brake fluid DODGE CARAVAN 2011 User Guide

WARNING! (Continued)
•Do not allow petroleum based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in a collision.
Automatic Transmission
The automatic transmission and differential assembly are
contained within a single housing.
The fluid level in the automatic transmission should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transmission and the fluid.
The six–speed transmission is equipped with a capped
dipstick tube. It is sealed and should not be tampered
with. Your authorized dealer has the necessary tools to
ensure that the fluid level is set properly.
Selection Of Lubricant
It is important that the proper lubricant is used in the
transmission to assure optimum transmission perfor-
mance. Use only the manufacturer’s recommended trans-
mission fluid. Refer to “Fluids, Lubricants, and Genuine
Parts” in “Maintaining Your Vehicle” for further informa-
tion. It is important that the transmission fluid be main-
tained at the prescribed level using the recommended
fluid. No chemical flushes should be used in any trans-
mission; only the approved lubricant may be used.
492 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission MOPAR
ATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Brake Master Cylinder MOPAR
DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPAR
Power Steering Fluid +4, MOPAR ATF+4Automatic Trans-
mission Fluid or equivalent licensed ATF+4 product.
7
MAINTAINING YOUR VEHICLE 513
ProCarManuals.com

•Under no circumstances should oil change intervals
exceed 8,000 miles (13 000 km) or six months, which-
ever comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)/Oil Change Required” in
“Understanding Your Instrument Panel” or under “In-
strument Cluster Description/Odometer/Trip Odom-
eter” in “Understanding Your Instrument Panel” for
further information.
At Each Stop For Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut OFF. Checking the oil
level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only
when the level is at or below the ADD, SAFE or MIN
mark.
•Check the windshield washer solvent and add if
required.
Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, the
brake master cylinder, the power steering and the
transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 517
ProCarManuals.com

56,000 Miles (91,000 km) or
42 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
56,000 miles (91 000 km).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
64,000 Miles (104,000 km) or 48 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
64,000 miles (104 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings; replace if necessary.
❏ Change the automatic transmission fluid and filter(s) if using your vehicle for any of the
following: police, taxi, fleet, or frequent trailer towing.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S522 MAINTENANCE SCHEDULES
ProCarManuals.com

120,000 Miles (195,000 km) or
90 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
120,000 miles (195 000 km).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Change the automatic transmission fluid
and filter(s).
❏ Replace the accessory drive belt(s).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
128,000 Miles (208,000 km) or 96 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
128,000 miles (208 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S526 MAINTENANCE SCHEDULES
ProCarManuals.com

Automatic TransaxleAdding Fluid ....................... 493
Fluid Level Check .................... 493
Selection Of Lubricant ..............492,513
Shifting ........................... 358
Special Additives ..................... 493
Automatic Transmission .............354,492,493
Adding Fluid ....................... 493
Fluid and Filter Changes ............... 493
Fluid Change ....................... 493
Fluid Type ...................... 492,513
B-Pillar Location ........................ 382
Battery ............................... 478
Jump Starting ....................... 456
Keyless Transmitter Replacement (RKE) ..... 26
Saving Feature (Protection) .............. 171
Belts, Seat ............................. 102
Blind Spot Monitoring .................... 118 Body Mechanism Lubrication
............... 482
Brake Assist System ...................... 372
Brake Control System, Electronic ............. 371
Brake Fluid ............................ 513
Brake System ........................... 489
Fluid Check ........................ 490
Parking ........................... 367
Warning Light ....................... 257
Brake/Transmission Interlock ............... 355
Brakes ............................... 489
Break-In Recommendations, New Vehicle ....... 100
Bulb Replacement ....................... 507
Bulbs, Light ......................... 104,507
Calibration, Compass .................. 265,278
Camera, Rear ........................... 191
Capacities, Fluid ........................ 511
Caps, Filler Fuel .............................. 416
10
INDEX 541
ProCarManuals.com

