maintenance DODGE CARAVAN 2004 4.G Owner's Guide

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
²Check all lights and all other electrical items for correct
operation.
MAINTENANCE SCHEDULES 349
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints and front suspension compo-
nents.
²Check the automatic transmission fluid level.
²Check the coolant level, hoses, and clamps.
Tire Rotation
²Rotate the tires at 6,000 miles (10 000 km).
350 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (173 000) (178 000) (182 000) (187 000) (192 000)
Change the All Wheel Drive (AWD) power transfer
unit fluid. (See note at the end of this chart)X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.NOTE:The AWD power transfer unit fluid and the
AWD overrunning clutch/ rear carrier fluid must be
changed at the intervals shown in schedule B if the
vehicle is operated under any of the conditions noted by
a diamond at the beginning of the schedule.
362 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Flush and replace the engine coolant at 120 months, if not
done at 100,000 miles (160 000 km).X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
SCHEDULE ªAº 369
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SUGGESTIONS FOR OBTAINING SERVICE FOR
YOUR VEHICLE
Prepare For The Appointment
If you're having warranty work done, be sure to have the
right papers with you. Take your warranty folder. All
work to be performed may not be covered by the
warranty, discuss additional charges with the service
manager. Keep a maintenance log of your vehicle's
service history. This can often provide a clue to the
current problem.
Prepare A List
Make a written list of your vehicle's problems or the
specific work you want done. If you've had an accident,
or work done that is not on your maintenance log, let the
service advisor know.
Be Reasonable With Requests
If you list a number of items, and you must have your
vehicle by the end of the day, discuss the situation with
the service advisor and list the items in order of priority.
At many dealers you may obtain a rental vehicle at a
minimal daily charge. If you need a rental, it is advisable
to make these arrangements when you call for an ap-
pointment.
IF YOU NEED ASSISTANCE
The manufacturer and its dealers are vitally interested in
your satisfaction. We want you to be happy with our
products and services.
Your selling dealer is best equipped and most anxious to
provide prompt resolution for any warranty issue or
related matter that you may experience. The manufactur-
er's dealers have the facilities, factory-trained techni-
cians, special tools, and the latest information to assure
your vehicle is fixed correctly and in a timely manner.
372 IF YOU NEED CONSUMER ASSISTANCE

²Service Manuals.
These comprehensive service manuals provide the
information that students and professional technicians
need in diagnosing/troubleshooting, problem solving,
maintaining, servicing and repairing DaimlerChrysler
Corporation vehicles. A complete working knowledge
of the vehicle, system and/or components is written in
straightforward language with illustrations, diagrams
and charts.
²Diagnostic Procedure Manuals.
Filled with diagrams, charts and detailed illustrations,
these practical manuals make it easy for students and
technicians to find and fix problems on computer-
controlled vehicle systems and features. They show
exactly how to find and correct problems the first time,
using step-by-step troubleshooting and driveability
procedures, proven diagnostic tests and a complete list
of all tools and equipment.
²Owner's Manuals.
These manuals have been prepared with the assistance
of service and engineering specialists to acquaint you
with specific Chrysler group vehicles. Included are
starting, operating, emergency and maintenance pro-
cedures as well as specifications, capabilities and
safety tips.
Call Toll Free at1±800±890±4038 (U.S.)or1±800±387±1143
(Canada)
Or
Visit us on the World Wide Web at:
www.techauthority.daimlerchrysler.com
IF YOU NEED CONSUMER ASSISTANCE 377
9

Adding Fuel........................... 270
Adding Washer Fluid..................221,316
Additives, Fuel......................... 268
Adjustable Pedals....................... 106
Air Conditioner Maintenance............... 312
Air Conditioning.....................199,203
Air Conditioning Controls................. 199
Air Conditioning Filter.................219,313
Air Conditioning, Operating Tips............ 218
Air Conditioning, Rear Zone.............206,214
Air Conditioning Refrigerant............... 312
Air Conditioning System..........199,203,208,312
Air Conditioning System, Zone Control........ 200
Air Pressure, Tires....................... 252
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light.....................52,57,72,152
Airbag Maintenance....................... 57
Airbag, Side............................ 54Alarm Light........................... 154
Alarm System........................... 26
Alignment and Balance................... 258
All Wheel Drive...................235,259,329
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 321
Antifreeze (Engine Coolant)..............319,320
Anti-Lock Brake System................... 237
Anti-Lock Warning Light.................. 153
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 330
Ashtray............................... 130
Auto Down Power Windows................ 37
Automatic Dimming Mirror................. 77
Automatic Door Locks..................... 19
Automatic Headlights.................... 100
Automatic Temperature Control............. 208
Automatic Transaxle...................231,326
Adding Fluid......................... 345
382 INDEX

