belt DODGE CALIBER 2008 1.G Service Manual

steel belt traction on the drive and driven pulleys. Refer
to “Fluids, Lubricants and Genuine Parts” for correct
fluid type.
CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid will cause belt slip and
result in a complete transmission failure! Refer to
“Fluids, Lubricants, and Genuine Parts” for correct
fluid type.
Fluid Level Check
The fluid level in the automatic transaxle should be
checked only by a trained technician.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” in Section 8 of this
manual for the correct change interval.
Special Additives
Do not add any materials (other than leak detection dyes)
to Continuously Variable Transaxle (CVT) Fluid
(CVTF+4). CVTF+4 is an engineered product and its
performance may be impaired by supplemental addi-
tives.
Manual Transaxle
Lubricant Selection
Use only the manufacturers recommended transmission
fluid. Refer to “Fluids, Lubricants, and Genuine Parts”
under Section 8.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more that 3/16 in (4.7 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
344 MAINTAINING YOUR VEHICLE

Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet, soft rag. A mild soap solution may
be used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean, damp
rag.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye or clean the seat belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the seat belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the seat belts from the
car to wash them.Replace the seat belts if they appear frayed or worn or if
the buckles do not work properly.
Dry with a soft cloth.
FUSES/INTEGRATED POWER MODULE (IPM)
An Integrated Power Module (IPM) is located in the
engine compartment near the air cleaner assembly. This
center contains cartridge fuses and mini-fuses. A label
that identifies each component may be printed on the
inside of the cover. Refer to “Engine Compartment” in
this section of the Owner’s Manual for the underhood
location of the IPM.
Cavity Cartridge
FuseMini-
FuseDescription
1 Empty Empty
2 15 Amp
Lt BlueAWD/4WD ECU
Feed
MAINTAINING YOUR VEHICLE 351
7

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the automatic transmission fluid and filter. 120,000 200 000 120
Replace Accessory Drive Belt(s). 120,000 200 000 120
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent
mechanic.
MAINTENANCE SCHEDULES 369
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Autostick............................. 239
BallJoints ............................. 332
Battery............................... 329
Keyless Transmitter Replacement (RKE)....... 25
Belts,Drive ............................ 326
Beverage Cooler........................ 154
Body Mechanism Lubrication............... 333
B-Pillar Location........................ 258
Brake Assist System...................... 130
Brake Fluid............................ 362
Brake, Parking.......................... 244
Brake System........................246,341
Anti-Lock (ABS).................128,129,247
Hoses.............................. 341
Master Cylinder....................... 342
Parking............................. 244
Warning Light........................ 172
Brakes.............................246,341Brake/Transmission Interlock............... 237
Break-In Recommendations, New Vehicle........ 69
Bulb Replacement....................... 355
Bulbs,Light ............................ 355
Calibration, Compass..................... 184
Capacities, Antifreeze (Engine Coolant)........ 360
Capacities, Fluid........................ 360
Caps, Filler
Fuel................................ 284
Oil (Engine).......................318,324
Car Washes............................ 347
Carbon Monoxide Warning................. 284
Cargo Area Cover....................... 149
Cargo Area Features...................... 147
Cargo Compartment
Light ............................... 147
Luggage Carrier....................... 153
CargoLight ............................ 147
INDEX 383
10

Cargo Load Floor........................ 150
Cargo Tie-Downs........................ 150
Carrier, Luggage........................ 153
Catalytic Converter...................... 326
Caution, Exhaust Gas...................... 69
CD (Compact Disc) Player...............187,195
CD (Compact Disc) Player Maintenance........ 218
Cellular Phone........................ 80,219
Center High Mounted Stop Light............ 359
Chains, Tire............................ 279
Changing A Flat Tire..................... 304
Chart, Tire Sizing........................ 255
Check Engine Light (Malfunction Indicator
Light)................................ 320
Child Restraint.......................... 60
Child Restraint Tether Anchors............... 64
Child Restraint with Automatic Belts........... 63
Child Safety Locks........................ 31
Child Seat.............................. 66Clean Air Gasoline....................... 281
Cleaning
Wheels............................. 348
Climate Control......................... 219
Clock ........................186,189,197,210
Clutch............................... 342
Clutch Fluid........................... 342
CoinHolder ........................... 146
Compact Disc (CD) Maintenance............. 218
Compact Spare Tire...................... 266
Compass.............................. 184
Compass Calibration..................... 184
Compass Variance....................... 183
Console.............................. 146
Contract, Service........................ 375
Coolant (Antifreeze)...................360,361
Cooler, Beverage........................ 154
Cooling System......................... 335
Adding Coolant (Antifreeze).............. 337
384 INDEX

Coolant Level......................335,338
Disposal of Used Coolant................ 338
Drain, Flush, and Refill.................. 336
Inspection........................... 338
Points to Remember.................337,339
Pressure Cap......................... 337
Selection of Coolant (Antifreeze)........... 336
Corrosion Protection..................... 346
Crankcase Emission Control System.......... 328
CruiseLight ........................... 170
CupHolder ............................ 146
Customer Assistance..................... 373
Data Recorder, Event...................... 57
Dealer Service.......................... 322
Defroster, Rear Window................... 153
Defroster, Windshield................ 70,220,221
Delay (Intermittent) Wipers................. 124
Diagnostic System, Onboard................ 319Dimmer Switch, Headlight................. 121
Disposal
Antifreeze (Engine Coolant)............... 338
Engine Oil........................... 325
Door Locks............................. 26
Door Locks, Automatic.................... 28
Door Opener, Garage..................... 134
Downshifting.......................... 243
DriveBelts ............................ 326
Driver’s Seat Back Tilt.................... 109
Driving
On Slippery Surfaces.................... 251
Through Flowing, Rising, or Shallow Standing
Water.............................. 252
Electric Remote Mirrors.................... 78
Electrical Power Outlets................... 144
Electronic Brake Control System............. 129
Anti-Lock Brake System................. 129
INDEX 385
10

