washer fluid DODGE CARAVAN 2004 4.G Owners Manual

Electronic Vehicle Information Center (EVIC) Ð If
Equipped
The Electronic Vehicle Information Center, when the
appropriate conditions exist, displays the following
WARNING messages and symbols. Each message is
accompanied by a single chime:
²TURN SIGNALS ON (with graphic)
²PERFORM SERVICE
²DOOR AJAR (one or more, with graphic)
²LIFTGATE AJAR (with graphic)
²WASHER FLUID LOW (with graphic)
²1,2,3 OR 4 LOW TIRE(S) PRESSURE (Refer to ªStarting
And Operating, Tire Sectionº)
²1,2,3 OR 4 HIGH TIRE(S) PRESSURE (Refer to ªStart-
ing And Operating, Tire Sectionº)
²SERVICE TIRE PRESS. SYSTEM/SEE OWNER'S
MANUAL (Refer to ªStarting And Operating, Tire
Sectionº)
²TIRE PRESSURE UNAVAILABLE (Refer to ªStarting
And Operating, Tire Sectionº)
²TIRE PRESSURE NOW AVAILABLE (Refer to ªStart-
ing And Operating, Tire Sectionº)
²SPARE TIRE IN USE? YES/NO (Refer to ªStarting
And Operating, Tire Sectionº)
²ALL 5 TIRES WITH CAR? YES/NO (Refer to ªStarting
And Operating, Tire Sectionº)
²MEMORY SEAT DISABLED (Not in Park) Ð If
Equipped
²ADJUSTABLE PEDAL DISABLED/CRUISE ENGAGED
²ADJUSTABLE PEDAL DISABLED/VEHICLE IN RE-
VERSE
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 115
3

WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, see Section 7 of this manual. Follow
the warnings under the Cooling System Pressure
Cap paragraph.
15. Washer Fluid Light
This light turns on when the washer fluid level
falls below approximately 1/4 filled. The light will
remain on until fluid is added.
16. Transmission Range Indicator
This vacuum fluorescent display indicator shows the
automatic transaxle gear selection.17. Oil Pressure Warning Light
This light shows low engine oil pressure. The light
should turn on momentarily when the engine is
started. If the light turns on while driving, stop the
vehicle and shut off the engine as soon as possible. A
chime will sound for 4 minutes when this light turns on.
Do not operate the vehicle until the cause is corrected.
This light does not show how much oil is in the engine.
The engine oil level must be checked under the hood.
18. Malfunction Indicator Light
This light is part of an onboard diagnostic system
called OBD that monitors engine and automatic
transmission control systems. The light will illu-
minate when the key is in the ON position before engine
start. If the bulb does not come when turning the key
from OFF to ON, have the condition checked promptly.
Certain conditions such as a loose or missing gas cap,
poor fuel quality, etc. may illuminate the light after
UNDERSTANDING YOUR INSTRUMENT PANEL 155
4

Rear Washer Operation Ð Automatic
Temperature Control Only
Press and hold the button as long as spray is
desired. If the switch is depressed while the wipers
are on, the wipers will operate for a few seconds
after the switch is released then resume the previously set
mode of intermittent wiper or continuous wipe. If the
switch is depressed when the wipers are off, the wipers
will operate for two cycles, then turn off.
NOTE:The washers will stop spraying if the switch is
pressed longer than 10 seconds.
Adding Washer Fluid
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the front of
the engine compartment on the passenger side and
should be checked for fluid level at regular intervals. Fillthe reservoir with windshield washer solvent (not radia-
tor antifreeze) and operate the system for a few seconds
to flush out the residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.
UNDERSTANDING YOUR INSTRUMENT PANEL 221
4

NFront Suspension Ball Joints..............314
NSteering Shaft Seal....................314
NSteering Linkage......................315
NDrive Shaft Universal Joints..............315
NBody Lubrication.....................315
NWindshield Wiper Blades................316
NWindshield And Rear Window Washers.....316
NExhaust System......................317
NCooling System.......................318
NHoses And Vacuum/Vapor Harnesses.......322
NBrakes.............................323
NMaster Cylinder Ð ABS Brakes Brake Fluid
Level Check.........................324NFuel System Hoses....................326
NAutomatic Transmission................326
NAll Wheel Drive (AWD).................329
NFront And Rear Wheel Bearings...........330
NAppearance Care And Protection From
Corrosion...........................330
NCleaning The Instrument Panel And
Underseat Cup Holders.................334
mIntegrated Power Module (IPM)............336
mVehicle Storage........................337
mReplacement Light Bulbs.................338
mBulb Replacement......................339
NHeadlights..........................339
296 MAINTAINING YOUR VEHICLE

Windshield Wiper Blades
The rubber edges of the wiper blades and the windshield
should be cleaned periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove accu-
mulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield.
Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
Windshield and Rear Window Washers
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the engine
compartment and should be checked for fluid level at
regular intervals. Fill the reservoir with windshieldwasher solvent (not radiator antifreeze) and operate the
system for a few seconds to flush out the residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.
316 MAINTAINING YOUR VEHICLE

