maintenance schedule DODGE CARAVAN 2005 4.G User Guide

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
426 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 427
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
•Check all lights and all other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
428 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (173 000) (178 000) (182 000) (187 000) (192 000)
Change the automatic transmission fluid and filter.
X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE“B”439
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Flush and replace the engine coolant at 120 months, if not
done at 100,000 miles (160 000 km).X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
446 SCHEDULE“A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Service Engine Soon (Malfunction Indicator) . . . 202
Side Marker.......................... 419
Theft Alarm.......................... 200
Turn Signal.....................138,418,419
Voltage............................. 199
Warning (Instrument Cluster Description)..... 196
Washer Fluid......................... 201
Load Leveling System.................... 185
Loading Vehicle...................181,336,337
Capacities........................... 337
Tires ............................... 312
Locks
Door................................ 17
Lower Anchors and Tether for CHildren (LATCH) . 74
Lubrication, Body....................... 391
Luggage Rack.......................... 182
Lumbar Support........................ 112
Maintenance, Airbag...................... 67Maintenance Free Battery.................. 387
Maintenance Procedures................... 379
Maintenance Schedule.................... 426
ScheduleA......................... 440
ScheduleB.......................... 429
Maintenance, Sunroof..................... 167
Malfunction Indicator Light..............202,377
Manual, Service......................... 454
Map/Reading Lights..................... 150
Mini-Trip Computer...................... 154
Mirrors................................ 92
Automatic Dimming..................... 92
Electric Remote........................ 94
Exterior Folding........................ 93
Heated.............................. 95
Outside.............................. 94
Rearview............................. 92
Vanity............................... 95
Modifications/Alterations, Vehicle............. 7
INDEX 467
10

Rear Wiper/Washer...................285,286
Rearview Mirrors........................ 92
Reclining Front Seats..................... 110
Recommended Fluids, Lubricants and Genuine
Parts............................... 422
Reminder, Seat Belt....................... 51
Remote Keyless Entry..................... 20
Remote Sound System Controls.............. 258
Removable Floor Console...............176,178
Replacement Keys........................ 15
Replacement Parts....................... 378
Replacement Tires....................... 323
Reporting Safety Defects................... 453
Restraint, Head......................... 109
Restraints, Child.......................69,76
Restraints, Infant......................... 70
Rocking Vehicle When Stuck................ 368
Roof Rack............................. 182
Rotation, Tires.......................... 329Safety Checks Inside Vehicle................. 84
Safety Checks Outside Vehicle............... 85
Safety Defects, Reporting.................. 453
Safety, Exhaust Gas....................... 38
Safety Information, Tire................... 308
Safety Tips............................. 83
Satellite Radio.......................... 254
Satellite Radio Antenna................... 257
Schedule, Maintenance.................... 426
Seat Belt Maintenance.................... 410
Seat Belt Reminder....................... 51
Seat Belts.............................. 41
Adjustable Shoulder Belt.................. 47
Adjustable Upper Shoulder Anchorage........ 47
And Pregnant Women................... 52
Center Lap Belt........................ 50
Child Restraint......................... 69
Extender............................. 52
Front Seat............................ 42
470 INDEX