check engine light DODGE CARAVAN 2012 User Guide

“Electronic Vehicle Information Center (EVIC)” in ”Un-
derstanding Your Instrument Panel” for further informa-
tion. Tighten the gas cap until aclickingsound is heard.
This is an indication that the gas cap is properly tight-
ened.
Press the odometer reset button to turn the message off.
If the problem persists, the message will appear the next
time the vehicle is started. This might indicate a damaged
cap. If the problem is detected twice in a row, the system
will turn on the MIL. Resolving the problem will turn the
MIL light off.
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration. For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system may notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition key-actuated test,
which you can use prior to going to the test station. To
check if your vehicle’s OBD II system is ready, you must
do the following:
1. Turn the ignition switch to the ON position, but do not
crank or start the engine.
7
MAINTAINING YOUR VEHICLE 547
ProCarManuals.com

Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
NOTE:Life expectancy of wiper blades varies depend-
ing on geographical area and frequency of use. Poor
performance of blades may be present with chattering,
marks, water lines or wet spots. If any of these conditions
are present, clean the wiper blades or replace as neces-
sary.
Adding Washer Fluid
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the engine
compartment and should be checked at regular intervals.
Fill the reservoir with windshield washer solvent (not
radiator antifreeze) and operate the system for a few
seconds to flush out any residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.
WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around
the washer solution.
After the engine has warmed, operate the defroster for a
few minutes to reduce the possibility of smearing or
freezing the fluid on the cold windshield. MOPAR All
Weather Windshield Washer Solution or equivalent, used
with water as directed on the container, aids cleaning
action, reduces the freezing point to avoid line clogging,
and is not harmful to paint or trim.
7
MAINTAINING YOUR VEHICLE 561
ProCarManuals.com

Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and the power steering and add as
needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
•Open the left and right door (slowly) and inspect for
excessive dirt. If noise exist wipe clean and apply
krytox lube to the door rollers.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S596 MAINTENANCE SCHEDULES
ProCarManuals.com

Caps, FillerFuel .............................. 490
Oil (Engine) ........................ 552
Power Steering ...................... 438
Radiator (Coolant Pressure) ............. 565
Car Washes ............................ 572
Carbon Monoxide Warning ..............100,486
Cargo (Vehicle Loading) ................... 260
Cargo Compartment Luggage Carrier ..................... 271
Caution, Exhaust Gas ...................... 51
Cellular Phone ....................... 125,392
Center High Mounted Stop Light ............ 588
Chains, Tire ............................ 470
Changing A Flat Tire ..................... 514
Chart, Tire Sizing ........................ 453
Check Engine Light
(Malfunction Indicator Light) .............291,547
Checking Your Vehicle For Safety ............. 99Checks, Safety
........................... 99
Child Restraint ...................... 85,86,87
Child Restraint Tether Anchors ............... 90
Child Safety Locks ........................ 46
Child Seat .............................. 89
Clean Air Gasoline ....................... 482
Cleaning Wheels ............................ 573
Climate Control ......................... 393
Clock ............................. 323,332
Coat Hook ............................ 260
Coin Holder ........................... 261
Cold Weather Operation ................... 420
Compact Disc (CD) Maintenance ............. 392
Compact Spare Tire ...................... 465
Compass .............................. 313
Compass Calibration ..................... 314
Compass Variance ....................... 314
Computer, Trip/Travel .................... 311
622 INDEX
ProCarManuals.com

Replacement Parts.................... 490
Starting ........................... 489
Flooded Engine Starting ................... 420
Floor Console .......................... 261
Fluid Capacities ......................... 589
Fluid Leaks ............................ 103
Fluid Level Checks Automatic Transmission ................ 571
Brake ............................. 568
Power Steering ...................... 438
Fluids ................................ 590
Fluids, Lubricants and Genuine Parts .......... 590
Fog Light Service ........................ 587
Fog Lights ....................... 200,286,587
Fold in Floor (Stow n Go) Seating........... 172
Freeing A Stuck Vehicle ................... 536
Fuel ................................. 482
Adding ........................... 490
Additives .......................... 484 Clean Air
.......................... 482
Conserving ......................... 310
Economy Mode ...................... 425
Ethanol ........................... 483
Filler Cap (Gas Cap) ...............293,490
Filler Door (Gas Cap) .................. 293
Gasoline ........................... 482
Gauge ............................ 293
Light .......................... 297,306
Materials Added ..................... 484
Methanol .......................... 483
Octane Rating ....................... 590
Requirements .................... 482,589
Saver Mode ........................ 310
Tank Capacity ....................... 589
Fuel Optimizer ......................... 310
Fuel Saver ............................. 310
Fuel, Flexible ........................... 486
Fueling ............................... 490
626 INDEX
ProCarManuals.com

LATCH
(Lower Anchors and Tether for CHildren)....... 90
Latches ............................... 103
Hood ............................. 196
Lead Free Gasoline ...................... 482
Leaks, Fluid ........................... 103
Life of Tires ............................ 468
Liftgate ................................ 48
Light Bulbs ............................ 103
Lights ............................. 103,198
Airbag ..................... 77,83,101,293
Alarm ............................ 294
Anti-Lock .......................... 289
Automatic Headlights ................. 199
Back-Up ........................... 588
Battery Saver ....................... 204
Brake Assist Warning .................. 448
Brake Warning ...................... 294
Bulb Replacement ................. 585,586Center Mounted Stop
.................. 588
Daytime Running .................... 200
Dimmer Switch, Headlight .............. 201
Electronic Stability Program (ESP) Indicator . . 448
Engine Temperature Warning ............ 298
Exterior ........................... 103
Fog ......................... 200,286,587
Hazard Warning Flasher ............... 513
Headlights ......................... 586
Headlights On Reminder ............... 200
High Beam Indicator .................. 286
High Beam/Low Beam Select ............ 204
Illuminated Entry ..................... 19
Interior ............................ 201
License ............................ 589
Lights On Reminder .................. 200
Low Fuel ....................... 297,306
Malfunction Indicator (Check Engine) ...... 291
Oil Pressure ........................ 297
10
INDEX 629
ProCarManuals.com

Park.............................. 587
Passing ............................ 204
Reading ........................... 228
Rear Servicing ....................... 588
Rear Tail ........................... 588
Seat Belt Reminder ................... 296
Security Alarm (Theft Alarm) ............ 294
Service ......................... 585,586
Service Engine Soon
(Malfunction Indicator) ................ 291
Side Marker ........................ 588
Theft Alarm (Security Alarm) ............ 294
Tire Pressure Monitoring (TPMS) ......... 289
Traction Control ..................... 448
Turn Signal ................... 103,587,588
Voltage ............................ 297
Warning (Instrument Cluster Description) . . . 286
Load Leveling System .................... 270 Loading Vehicle
................... 260,492,494
Capacities .......................... 494
Tires .............................. 457
Locks Automatic Door ...................... 35
Door .............................. 32
Lower Anchors and Tether for
CHildren (LATCH) ....................... 90
Lubrication, Body ....................... 560
Luggage Rack (Roof Rack) ................. 271
Maintenance Free Battery .................. 556
Maintenance Procedures ................... 549
Maintenance Schedule .................... 594
Maintenance, Sunroof ..................... 244
Malfunction Indicator Light (Check Engine) . . 291,547
Manual, Service ......................... 615
Map/Reading Lights ..................... 228
Memory Feature (Memory Seat) ............. 192
630 INDEX
ProCarManuals.com