flat tire DODGE CHALLENGER 2017 3.G Owner's Guide

If the tire inflates to the recommended pressure or is at
least 26 psi (1.8 Bar) pressure within 15 minutes:
1. Push the Power Button (4) to turn off the Tire ServiceKit.
2. Remove the Speed Limit sticker from the top of the Sealant Bottle (1) and place the sticker on the instrument
panel.
3. Immediately disconnect the Sealant Hose (6) from the valve stem, reinstall the cap on the fitting at the end of
the hose, and place the Tire Service Kit in the vehicle
storage location. Quickly proceed to (D) “Drive Ve-
hicle.”
CAUTION!
•The metal end fitting from Power Plug (8) may get
hot after use, so it should be handled carefully.
• Failure to reinstall the cap on the fitting at the end of
the Sealant Hose (6) can result in sealant contacting
your skin, clothing, and the vehicle’s interior. It can
also result in sealant contacting internal Tire Service
Kit components which may cause permanent damage
to the kit.
(D) Drive Vehicle:
Immediately after injecting sealant and inflating the tire,
drive the vehicle 5 miles (8 km) or 10 minutes to ensure
distribution of the Tire Service Kit Sealant within the tire.
Do not exceed 55 mph (90 km/h).
WARNING!
Tire Service Kit is not a permanent flat tire repair. Have
the tire inspected and repaired or replaced after using
Tire Service Kit. Do not exceed 55 mph (90 km/h) until
the tire is repaired or replaced. Failure to follow this
warning can result in injuries that are serious or fatal
to you, your passengers, and others around you.
(E) After Driving:
Pull over to a safe location. Refer to “Whenever You Stop to
Use Tire Service Kit” before continuing.
1. Push in the Mode Select Knob (5) and turn to the Air Mode position.
2. Uncoil the power plug and insert the plug into the vehicle’s 12 Volt power outlet.
3. Uncoil the Air Pump Hose (7) (black in color) and screw the fitting at the end of hose (7) onto the valve stem.
6
WHAT TO DO IN EMERGENCIES 389

4. Check the pressure in the tire by reading the PressureGauge (3).
If tire pressure is less than 19 psi (1.3 Bar):
The tire is too badly damaged. Do not attempt to drive the
vehicle further. Call for assistance.
If the tire pressure is 19 psi (1.3 Bar) or higher:
1. Push the Power Button (4) to turn on Tire Service Kit and inflate the tire to the pressure indicated on the tire
and loading information label on the driver-side door
opening.
NOTE: If the tire becomes over-inflated, push the Deflation
Button to reduce the tire pressure to the recommended
inflation pressure before continuing.
2. Disconnect the Tire Service Kit from the valve stem, reinstall the cap on the valve stem and unplug from 12
Volt outlet.
3. Place the Tire Service Kit in its proper storage area in the vehicle.
4. Have the tire inspected and repaired or replaced at the earliest opportunity at an authorized dealer or tire
service center. 5. Remove the Speed Limit sticker from the instrument
panel after the tire has been repaired.
6. Replace the Sealant Bottle (1) and Sealant Hose (6) assembly at your authorized dealer as soon as possible.
Refer to (F) “Sealant Bottle and Hose Replacement”.
NOTE: When having the tire serviced, advise the autho-
rized dealer or service center that the tire has been sealed
using the Tire Service Kit.
(F) Sealant Bottle And Hose Replacement:
1. Uncoil the Sealant Hose (6) (clear in color).
2. Locate the round Sealant Bottle release button in the recessed area under the sealant bottle.
3. Push the Sealant Bottle release button. The Sealant Bottle (1) will pop up. Remove the bottle and dispose of it
accordingly.
4. Clean any remaining sealant from the Tire Service Kit housing.
390 WHAT TO DO IN EMERGENCIES

6. Remove the jack and lug wrench assembly from underthe spare tire. Turn the jack screw to the left to loosen the
lug wrench, and remove the wrench from the jack
assembly.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the vehicle.
Always stow the jack parts and the spare tire in the
places provided. Have the deflated (flat) tire repaired
or replaced immediately.
Preparations For Jacking
1. Park the vehicle on a firm, level surface as far from theedge of the roadway as possible. Avoid icy or slippery
areas.
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic, pull far enough off the
road to avoid being hit when operating the jack or
changing the wheel.
2. Turn on the Hazard Warning flasher.
3. Set the parking brake.
4. Place the gear selector into PARK (automatic transmis- sion) or first gear (manual transmission).
5. Turn off the ignition.
6. Block both the front and rear of the wheel diagonally opposite of the jacking position. For ex-
ample, if changing the right front tire, block
the left rear wheel.
NOTE: Passengers should not remain in the
vehicle when the vehicle is being jacked.
Jack Fastener
394 WHAT TO DO IN EMERGENCIES

1. Remove the spare tire, jack, and lug wrench.
2. If equipped with aluminum wheels where the center capcovers the lug nuts, use the lug wrench to pry the center
cap off carefully before raising the vehicle.
3. Before raising the vehicle, use the lug wrench to loosen, but not remove, the lug nuts on the wheel with the flat
tire. Turn the lug nuts counterclockwise one turn while
the wheel is still on the ground. 4. Place the jack underneath the lift area that is closest to
the flat tire. Turn the jack screw clockwise to firmly
engage the jack saddle with the lift area of the sill flange.
NOTE: If the vehicle is too low for jack placement, slide the
jack on its side and rotate it up into position.
Jack Engagement Locations
Front Jacking Location
396 WHAT TO DO IN EMERGENCIES

