parking brake DODGE CARAVAN 2004 4.G User Guide

WARNING!
Be sure the parking brake is fully disengaged before
driving: failure to do so can lead to brake failure, and
an accident.
BRAKE SYSTEM
In the event power assist is lost for any reason (for
example, repeated brake applications with the engine
off), the brakes will still function. The effort required to
brake the vehicle will be much greater than that required
with the power system operating.
Your vehicle is equipped with dual hydraulic
brake systems. If either of the two hydraulic
systems lose normal capability, the remaining
system will still function. There will be some
loss of overall braking effectiveness. This may be evidentby increased pedal travel during application, greater
pedal force required to slow or stop, and potential
activation of the Brake Warning Lamp.
Anti-Lock Brake System Ð If Equipped
The Anti-Lock Brake System provides increased vehicle
stability and brake performance under most braking
conditions. The system automatically ªpumpsº the
brakes during severe braking conditions to prevent
wheel lock-up.
WARNING!
Pumping of the Anti-Lock Brakes will diminish
their effectiveness and may lead to an accident.
Pumping makes the stopping distance longer. Just
press firmly on your brake pedal when you need to
slow down or stop.
STARTING AND OPERATING 237
5

Spare Tire Removal
Fit the jack-handle over the drive nut. Rotate the nut to
the left until the spare is on the ground with enough slack
cable to allow you to pull the tire out from under the
vehicle.
CAUTION!
The winch mechanism is designed for use with the
jack handle only. Use of an air wrench or other
power tools is not recommended and can damage the
winch.
When the spare is clear, tilt the retainer at the end of the
cable and pull it through the center of the wheel.
Preparations For Jacking
Park the vehicle on a firm level surface, avoid ice or
slippery areas,set the parking brakeand place the gear
selector in PARK. Turn OFF the ignition.
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
²Turn on the Hazard Warning Flasher.
284 WHAT TO DO IN EMERGENCIES

1. Wear eye protection and remove any metal jewelry
such as watch bands or bracelets that might make an
inadvertent electrical contact.
2. When boost is provided by a battery in another
vehicle, park that vehicle within booster cable reach and
without letting the vehicles touch. Set the parking brake,
place the automatic transmission in PARK and turn the
ignition switch to the OFF position for both vehicles.
3. Turn off the heater, radio and all unnecessary electrical
loads.
4. Connect one end of a jumper cable to the positive
terminal of the discharged battery. Connect the other end
of the same cable to the positive terminal of the booster
battery.5. Connect the other cable, first to the negative terminal
of the booster battery andthen to the engine of the
vehicle with the discharged battery.Make sure you have
a good contact on the engine.
6. Start the engine in the vehicle which has the booster
battery, let the engine idle a few minutes, then start the
engine in the vehicle with the discharged battery.
7. When removing the jumper cables, reverse the above
sequence exactly. Be careful of the moving belts and fan.
WHAT TO DO IN EMERGENCIES 289
6

CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Recommended Fluids, Lubricants and Genuine Parts
for correct fluid type.
Procedure For Checking Fluid Level
The fluid level in the automatic transmission should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transmission and of the fluid.
To properly check the automatic transmission fluid level,
the following procedure must be used:
1. The vehicle must be on level ground.
2. The engine should be running at curb idle speed for a
minimum of 60 seconds.
3. Fully apply parking brake.
4. Place the gear selector momentarily in each gear
position ending with the lever in P (PARK). Wipe the area
around the dipstick clean to eliminate the possibility of
dirt entering the transmission.
MAINTAINING YOUR VEHICLE 327
7

Filter............................... 328
Fluid and Filter Changes................. 328
Fluid Level Check...................... 327
Interlock System....................... 232
Reset Mode.......................... 233
Selection Of Lubricant................326,345
Shifting............................. 233
Special Additives...................... 329
Ball Joints............................. 314
Battery............................... 311
Gas Caution.......................... 311
Jump Starting......................... 288
Keyless Transmitter Replacement............ 25
Saving Feature........................ 101
Bearings.............................. 330
Belts, Drive............................ 307
Body Mechanism Lubrication............... 315
B-Pillar Location........................ 247Brake, Parking.......................... 235
Brake System........................237,323
Anti-Lock........................... 237
Fluid Check.......................324,345
Hoses.............................. 323
Warning Light........................ 151
Brake/Transmission Interlock............... 232
Break-In Recommendations, New Vehicle........ 70
Bulb Replacement....................... 339
Bulbs, Light............................ 338
Calibration, Compass..................... 112
Capacities, Fluid........................ 343
Caps, Filler
Fuel................................ 270
Radiator............................ 320
Car Washes............................ 331
Carbon Monoxide Warning................. 269
Cargo ................................ 135
INDEX 383
10

Panic Alarm............................ 22
Parking Brake.......................... 235
Parking On Hill......................... 236
Passing Light........................... 103
Pedals, Adjustable....................... 106
Pets.................................. 66
Placard, Tire and Loading Information......... 247
Power
Brakes.............................. 237
Distribution Center..................... 336
Door Locks........................... 18
Lift Gate............................. 34
Mirrors.............................. 79
Outlet.............................. 127
Seats................................ 81
Sliding Door.......................... 29
Steering............................. 240
Steering, Checking..................... 314
Sunroof............................. 125Windows............................. 37
Pregnant Women and Seat Belts.............. 48
Pretensioners
Seat Belts............................. 47
Programmable Electronic Features...... 116,120,124
Programming Transmitters............23,120,124
Radial Ply Tires......................... 255
Radiator Cap........................319,320
Radio..........................161,171,178
Radio Broadcast Signals................... 160
Radio Operation........................ 198
Radio Remote Controls.................189,195
Rear Air Conditioning.................206,214
Rear Cup Holder........................ 130
Rear Heater............................ 206
Rear Seat Removal......................88,90
Rear Seating Flexibility..................92,94
Rear Window Defroster................... 222
392 INDEX