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
²Check all lights and all other electrical items for correct
operation.
MAINTENANCE SCHEDULES 349
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 270
Adding Washer Fluid..................221,316
Additives, Fuel......................... 268
Adjustable Pedals....................... 106
Air Conditioner Maintenance............... 312
Air Conditioning.....................199,203
Air Conditioning Controls................. 199
Air Conditioning Filter.................219,313
Air Conditioning, Operating Tips............ 218
Air Conditioning, Rear Zone.............206,214
Air Conditioning Refrigerant............... 312
Air Conditioning System..........199,203,208,312
Air Conditioning System, Zone Control........ 200
Air Pressure, Tires....................... 252
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light.....................52,57,72,152
Airbag Maintenance....................... 57
Airbag, Side............................ 54Alarm Light........................... 154
Alarm System........................... 26
Alignment and Balance................... 258
All Wheel Drive...................235,259,329
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 321
Antifreeze (Engine Coolant)..............319,320
Anti-Lock Brake System................... 237
Anti-Lock Warning Light.................. 153
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 330
Ashtray............................... 130
Auto Down Power Windows................ 37
Automatic Dimming Mirror................. 77
Automatic Door Locks..................... 19
Automatic Headlights.................... 100
Automatic Temperature Control............. 208
Automatic Transaxle...................231,326
Adding Fluid......................... 345
382 INDEX

Malfunction Indicator................... 155
Oil Pressure.......................... 155
Park.............................99,340
Passing............................. 103
Reading............................. 110
Rear Servicing........................ 342
Rear Tail............................ 342
Seat Belt Reminder..................... 153
Security Alarm........................ 154
Service...........................338,339
Service Engine Soon.................... 155
Side Marker.......................... 342
Theft Alarm.......................... 154
Turn Signal.....................102,340,342
Voltage............................. 153
Washer Fluid......................... 155
Load Leveling System.................... 141
Loading Vehicle...................135,272,274
Capacities........................... 274Tires ............................... 247
Locks
Door................................ 17
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubrication, Body....................... 315
Luggage Rack.......................... 139
Lumbar Support......................... 84
Maintenance Free Battery.................. 311
Maintenance Procedures................... 303
Maintenance Schedule.................... 348
Light Duty Schedule9A9................. 363
Light Duty Schedule9B9................. 351
Schedule9A9......................... 363
Schedule9B9.......................... 351
Malfunction Indicator Light..............155,301
Manual, Service......................... 376
Mini-Trip Computer...................... 114
Mirrors................................ 77
390 INDEX

Rear Window Features.................... 219
Rear Wiper/Washer................219,220,221
Rearview Mirrors........................ 77
Reclining Front Seats...................... 83
Recommended Fluids, Lubricants and Genuine
Parts............................... 344
Remote Keyless Entry..................... 20
Remote Sound System Controls.............. 195
Removable Floor Console.................. 132
Replacement Tires....................257,259
Reporting Safety Defects................... 376
Restraint, Head.......................... 82
Restraints, Child.......................58,64
Restraints, Infant......................... 59
Rocking Vehicle When Stuck................ 291
Roof Rack............................. 139
Rotation, Tires.......................... 265
Safety Checks Inside Vehicle................. 71Safety Checks Outside Vehicle............... 72
Safety, Exhaust Gas....................... 36
Safety Information, Tire................... 242
Safety Tips............................. 71
Schedule, Maintenance.................... 348
Seat Belt Maintenance.................... 334
Seat Belts.............................. 38
Adjustable Shoulder Belt.................. 44
Adjustable Upper Shoulder Anchorage........ 44
And Pregnant Women................... 48
Center Lap Belt........................ 47
Child Restraint......................... 58
Extender............................. 48
Front Seat............................ 39
Pretensioners.......................... 47
Rear Seat............................. 39
Untwisting Procedure.................... 45
Seats................................. 80
Adjustment........................... 80
INDEX 393
10

Vehicle Information Center................. 115
Vehicle Loading......................272,274
Vehicle Modifications/Alterations.............. 7
Vehicle Storage.......................217,337
Vehicle Theft Alarm....................... 26
Video Entertainment System................ 187
Warning Flasher, Hazard.................. 280
Warnings and Cautions..................... 6
Warranty Information..................... 375
Washer, Adding Fluid..................221,316
Washer, Rear........................219,221
Washing Vehicle......................... 331
Wheel Alignment and Balance............... 258
Wheel and Wheel Trim.................... 332Wheel Bearings......................... 330
Wind Buffeting.......................38,127
Window Fogging........................ 218
Windows.............................. 36
Power............................... 37
Rear Vent............................ 36
Windshield Washers...................103,316
Windshield Wiper Blades.................. 316
Windshield Wipers....................... 103
Wiper Blade Replacement.................. 316
Wiper, Rear............................ 220
Wipers, Intermittent...................... 104
Zone Control........................... 200
INDEX 397
10