Ignition............................... 12
Key ................................. 12
Ignition Key Removal..................... 12
Immobilizer (Sentry Key)................. 15,20
Infant Restraint.......................... 60
Information Center, Vehicle................. 175
Inside Rearview Mirror.................... 77
Instrument Cluster....................162,164
Instrument Panel and Controls.............. 161
Instrument Panel Cover................... 350
Instrument Panel Lens Cleaning............. 351
Integrated Power Module (Fuses)............ 351
Interior Appearance Care.................. 349
Intermittent Wipers (Delay Wipers)........... 124
Introduction............................. 4
Jack Location........................... 305
Jack Operation.......................304,306
Jacking Instructions...................... 306Jump Starting.......................... 310
Key, Programming........................ 17
Key, Replacement........................ 17
Key, Sentry (Immobilizer)................... 15
Key-In Reminder......................... 14
Keyless Entry System (Sedan)................ 20
Keys................................. 12
Lane Change and Turn Signals...........171,356
Lap/Shoulder Belts....................... 36
Latches
Hood............................... 115
Lead Free Gasoline...................... 281
LifeofTires ............................ 268
Liftgate (Sedan).......................... 34
Liftgate Window Wiper/Washer............. 152
LightBulbs ............................ 355
Lights .............................. 71,117
INDEX 389
10

Airbag.......................... 57,70,165
Back-Up............................. 356
Brake Warning........................ 172
Bulb Replacement...................... 355
Cargo .............................. 147
Center Mounted Stop................... 359
Daytime Running...................... 121
Dimmer Switch, Headlight................ 117
Electronic Stability Program (ESP)
Indicator.........................132,133
Engine Temperature Warning.............. 166
Fog .......................... 119,171,356
Headlight Switch...................... 118
Headlights........................... 118
High Beam Indicator.................... 172
Instrument Cluster..................... 118
License............................. 358
Lights On Reminder.................... 119
Low Fuel............................ 165Malfunction Indicator (Check Engine)........ 169
Map Reading......................... 117
Oil Pressure.......................... 166
Seat Belt Reminder..................... 165
Security Alarm (Theft Alarm).............. 19
Theft Alarm (Security Alarm).............. 165
Traction Control....................... 132
Turn Signal.................. 117,120,171,356
Voltage............................. 165
Warning (Instrument Cluster Description)..... 164
Loading Vehicle......................... 287
Tires ............................... 258
Locks
Child Protection........................ 31
Door................................ 26
Power Door........................... 28
Steering Wheel......................... 15
Lubrication, Body....................... 333
Luggage Rack (Roof Rack)................. 153
390 INDEX

Disposal............................ 325
Filter ............................... 325
Identification Logo..................... 324
Materials Added to..................... 325
Recommendation...................324,360
Synthetic............................ 325
Viscosity............................ 324
Oil Pressure Light....................... 166
Onboard Diagnostic System..............319,320
Opener, Garage Door (HomeLink) ........... 134
Operator Manual (Owner’s Manual)............ 4
Outside Air Intake....................... 226
Overdrive............................. 239
Overheating, Engine...................... 302
Owner’s Manual (Operator Manual)......... 4,377
PaintCare ............................. 346
Panic Alarm............................ 22
Parking Brake.......................... 244Passing Light........................... 121
Personal Settings........................ 179
Pets.................................. 68
Phone, Cellular.......................... 80
Phone, Hands-Free (UConnect™)............. 80
Placard, Tire and Loading Information......... 258
Power
Distribution Center (Fuses)............... 351
Door Locks........................... 28
Mirrors .............................. 78
Outlet (Auxiliary Electrical Outlet).......... 144
Steering..........................250,332
Steering, Checking..................... 332
Sunroof............................. 141
Transfer Unit......................... 345
Windows............................. 32
Power Steering Fluid..................... 362
Power Transfer Unit...................... 345
Pregnant Women and Seat Belts.............. 47
392 INDEX

Preparation for Jacking.................... 305
Pretensioners
Seat Belts............................. 45
Programmable Electronic Features............ 179
Programming Transmitters (Remote Keyless
Entry)................................. 23
Radial Ply Tires......................... 265
Radio Broadcast Signals................... 185
Radio, Navigation....................... 210
Radio Operation...................187,195,219
Radio, Satellite.......................210,213
Radio (Sound Systems).................187,195
Rear Axle (Differential).................... 345
Rear Drive Assembly..................... 345
Rear Liftgate (Sedan)...................... 34
Rear Seat, Folding....................... 113
Rear Window Defroster................... 153
Rear Window Features.................... 152Rear Wiper/Washer...................... 152
Recorder, Event Data...................... 57
Recreational Towing...................... 299
Refrigerant............................ 332
Reminder, Seat Belt....................... 46
Remote Control
Door Locks........................... 20
Security Alarm......................... 19
Remote Keyless Entry (Sedan)............... 20
Remote Sound System (Radio) Controls........ 217
Replacement Bulbs....................... 355
Replacement Keys........................ 17
Replacement Parts....................... 321
Replacement Tires....................... 269
Reporting Safety Defects................... 376
Resetting Oil Change Indicator.............. 168
Restraints, Child....................... 60,66
Restraints, Infant......................... 60
Retractable Cargo Area Cover............... 149
INDEX 393
10