5. Raise the vehicle just enough to remove the flat tire andinstall the spare tire.
WARNING!
Raising the vehicle higher than necessary can make the
vehicle less stable. It could slip off the jack and hurt
someone near it. Raise the vehicle only enough to
remove the tire.
6. Remove the lug nuts and tire. 7. Mount the spare tire.
CAUTION!
Be sure to mount the spare tire with the valve stem
facing outward. The vehicle could be damaged if the
spare tire is mounted incorrectly.
Rear Jacking Location
Mounting Spare Tire
6
WHAT TO DO IN EMERGENCIES 397

NOTE:•For vehicles so equipped, do not attempt to install a
center cap or wheel cover on the compact spare.
• Refer to “Compact Spare Tire” and to “Limited-Use
Spare” under “Tires—General Information” in “Start-
ing And Operating” for additional warnings, cautions,
and information about the spare tire, its use, and
operation.
8. Install the lug nuts with the cone shaped end of the lug nut toward the wheel. Lightly tighten the lug nuts.
WARNING!
To avoid the risk of forcing the vehicle off the jack, do
not tighten the lug nuts fully until the vehicle has been
lowered. Failure to follow this warning may result in
personal injury.
9. Lower the vehicle to the ground by turning the jack handle counterclockwise.
10. Refer to “Torque Specifications” in this section for proper lug nut torque. 11. Stow the jack, tools and flat tire. Make sure the base of
the jack faces the front of the vehicle before tightening
down the fastener.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the vehicle.
Always stow the jack parts and the spare tire in the
places provided. Have the deflated (flat) tire repaired
or replaced immediately.
Road Tire Installation
1. Mount the road tire on the axle.
2. Install the remaining lug nuts with the cone shaped endof the nut toward the wheel. Lightly tighten the lug
nuts.
WARNING!
To avoid the risk of forcing the vehicle off the jack, do
not tighten the lug nuts fully until the vehicle has been
lowered. Failure to follow this warning may result in
personal injury.
398 WHAT TO DO IN EMERGENCIES

Cargo (Vehicle Loading)..................... .370
Car Washes .............................. .439
Center High Mounted Stop Light ...............459
Certification Label ......................... .370
Chains, Tire ............................. .354
Changing A Flat Tire ....................... .392
Chart, Tire Sizing .......................... .336
Check Engine Light (Malfunction Indicator Light). . . .415
Checking Your Vehicle For Safety ................70
Checks, Safety .............................70
Child Restraint .............................54
Child Restraints Booster Seats ............................57
Child Restraints ..........................54
Child Seat Installation ......................65
How To Stow An Unused ALR Seat Belt .........63
Infants And Child Restraints .................56
Lower Anchors And Tethers For Children ........59
Older Children And Child Restraints ...........56
Seating Positions ..........................58
Clean Air Gasoline ........................ .365
Cleaning Wheels ............................... .440
Climate Control ........................... .268
Cold Weather Operation ..................... .302Compact Spare Tire
........................ .350
Console, Overhead ........................ .149
Contract, Service .......................... .482
Coolant Pressure Cap (Radiator Cap) .............432
Cooling System ........................... .430
Adding Coolant (Antifreeze) .................431
Coolant Capacity .....................460, 461
Coolant Level ....................... .430, 433
Disposal Of Used Coolant ..................433
Drain, Flush, And Refill ....................431
Inspection ............................. .433
Points To Remember ..................... .434
Pressure Cap ........................... .432
Radiator Cap .......................... .432
Selection Of Coolant
(Antifr
eeze)............431, 460, 461, 462, 464, 465
Corrosion Protection ....................... .439
Cruise Control (Speed Control) .................120
Cruise Light ....................194, 195, 197, 198
Cupholders .......................... .163, 444
Customer Assistance ....................... .480
Customer Programmable Features ...........212, 213
Daytime Brightness, Interior Lights ..............111
Daytime Running Lights .....................107
488 INDEX

Remote................................20
Starting And Operating ..................... .299
Starting Procedures ........................ .299
Steering Column Controls ........................ .108
Column Lock ...........................114
Power ............................... .321
Tilt Column .........................114,115
Wheel, Heated ..........................116
Wheel, Tilt ..........................114,115
Steering Wheel Audio Controls .................266
Steering Wheel Mounted Sound System Controls . . . .266
Storage ................................. .455
Storage, Vehicle ....................... .277, 455
Storing Your Vehicle ....................... .455
Stuck, Freeing ............................ .402
Sunglasses Storage ......................... .150
Sun Roof ............................... .157
Supplemental Restraint System - Air Bag ...........44
Synthetic Engine Oil ....................... .422
System, Remote Starting ......................20
Telescoping Steering Column ...............114,115
Temperature Control, Automatic (ATC) ...........276Tilt
Down .................................95
Up....................................95
Tilt Steering Column .....................114,115
Time Delay, Headlight ...................... .107
Tip Start ................................ .300
Tire And Loading Information Placard ........340, 341
Tire Markings ............................ .335
Tires.......................... .74, 345, 349, 356
Aging (Life Of Tires) ..................... .353
Air Pressure ........................ .340, 345
Chains ............................... .354
Changing ...................... .392, 395, 398
Compact Spare ......................... .350
Flat Changing .......................... .398
General Information ...................345, 349
High Speed ............................ .347
Inflation

Pressures ....................... .346
Jacking ........................ .392, 394, 395
Life Of Tires ........................... .353
Load Capacity ...................... .340, 341
Pressure Monitor System (TPMS) .............357
Pressure Warning Light ....................187
Quality Grading ........................ .356
Radial ............................... .34710
INDEX 499