+4 MS9602
Rear Drive Assembly (RDA) MoparGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Power Transfer Unit (PTU) MoparGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids or equivalent.
Power Steering Reservoir MoparPower Steering Fluid +4 or MoparATF+4 Automatic Transmis-
sion Fluid.
362 MAINTAINING YOUR VEHICLE

if it has been six months since your last oil change and
even if the oil change indicator message is NOT
illuminated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 mi (10 000 km) or six months, whichever
comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If this
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Oil Change
Required” in “Use Factory Settings” of the EVIC section
in this manual or under “Odometer/Trip Odometer” in
the Instrument Cluster Descriptions section of this
manual.At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check the tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
MAINTENANCE SCHEDULES 365
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Airbag.......................... 57,70,165
Back-Up............................. 356
Brake Warning........................ 172
Bulb Replacement...................... 355
Cargo .............................. 147
Center Mounted Stop................... 359
Daytime Running...................... 121
Dimmer Switch, Headlight................ 117
Electronic Stability Program (ESP)
Indicator.........................132,133
Engine Temperature Warning.............. 166
Fog .......................... 119,171,356
Headlight Switch...................... 118
Headlights........................... 118
High Beam Indicator.................... 172
Instrument Cluster..................... 118
License............................. 358
Lights On Reminder.................... 119
Low Fuel............................ 165Malfunction Indicator (Check Engine)........ 169
Map Reading......................... 117
Oil Pressure.......................... 166
Seat Belt Reminder..................... 165
Security Alarm (Theft Alarm).............. 19
Theft Alarm (Security Alarm).............. 165
Traction Control....................... 132
Turn Signal.................. 117,120,171,356
Voltage............................. 165
Warning (Instrument Cluster Description)..... 164
Loading Vehicle......................... 287
Tires ............................... 258
Locks
Child Protection........................ 31
Door................................ 26
Power Door........................... 28
Steering Wheel......................... 15
Lubrication, Body....................... 333
Luggage Rack (Roof Rack)................. 153
390 INDEX

Disposal............................ 325
Filter ............................... 325
Identification Logo..................... 324
Materials Added to..................... 325
Recommendation...................324,360
Synthetic............................ 325
Viscosity............................ 324
Oil Pressure Light....................... 166
Onboard Diagnostic System..............319,320
Opener, Garage Door (HomeLink) ........... 134
Operator Manual (Owner’s Manual)............ 4
Outside Air Intake....................... 226
Overdrive............................. 239
Overheating, Engine...................... 302
Owner’s Manual (Operator Manual)......... 4,377
PaintCare ............................. 346
Panic Alarm............................ 22
Parking Brake.......................... 244Passing Light........................... 121
Personal Settings........................ 179
Pets.................................. 68
Phone, Cellular.......................... 80
Phone, Hands-Free (UConnect™)............. 80
Placard, Tire and Loading Information......... 258
Power
Distribution Center (Fuses)............... 351
Door Locks........................... 28
Mirrors .............................. 78
Outlet (Auxiliary Electrical Outlet).......... 144
Steering..........................250,332
Steering, Checking..................... 332
Sunroof............................. 141
Transfer Unit......................... 345
Windows............................. 32
Power Steering Fluid..................... 362
Power Transfer Unit...................... 345
Pregnant Women and Seat Belts.............. 47
392 INDEX

Service Assistance....................... 373
Service Contract......................... 375
Service Manuals........................ 377
Setting the Clock................187,189,197,210
Settings, Personal........................ 179
Shift Speeds, Manual Transaxle.............. 243
Shoulder Belts........................... 36
Side Airbag............................. 54
Side Window Demisters (Defrosters).......... 227
Signals, Turn........................... 356
Slippery Surfaces, Driving On............... 251
Snow Chains (Tire Chains)................. 279
Snow Tires............................ 279
Spare Tire..........................266,305
Spark Plugs............................ 326
Specifications
Oil ................................ 324
Speed Control (Cruise Control)...........126,170
Speedometer........................... 164Speedometer and Odometer................ 162
Starting............................... 233
Automatic Transmission................. 233
Engine Fails to Start.................... 234
Manual Transmission................... 233
Starting Procedures...................... 233
Steering
Power...........................250,332
TiltColumn .......................... 125
Wheel Lock........................... 15
Steering Wheel Mounted Sound System
Controls............................. 217
Storage............................... 355
Stuck, Freeing.......................... 312
Sun Roof.............................. 141
Sun Visor Extension....................... 80
Supplemental Restraint System - Airbag........ 48
Synthetic Engine Oil...................... 325
System, Navigation...................... 210
INDEX 395
10