air condition DODGE CARAVAN 2008 5.G Owner's Guide

The Heated Mirrors, Lower Instrument Panel Power
Outlet and Removable Floor Console, when in the front
position are fused with self-resetting fuses that are only
serviceable by an authorized dealer. The power seats are
fused by a 30 Amp circuit breaker located under the
driver's seat. The Power Windows are fused by a 25 Amp
circuit breaker located under the instrument panel near
the steering column. If you experience temporary or
permanent loss of these systems, see your authorized
dealer for service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may do the following:
²Remove the 20 Amp mini-fuse in the Integrated Power
Module labeled Ignition-Off Draw (IOD).
²Or, disconnect the negative cable from the battery.
²Anytime you store your vehicle, or keep it out of
service for two weeks or more, run the air conditioning
system at idle for about five minutes in the fresh air
and high blower setting. This will ensure adequate
system lubrication to minimize the possibility of com-
pressor damage when the system is started again.
REPLACEMENT LIGHT BULBS
LIGHT BULBS Ð Interior Bulb Number
Center & Rear Dome Light.................. 578
Center & Rear Reading Lights............... 578
Front Door Courtesy Light.................. 578
Front Header Reading Lights Ð If Equipped..... 578
Instrument Cluster Lights.................PC74
Liftgate Light(s).......................... 578
Overhead Console Reading Lights..........PC579
Removable Console Light Ð If Equipped....... 194
Visor Vanity Lights....................6501966
MAINTAINING YOUR VEHICLE 481
7

EMISSIONS CONTROL SYSTEM MAINTENANCE
The Scheduled Maintenance services listed inbold type,
must be done at the times or mileages specified to ensure
the continued proper functioning of the Emissions Con-
trol System. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions, such as dusty areas and very short trip
driving.
Inspection and service should also be done anytime a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sions control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part that has been
certified pursuant to U.S. EPA or in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
The oil change indicator system will remind you that it is
time to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehiclesCHAngE OILwill flash
in the instrument cluster odometer and a single chime
will sound, indicating that an oil change is necessary.
On Electronic Vehicle Information Center (EVIC)
equipped vehiclesOil Change Requiredwill be dis-
played in the EVIC and a single chime will sound,
indicating that an oil change is necessary.
Based on engine operation conditions the oil change
indicator message will illuminate, this means that service
is required for your vehicle. Have your vehicle serviced
as soon as possible, within the next 500 mi (805 km).
490 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Required Maintenance Intervals
Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the engine oil and engine oil filter. 6,000 10 000 6
Rotate Tires. 6,000 10 000 6
If using your vehicle for any of the following: Dusty
or off-road conditions. Inspect the engine air cleaner
filter, replace if necessary.12,000 20 000 12
Inspect the brake linings, replace if necessary. 12,000 20 000 12
Replace the air conditioning filter. 12,000 20 000 12
Inspect the CV Joints. Perform the first inspection at
12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect Exhaust System. Perform the first inspection at
12,000 mi (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals, replace if necessary.24,000 40 000 24
Replace the engine air cleaner filter. 30,000 50 000 30
MAINTENANCE SCHEDULES 493
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Engine Coolant (Antifreeze).......... 458
Adding Fuel........................... 382
Adding Washer Fluid..................... 455
Additives, Fuel......................... 380
Adjustable Pedals....................... 177
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 445
Air Conditioner Maintenance............... 450
Air Conditioning........................ 301
Air Conditioning Controls................. 301
Air Conditioning Filter.................320,451
Air Conditioning, Operating Tips............ 319
Air Conditioning, Rear Zone.............307,314
Air Conditioning Refrigerant............... 450
Air Conditioning System.............301,309,450
Air Conditioning System, Zone Control........ 305
Air Pressure, Tires....................... 358
Airbag..............................66,74
Airbag Deployment....................... 75
Airbag Light...................67,73,77,94,233Airbag Maintenance....................... 76
Airbag, Side........................68,72,74
Airbag, Window (Side Curtain)...........70,72,74
Alarm Light........................... 233
Alarm (Security Alarm).................... 18
Alignment and Balance................... 366
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 288
Antifreeze (Engine Coolant)...........457,458,486
Disposal............................ 459
Anti-Lock Brake System (ABS).............. 338
Anti-Lock Warning Light...............227,339
Anti-Theft System........................ 18
Appearance Care........................ 467
Ashtray............................... 201
Assistance Towing....................... 117
Audio Systems (Radio).................280,283
Auto Down Power Windows................ 39
Auto Up Power Windows................40,194
508 INDEX

Emission Control System Maintenance......438,490
Engine........................93,434,435,436
Air Cleaner.......................... 445
Block Heater......................... 327
Break-In Recommendations................ 93
Checking Oil Level..................... 441
Compartment......................435,436
Coolant (Antifreeze).................... 487
Cooling............................. 456
Exhaust Gas Caution..................51,381
Flooded, Starting...................... 326
Fuel Requirements..................377,486
Oil ...........................441,486,487
Oil Change Interval.................... 442
Oil Disposal.......................... 444
Oil Filler Cap......................434,443
Oil Filter Disposal...................... 444
Oil Selection.......................442,486
Oil Synthetic......................... 444Operation............................ 93
Overheating.......................... 410
Starting............................. 324
Temperature Gauge..................... 226
Enhanced Accident Response Feature.......... 74
Event Data Recorder...................... 78
Exhaust Gas Caution..............51,95,381,448
Exhaust System......................... 447
Extender, Seat Belt........................ 66
Exterior Folding Mirrors................... 102
Fabric Care.........................470,471
Filler Location Fuel...................... 226
Filters
Air Cleaner.......................... 445
Air Conditioning....................320,451
Engine Oil........................444,487
Engine Oil Disposal.................... 444
INDEX 513
10

Pretensioners
Seat Belts............................. 64
Programmable Electronic Features............ 248
Radial Ply Tires......................... 361
Radiator Cap (Coolant Pressure Cap).......457,458
Radio Broadcast Signals................... 251
Radio, Navigation....................... 283
Radio Operation...................281,284,299
Radio Remote Controls.................... 299
Radio, Satellite............280,281,283,284,287,297
Radio (Sound Systems).................280,283
Rear Air Conditioning.................307,314
Rear Heater............................ 307
Rear Park Sense System................... 171
Rear Window Defroster................... 320
Rearview Mirrors........................ 100
Reclining Front Seats..................... 136
Recorder, Event Data...................... 78Recreational Towing...................407,429
Reminder, Seat Belt....................... 64
Remote Keyless Entry (RKE)................. 21
Remote Sound System (Radio) Controls........ 299
Remote Starting System.................... 28
Removable Floor Console...............207,211
Replacement Keys........................ 16
Replacement Parts....................... 440
Replacement Tires....................... 365
Reporting Safety Defects................... 503
Resetting Oil Change Indicator.........230,237,243
Restraint, Head......................... 134
Restraints, Child.......................81,88
Restraints, Infant......................... 81
Rocking Vehicle When Stuck................ 427
Roof Rack (Luggage Rack)................. 215
Rotation, Tires.......................... 368
Safety Checks Inside Vehicle................. 93
INDEX 521
10