brake fluid DODGE CARAVAN 2006 4.G User Guide

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4 Automatic Transmission Fluid.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MoparATF+4 Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 445
7

•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed.
MAINTENANCE SCHEDULES 449
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
450 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 57, 000 60, 000 63, 000 66, 000 69, 000 72, 000
(Kilometers) (95 000) (100 000) (105 000) (110 000) (115 000) (120 000)
Change engine oil and engine oil filter. X XXXXX
Rotate Tires X X X
Inspect the brake linings. X X
Inspect the engine air cleaner filter, replace if necessary. * XXXXX
Replace theengine air cleaner filter.X
Replace thespark plugs
on 2.4 liter engines.X
Replace theignition cables
on 2.4 liter engines.X
Inspect the tie rod ends and boot seals. X
Inspect and adjust the power steering pump belt tension
on 2.4 liter engines.X
Inspect the generator belt on 2.4 liter engines, replace if
necessary.X
Inspect thePCV valve
and replace if necessary.*X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary.X
Change the automatic transmission fluid and filter.X
Replace the air conditioning filter. X X
SCHEDULE“B”455
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (180 000) (185 000) (190 000) (195 000) (200 000)
Change engine oil and engine oil filter. X X X X X
Rotate Tires X X X
Inspect the brake linings. X X
Inspect the engine air cleaner filter, replace if necessary. * X X X X
Replace theengine air cleaner filter.X
Replace thespark plugs
on 2.4 liter engines.X
Replace theignition cables
on 2.4 liter engines.X
Inspect and adjust the power steering pump belt tension on
2.4 liter engines.X
Inspect the generator belt on 2.4 liter engines, replace if
necessary.X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary.‡X
Inspect the tie rod ends and boot seals.X
Inspect thePCV valve
and replace as necessary.*X
Change the automatic transmission fluid and filter.X
Replace the air conditioning filter. X X
SCHEDULE“B”459
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 346
Adding Washer Fluid..................299,414
Additives, Fuel......................... 344
Adjustable Pedals....................... 153
Air Conditioner Maintenance............... 410
Air Conditioning.....................274,279
Air Conditioning Controls................. 274
Air Conditioning Filter.................296,411
Air Conditioning, Operating Tips............ 296
Air Conditioning, Rear Zone.............282,291
Air Conditioning Refrigerant............... 410
Air Conditioning System..........274,279,284,410
Air Conditioning System, Zone Control........ 275
Air Pressure, Tires....................... 329
Airbag................................ 54
Airbag Deployment....................... 66
Airbag Light...................59,60,68,84,206
Airbag Maintenance....................... 68
Airbag, Window (Side Curtain)............... 55Alarm Light........................... 208
Alarm System (Security Alarm)............... 26
Alignment and Balance................... 336
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 269
Antifreeze (Engine Coolant)...........417,418,443
Disposal............................ 419
Anti-Lock Brake System (ABS).............. 315
Anti-Lock Warning Light.................. 207
Anti-Theft Security Alarm (Theft Alarm)........ 26
Appearance Care........................ 428
Arming Theft System (Security Alarm)......... 27
Ashtray............................... 178
Auto Down Power Windows................ 41
Automatic Dimming Mirror................. 90
Automatic Door Locks...................19,20
Automatic Headlights.................... 145
Automatic Temperature Control (ATC)......... 284
Automatic Transaxle...................... 309
482 INDEX

Interlock System....................... 310
Reset Mode.......................... 311
Selection Of Lubricant................425,445
Shifting............................. 311
Special Additives...................... 427
Automatic Transmission................... 424
Adding Fluid......................... 426
Fluid and Filter Changes................. 427
Fluid Change......................... 427
Fluid Level Check...................... 426
Fluid Type........................425,445
Ball Joints............................. 412
Battery............................... 409
Gas Caution.......................... 409
Jump Starting......................... 387
Keyless Transmitter Replacement (RKE)....... 25
Saving Feature (Protection)............... 145
Bearings.............................. 428Belts, Drive............................ 405
Body Mechanism Lubrication............... 413
B-Pillar Location........................ 324
Brake Fluid............................ 445
Brake, Parking.......................... 313
Brake System........................314,421
Anti-Lock (ABS)....................... 315
Fluid Check.......................... 423
Hoses.............................. 422
Warning Light........................ 205
Brakes.............................314,421
Brake/Transmission Interlock............... 310
Break-In Recommendations, New Vehicle........ 82
Bulb Replacement....................... 438
Bulbs, Light............................ 437
Calibration, Compass..................... 159
Capacities, Fluid........................ 443
INDEX 483
10

Temperature Gauge..................... 208
Exhaust Gas Caution..............37,83,345,415
Exhaust System......................... 415
Extender, Seat Belt........................ 53
Exterior Folding Mirrors................... 91
Filters
Air Cleaner.......................... 406
Air Conditioning....................296,411
Automatic Transaxle.................... 427
Engine Oil........................405,444
Engine Oil Disposal.................... 405
Flashers
Hazard Warning....................... 366
Turn Signal.....................205,439,441
Flat Tire Stowage........................ 377
Fluid Capacities......................... 443
Fluid Leaks............................. 84Fluid Level Checks
Automatic Transmission................. 426
Brake............................... 423
Power Steering........................ 412
Fluids................................ 444
Fluids, Lubricants and Genuine Parts.......... 444
Fog Light Service........................ 440
Fog Lights..........................146,440
Fold in Floor (Stown Go) Seating........... 123
Freeing A Stuck Vehicle................... 390
Fuel................................. 342
Adding............................. 346
Additives............................ 344
Clean Air............................ 342
Filler Cap (Gas Cap).................... 346
Gasoline............................ 342
Gauge.............................. 204
Hoses.............................. 424
Light............................... 204
INDEX 487
10

Panic Alarm............................ 23
Parking Brake.......................... 313
Parking On Hill......................... 313
Passing Light........................... 148
Pedals, Adjustable....................... 153
Pets, Transporting........................ 78
Phone, Cellular.......................... 94
Phone, Hands-Free (UConnect™) ............. 94
Placard, Tire and Loading Information......... 324
Power
Brakes.............................. 314
Distribution Center..................... 434
Door Locks........................... 18
Lift Gate............................. 35
Mirrors.............................. 92
Outlet (Auxiliary Electrical Outlet).......... 175
Seats............................... 118
Sliding Door.......................... 30
Steering............................. 317Steering, Checking..................... 412
Sunroof............................. 173
Windows............................. 41
Power Steering Fluid..................... 445
Pregnant Women and Seat Belts.............. 53
Preparation for Jacking.................369,381
Pretensioners
Seat Belts............................. 51
Programmable Electronic Features......164,169,172
Programming Transmitters
(Remote Keyless Entry)...............23,169,172
Radial Ply Tires......................... 331
Radiator Cap (Coolant Pressure Cap).......416,418
Radio Broadcast Signals................... 212
Radio Operation...................234,252,274
Radio Remote Controls.................258,270
Radio, Satellite.......................... 266
Radio (Sound Systems).........214,224,234,244,251
INDEX 493
10