Flooded Engine Starting................... 352
Floor Console .......................... 224
Fluid Capacities ......................... 511
Fluid Leaks ............................ 105
Fluid Level Checks Automatic Transaxle .................. 493
Brake ............................. 490
Power Steering ...................... 366
Fluids ................................ 512
Fluids, Lubricants and Genuine Parts .......... 512
Fog Light Service ........................ 508
Fog Lights ....................... 167,249,508
Fold in Floor (Stow \bn Go) Seating........... 139
Freeing A Stuck Vehicle ................... 460
Fuel ................................. 408
Adding ........................... 416
Additives .......................... 410
Clean Air .......................... 408
Conserving ......................... 274 Economy Mode
...................... 356
Ethanol ........................... 409
Filler Cap (Gas Cap) ...............256,416
Filler Door (Gas Cap) .................. 256
Gasoline ........................... 408
Gauge ............................ 256
Light .......................... 260,270
Materials Added ..................... 410
Methanol .......................... 409
Octane Rating ....................... 512
Requirements .................... 408,511
Saver Mode ........................ 274
Tank Capacity ....................... 511
Fuel Optimizer ......................... 274
Fuel Saver ............................. 274
Fuel, Flexible ........................... 412
Fueling ............................... 416
Fuses ................................ 499
546 INDEX
ProCarManuals.com

Hood............................. 163
Lead Free Gasoline ...................... 408
Leaks, Fluid ........................... 105
Life of Tires ............................ 393
Liftgate ................................ 49
Light Bulbs ............................ 104
Lights ............................. 104,165
Airbag ..................... 79,85,102,257
Alarm ............................ 257
Anti-Lock .......................... 252
Automatic Headlights ................. 165
Back-Up ........................... 509
Battery Saver ....................... 171
Brake Assist Warning .................. 375
Brake Warning ...................... 257
Bulb Replacement .................... 507
Center Mounted Stop .................. 510
Daytime Running .................... 167
Dimmer Switch, Headlight .............. 167 Electronic Stability Program (ESP) Indicator . . 375
Engine Temperature Warning
............ 261
Exterior ........................... 104
Fog ......................... 167,249,508
Hazard Warning Flasher ............... 438
Headlights ......................... 507
Headlights On Reminder ............... 166
High Beam Indicator .................. 249
High Beam/Low Beam Select ............ 170
Illuminated Entry ..................... 19
Interior ............................ 167
License ............................ 510
Lights On Reminder .................. 166
Low Fuel ....................... 260,270
Malfunction Indicator (Check Engine) ...... 254
Oil Pressure ........................ 261
Park .............................. 508
Passing ............................ 170
Reading ........................... 194
10
INDEX 549
ProCarManuals.com

Overhead Console....................... 193
Overhead Travel Information Center .......... 193
Overheating, Engine ................... 260,438
Owner’s Manual (Operator Manual) .........4,535
Panic Alarm ............................ 23
Park Sense System, Rear ................... 182
Parking Brake .......................... 367
Pedals, Adjustable ....................... 177
Personal Settings ........................ 279
Pets, Transporting ........................ 97
Phone, Cellular ......................... 127
Phone, Hands-Free (Uconnect™) ............. 127
Placard, Tire and Loading Information ......... 382
Power Door Locks ......................... 34
Lift Gate ........................... 50
Mirrors ............................ 115
Outlet (Auxiliary Electrical Outlet) ........ 207Seats
............................. 128
Sliding Door ......................... 43
Steering ........................ 365,366
Sunroof ........................... 204
Windows ........................... 37
Windows, Express Down ................ 22
Power Steering Fluid ..................... 513
Pregnant Women and Seat Belts .............. 71
Preparation for Jacking .................... 447
Pretensioners Seat Belts ........................... 65
Programmable Electronic Features ............ 279
Radial Ply Tires ......................... 389
Radiator Cap (Coolant Pressure Cap) .......484,487
Radio Operation ........................ 321
Radio Remote Controls .................... 319
Rear Air Conditioning .................330,340
Rear Camera ........................... 191
552 INDEX
ProCarManuals.com