maintenance schedule DODGE CARAVAN 2004 4.G User Guide

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
²Check all lights and all other electrical items for correct
operation.
MAINTENANCE SCHEDULES 349
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints and front suspension compo-
nents.
²Check the automatic transmission fluid level.
²Check the coolant level, hoses, and clamps.
Tire Rotation
²Rotate the tires at 6,000 miles (10 000 km).
350 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (173 000) (178 000) (182 000) (187 000) (192 000)
Change the All Wheel Drive (AWD) power transfer
unit fluid. (See note at the end of this chart)X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.NOTE:The AWD power transfer unit fluid and the
AWD overrunning clutch/ rear carrier fluid must be
changed at the intervals shown in schedule B if the
vehicle is operated under any of the conditions noted by
a diamond at the beginning of the schedule.
362 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Flush and replace the engine coolant at 120 months, if not
done at 100,000 miles (160 000 km).X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE ªAº 369
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Malfunction Indicator................... 155
Oil Pressure.......................... 155
Park.............................99,340
Passing............................. 103
Reading............................. 110
Rear Servicing........................ 342
Rear Tail............................ 342
Seat Belt Reminder..................... 153
Security Alarm........................ 154
Service...........................338,339
Service Engine Soon.................... 155
Side Marker.......................... 342
Theft Alarm.......................... 154
Turn Signal.....................102,340,342
Voltage............................. 153
Washer Fluid......................... 155
Load Leveling System.................... 141
Loading Vehicle...................135,272,274
Capacities........................... 274Tires ............................... 247
Locks
Door................................ 17
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubrication, Body....................... 315
Luggage Rack.......................... 139
Lumbar Support......................... 84
Maintenance Free Battery.................. 311
Maintenance Procedures................... 303
Maintenance Schedule.................... 348
Light Duty Schedule9A9................. 363
Light Duty Schedule9B9................. 351
Schedule9A9......................... 363
Schedule9B9.......................... 351
Malfunction Indicator Light..............155,301
Manual, Service......................... 376
Mini-Trip Computer...................... 114
Mirrors................................ 77
390 INDEX

Rear Window Features.................... 219
Rear Wiper/Washer................219,220,221
Rearview Mirrors........................ 77
Reclining Front Seats...................... 83
Recommended Fluids, Lubricants and Genuine
Parts............................... 344
Remote Keyless Entry..................... 20
Remote Sound System Controls.............. 195
Removable Floor Console.................. 132
Replacement Tires....................257,259
Reporting Safety Defects................... 376
Restraint, Head.......................... 82
Restraints, Child.......................58,64
Restraints, Infant......................... 59
Rocking Vehicle When Stuck................ 291
Roof Rack............................. 139
Rotation, Tires.......................... 265
Safety Checks Inside Vehicle................. 71Safety Checks Outside Vehicle............... 72
Safety, Exhaust Gas....................... 36
Safety Information, Tire................... 242
Safety Tips............................. 71
Schedule, Maintenance.................... 348
Seat Belt Maintenance.................... 334
Seat Belts.............................. 38
Adjustable Shoulder Belt.................. 44
Adjustable Upper Shoulder Anchorage........ 44
And Pregnant Women................... 48
Center Lap Belt........................ 47
Child Restraint......................... 58
Extender............................. 48
Front Seat............................ 39
Pretensioners.......................... 47
Rear Seat............................. 39
Untwisting Procedure.................... 45
Seats................................. 80
Adjustment........................... 80
INDEX 393
10