trailer DODGE CARAVAN 2007 4.G Owner's Manual

Change Engine Oil
Road conditions and your kind of driving affects the
interval at which your oil should be changed. Check the
following list to see if any apply to you.
•Day or night temperatures are below 32°F (0°C).
•Stop and Go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.
•Taxi, Police or delivery service (commercial service).
•Off-Road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
If ANY of these apply to you, then change your engine oil
at every interval shown in schedule “B” of the “Mainte-
nance Schedules” section of this manual.
If none of these apply to you, then change your engine oil
at every interval shown on schedule “A” of the “Main-
tenance Schedules” section of this manual
NOTE: Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
Engine Oil Selection
For best performance and maximum protection under all
types of operating conditions, the manufacturer only
recommends engine oils that are API certified and meet
the requirements of DaimlerChrysler Material Standard
MS-6395.
MAINTAINING YOUR VEHICLE 421
7

CAUTION!
Do not overfill. Dirt and water in the transmission
can cause serious damage. To prevent dirt and water
from entering the transmission after checking or
replenishing fluid, make certain that the dipstick cap
is reseated properly.
Fluid and Filter Changes
Automatic transmission fluid should be changed on all
transmissions as follows:
Normal Usage — No change necessary
Severe Usage (fluid and filter) — Refer to Maintenance
Schedule “B” Severe Usage is defined as:
•Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle is driven regularly for
more than 45 minutes of continuous operation.
NOTE: Refer to Section 8 of this manual for Mainte-
nance Schedules.
If the transmission is disassembled for any reason, the
fluid and filter should be changed.
Special Additives
Do not add any fluid additives to the transmission. The
only exception to this policy is the use of special dyes to
aid in detecting fluid leaks. The use of transmission
sealers should be avoided as they may adversely affect
seals.
MAINTAINING YOUR VEHICLE 445
7

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
type must be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE: Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part, which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
required service for your vehicle.
First is Schedule “B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 0° C (32° F).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 16 km (10 miles).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 32° C (90° F).
•Trailer towing. \b
466 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 96 000
km (60,000 miles) if the vehicle is usually operated under
one or more of the conditions marked with an \b.
•Day or night temperatures are below 0° C (32° F).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 16 km (10 miles).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 32° C (90° F).
•Trailer towing. \b
•Taxi, police, or delivery service (commercial ser-
vice). \b
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
SCHEDULE “B” 469
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (180 000) (185 000) (190 000) (195 000) (200 000)
Inspect the serpentine drive belt on 3.3 liter
and 3.8 liter engines, replace if necessary. ‡ X
Change the automatic transmission fluid and
filter.
X
Replace the air conditioning filter. XX
‡ This maintenance is not required if previously replaced.

This maintenance is required only for police, taxi,
limousine type operation, or trailer towing. Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 477
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Head Phones........................... 268
Head Restraints ......................... 125
Headlights ............................ 151
Bulb Replacement ...................... 456
High Beam/Low Beam Select Switch ........ 156
Lights On Reminder .................... 153
Replacing ............................ 456
Time Delay .......................... 154
Heated Seats ........................... 126
Heater ............................... 278
Heater, Engine Block ..................... 315
Hitches Trailer Towing ........................ 371
HomeLink (Garage Door Opener) Transmitter . . . 177
Hood Release .......................... 149
Hook, Coat ............................ 198
Hoses ............................. 439,442
Ignition ............................... 12 Key ................................. 12
Ignition Key Removal ..................... 12
Illuminated Entry ........................ 20
Immobilizer (Sentry Key) ................... 15
Indicator, Traction Control ................. 218
Infant Restraint ........................ 75,76
Information Center ...................... 172
Information Center, Vehicle ................. 172
Inside Rearview Mirror .................... 96
Instrument Cluster ................. 209,210,211
Instrument Panel and Controls .............. 208
Instrument Panel Lens Cleaning ............. 450
Integrated Child Seat ...................... 74
Integrated Power Module (Fuses) ............ 452
Interior Appearance Care .................. 448
Interior Lights ....................... 151,152
Intermittent Wipers (Delay Wipers) .....157,301,303
Introduction ............................. 4
INDEX 503
10

Load Capacity..................... 332,333
Pressure Monitor System (TPMS) ........... 347
Quality Grading ....................... 491
Radial .............................. 339
Replacement ......................... 343
Rotation ............................. 346
Safety ........................... 327,336
Sizes ............................... 328
Snow Tires ........................... 346
Spare Tire ......................... 389,400
Spinning ............................ 341
Tread Wear Indicators ................... 342
Tongue Weight/Trailer Weight .............. 374
Towing ............................... 367
Disabled Vehicle ....................... 408
Guide .............................. 372
Recreational ....................... 382,410
Weight .............................. 372
Traction Control ................... 158,218,324 Traction Control Switch
.................158,324
Trailer Towing .......................... 367
Cooling System Tips .................... 382
Hitches ............................. 371
Minimum Requirements ................. 376
Trailer and Tongue Weight ................ 374
Wiring .............................. 380
Trailer Towing Guide ..................... 372
Trailer Weight .......................... 372
Transaxle ............................. 315
Automatic ......................... 12,315
Operation ........................... 315
Overdrive ........................... 318
Selection of Lubricant ................443,463
Transmission ........................... 442
Automatic ........................... 442
Filter ............................... 445
Fluid ............................ 443,463
512 INDEX