Cargo Compartment
Luggage Carrier....................... 139
Cassette Tape and Player Maintenance......... 197
Cassette Tape Player..................... 161
Catalytic Converter...................... 309
CD Changer......................170,182,187
CD Player...............167,171,174,178,180,187
Center High Mounted Stop Light............ 343
Center Lap Belts......................... 47
Chains, Tire............................ 263
Changing A Flat Tire..................... 282
Child Restraint.......................... 58
Child Restraint Tether Anchors............... 62
Child Safety Locks........................ 32
Child Seat............................58,64
Clean Air Gasoline....................... 266
Climate Control......................... 199
Clock................................ 159
Compact Disc Maintenance................. 198Compact Disc Player..................161,167
Compact Spare Tire...................... 255
Compass.............................. 111
Compass Calibration..................... 112
Compass Variance....................... 112
Computer, Trip/Travel.................... 114
Console, Overhead....................... 110
Console, Removable...................... 132
Contract, Service........................ 374
Coolant Pressure Cap..................... 320
Cooling System......................... 318
Adding Coolant (Antifreeze).............. 320
Coolant Capacity...................... 343
Coolant Level......................... 321
Disposal of Used Coolant................ 321
Drain, Flush, and Refill.................. 319
Inspection........................... 318
Points to Remember.................... 321
Pressure Cap......................... 320
384 INDEX

Radiator Cap......................... 320
Selection of Coolant..................319,344
Cruise Control.......................... 107
Cruise Light........................... 157
Cup Holder.........................129,334
Customer Assistance..................... 372
Daytime Running Lights................... 101
Dealer Service.......................... 302
Defroster, Rear Window................... 222
Defroster, Windshield................72,203,213
Digital Video Disc Player.................. 187
Dimmer Control......................... 99
Dipsticks
Automatic Transaxle.................... 327
Disposal
Antifreeze........................... 321
Domelight............................. 99
Door Ajar Light......................... 151Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 119
Drive Belts............................ 307
Drive Shaft Universal Joints................ 315
Driving
On Slippery Surfaces.................... 290
DVD Player............................ 187
Electric Remote Mirrors.................... 79
Electrical Power Outlets................... 127
Electronic Speed Control................... 107
Electronic Vehicle Information Center.......... 115
Emergency, In Case of
Jacking............................. 282
Overheating.......................... 281
Emission Control System Maintenance......301,348
Engine............................298,299
Air Cleaner.......................... 309
INDEX 385
10

Malfunction Indicator................... 155
Oil Pressure.......................... 155
Park.............................99,340
Passing............................. 103
Reading............................. 110
Rear Servicing........................ 342
Rear Tail............................ 342
Seat Belt Reminder..................... 153
Security Alarm........................ 154
Service...........................338,339
Service Engine Soon.................... 155
Side Marker.......................... 342
Theft Alarm.......................... 154
Turn Signal.....................102,340,342
Voltage............................. 153
Washer Fluid......................... 155
Load Leveling System.................... 141
Loading Vehicle...................135,272,274
Capacities........................... 274Tires ............................... 247
Locks
Door................................ 17
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubrication, Body....................... 315
Luggage Rack.......................... 139
Lumbar Support......................... 84
Maintenance Free Battery.................. 311
Maintenance Procedures................... 303
Maintenance Schedule.................... 348
Light Duty Schedule9A9................. 363
Light Duty Schedule9B9................. 351
Schedule9A9......................... 363
Schedule9B9.......................... 351
Malfunction Indicator Light..............155,301
Manual, Service......................... 376
Mini-Trip Computer...................... 114
Mirrors................................ 77
390 INDEX