brake fluid DODGE CARAVAN 2012 User Guide

WARNING! (Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep the
master cylinder reservoir cap secured at all times.
Brake fluid in a open container absorbs moisture
from the air resulting in a lower boiling point.
This may cause it to boil unexpectedly during hard
or prolonged braking, resulting in sudden brake
failure. This could result in a collision.
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.(Continued)
WARNING! (Continued)
•Do not allow petroleum based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in a collision.
Automatic Transmission
The automatic transmission and differential assembly are
contained within a single housing.
The fluid level in the automatic transmission should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transmission and the fluid.
The six–speed transmission is equipped with a capped
dipstick tube. It is sealed and should not be tampered
with. Your authorized dealer has the necessary tools to
ensure that the fluid level is set properly.
7
MAINTAINING YOUR VEHICLE 569
ProCarManuals.com

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission MOPAR
ATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Brake Master Cylinder MOPAR
DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPAR
Power Steering Fluid +4, MOPAR ATF+4Automatic Trans-
mission Fluid or equivalent licensed ATF+4 product.
7
MAINTAINING YOUR VEHICLE 591
ProCarManuals.com

Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and the power steering and add as
needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
•Open the left and right door (slowly) and inspect for
excessive dirt. If noise exist wipe clean and apply
krytox lube to the door rollers.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S596 MAINTENANCE SCHEDULES
ProCarManuals.com

56,000 Miles (91,000 km) or
42 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
56,000 miles (91 000 km).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
64,000 Miles (104,000 km) or 48 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
64,000 miles (104 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings; replace if necessary.
❏ Change the automatic transmission fluid and filter(s) if using your vehicle for any of the
following: police, taxi, fleet, or frequent trailer towing.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S600 MAINTENANCE SCHEDULES
ProCarManuals.com

120,000 Miles (195,000 km) or
90 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
120,000 miles (195 000 km).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Change the automatic transmission fluid
and filter(s).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
128,000 Miles (208,000 km) or 96 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
128,000 miles (208 000 km).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S604 MAINTENANCE SCHEDULES
ProCarManuals.com

Automatic Headlights.................... 199
Automatic Temperature Control (ATC) ......... 400
Automatic Transaxle Selection Of Lubricant ................. 591
Automatic Transmission ................422,569
Adding Fluid ....................... 571
Fluid and Filter Changes ............... 571
Fluid Change ....................... 571
Fluid Level Check .................... 571
Fluid Type ...................... 570,591
Gear Ranges ........................ 427
Special Additives ..................... 570
B-Pillar Location ........................ 457
Battery ............................... 556
Jump Starting ....................... 532
Keyless Transmitter Replacement (RKE) ..... 26
Saving Feature (Protection) .............. 204
Belts, Seat ............................. 101 Blind Spot Monitoring
.................... 117
Body Mechanism Lubrication ............... 560
Brake Assist System ...................... 444
Brake Control System, Electronic ............. 443
Brake Fluid ............................ 591
Brake System ........................... 567
Fluid Check ........................ 568
Parking ........................... 439
Warning Light ....................... 294
Brake/Transmission Interlock ............... 424
Brakes ............................... 567
Break-In Recommendations, New Vehicle ........ 98
Bulb Replacement ....................... 586
Bulbs, Light ......................... 103,585
Calibration, Compass ..................... 314
Camera, Rear ........................... 224
Capacities, Fluid ........................ 589
10
INDEX 621
ProCarManuals.com

Replacement Parts.................... 490
Starting ........................... 489
Flooded Engine Starting ................... 420
Floor Console .......................... 261
Fluid Capacities ......................... 589
Fluid Leaks ............................ 103
Fluid Level Checks Automatic Transmission ................ 571
Brake ............................. 568
Power Steering ...................... 438
Fluids ................................ 590
Fluids, Lubricants and Genuine Parts .......... 590
Fog Light Service ........................ 587
Fog Lights ....................... 200,286,587
Fold in Floor (Stow n Go) Seating........... 172
Freeing A Stuck Vehicle ................... 536
Fuel ................................. 482
Adding ........................... 490
Additives .......................... 484 Clean Air
.......................... 482
Conserving ......................... 310
Economy Mode ...................... 425
Ethanol ........................... 483
Filler Cap (Gas Cap) ...............293,490
Filler Door (Gas Cap) .................. 293
Gasoline ........................... 482
Gauge ............................ 293
Light .......................... 297,306
Materials Added ..................... 484
Methanol .......................... 483
Octane Rating ....................... 590
Requirements .................... 482,589
Saver Mode ........................ 310
Tank Capacity ....................... 589
Fuel Optimizer ......................... 310
Fuel Saver ............................. 310
Fuel, Flexible ........................... 486
Fueling ............................... 490
626 INDEX
ProCarManuals.com

LATCH
(Lower Anchors and Tether for CHildren)....... 90
Latches ............................... 103
Hood ............................. 196
Lead Free Gasoline ...................... 482
Leaks, Fluid ........................... 103
Life of Tires ............................ 468
Liftgate ................................ 48
Light Bulbs ............................ 103
Lights ............................. 103,198
Airbag ..................... 77,83,101,293
Alarm ............................ 294
Anti-Lock .......................... 289
Automatic Headlights ................. 199
Back-Up ........................... 588
Battery Saver ....................... 204
Brake Assist Warning .................. 448
Brake Warning ...................... 294
Bulb Replacement ................. 585,586Center Mounted Stop
.................. 588
Daytime Running .................... 200
Dimmer Switch, Headlight .............. 201
Electronic Stability Program (ESP) Indicator . . 448
Engine Temperature Warning ............ 298
Exterior ........................... 103
Fog ......................... 200,286,587
Hazard Warning Flasher ............... 513
Headlights ......................... 586
Headlights On Reminder ............... 200
High Beam Indicator .................. 286
High Beam/Low Beam Select ............ 204
Illuminated Entry ..................... 19
Interior ............................ 201
License ............................ 589
Lights On Reminder .................. 200
Low Fuel ....................... 297,306
Malfunction Indicator (Check Engine) ...... 291
Oil Pressure ........................ 297
10
INDEX 629
ProCarManuals.com

Viscosity........................ 552,589
Onboard Diagnostic System ..............546,547
Opener, Garage Door (HomeLink®) ........... 231
Operator Manual (Owner’s Manual) ............ 4
Outside Rearview Mirrors ............... 112,113
Overhead Console ....................... 227
Overhead Travel Information Center .......... 227
Overheating, Engine ................... 296,513
Owner’s Manual (Operator Manual) .........4,615
Panic Alarm ............................ 23
Park Sense System, Rear ................... 215
Parking Brake .......................... 439
Pedals, Adjustable ....................... 210
Personal Settings ........................ 315
Pets, Transporting ........................ 95
Phone, Cellular ......................... 125
Phone, Hands-Free (Uconnect™) ............. 125
Placard, Tire and Loading Information ......... 457Power
Door Locks ......................... 34
Lift Gate ........................... 49
Mirrors ............................ 114
Outlet (Auxiliary Electrical Outlet) ........ 244
Seats ............................. 160
Sliding Door ......................... 42
Steering ........................ 437,438
Sunroof ........................... 241
Windows ........................... 36
Power Steering Fluid ..................... 591
Pregnant Women and Seat Belts .............. 69
Preparation for Jacking .................... 522
Pretensioners Seat Belts ........................... 64
Programmable Electronic Features ............ 315
Radial Ply Tires ......................... 464
Radiator Cap (Coolant Pressure Cap) .......562,565
632 INDEX
ProCarManuals.com