engine coolant DODGE CHALLENGER SRT 2010 3.G User Guide

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol-based engine coolant is a regulated
substance requiring proper disposal. Check with yourlocal authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children,
do not store ethylene glycol-based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child or pet, seek emergency
assistance immediately. Clean up any ground spills
immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
7
MAINTAINING YOUR VEHICLE 357

When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points to Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check the coolant freeze point in the radiator and in
the coolant recovery bottle. If antifreeze needs to be
added, the contents of the coolant recovery bottle must
also be protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine, which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
358 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate) 19 Gallons72 Liters
Engine Oil with Filter
6.1 Liter Engine (SAE 5W-40, API Certified) 7 Quarts6.6 Liters
Cooling System *
6.1 Liter Engine (MOPAR Antifreeze/Coolant 5 Year/100,000 Mile
Formula or equivalent) 15 Quarts
14.4 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
382 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPARAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hy-
brid Organic Additive Technology) or equivalent.
Engine Oil For best performance and maximum protection under all types of operat-
ing conditions, the manufacturer only recommends full synthetic engine
oils that meet the requirements of Chrysler Material Standard MS-10725
and are approved to MB 229.3 or MB 229.5. The manufacturer recom-
mends the use of a full synthetic 5W-40 or equivalent engine oil.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs PLZTR5A-13 (Gap 0.040 in [1.01 mm])
Fuel Selection Premium Unleaded 91 Octane Only or higher.
7
MAINTAINING YOUR VEHICLE 383

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering, and add as
needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S388 MAINTENANCE SCHEDULES

54,000 Miles (90,000 km) or
54 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Inspect the rear axle fluid.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
60,000 Miles (100,000 km) or 60 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, and replace if necessary.
❏ Adjust parking brake on vehicles equipped with four-wheel disc brakes.
❏ Inspect the manual transmission fluid (if equipped), add as necessary.
❏ Change the automatic transmission fluid and filter if using your vehicle for any of the
following: police, taxi, fleet, or frequent trailer towing.
❏ Flush and replace the engine coolant at 60 months if not done at 102,000 miles
(170 000 km).
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S394 MAINTENANCE SCHEDULES

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the spark plugs.
❏ Flush and replace the engine coolant if
not done at 60 months.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If you are using your vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, and replace if necessary.
❏ Inspect the rear axle fluid.
❏ Inspect the manual transmission fluid (if equipped), add as necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S398 MAINTENANCE SCHEDULES

About Your Brakes.................... 264,267
ABS (Anti-Lock Brake System) ............267,271
Adding Engine Coolant (Antifreeze) .......... 356
Adding Fuel ........................... 308
Adding Washer Fluid ..................... 350
Additives, Fuel ......................... 306
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 345
Air Conditioner Maintenance ............... 348
Air Conditioning ........................ 224
Air Conditioning Controls ................. 224
Air Conditioning, Operating Tips ............ 231
Air Conditioning Refrigerant .............348,349
Air Conditioning System ................224,348
Air Pressure, Tires ....................... 290
Airbag .............................. 45,53
Airbag Deployment ....................... 55
Airbag Light ................... 46,52,57,71,161
Airbag Maintenance ....................... 56
Airbag, Side .......................... 51,53Airbag, Window (Side Curtain)
...........47,51,53
Alarm Light ........................... 165
Alarm, Panic ............................ 24
Alarm (Security Alarm) .................... 17
Alarm System (Security Alarm) ............... 17
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 217
Antifreeze (Engine Coolant) ...........355,356,382
Disposal ............................ 357
Anti-Lock Brake System (ABS) ............267,271
Anti-Lock Warning Light ...............167,270
Anti-Theft Security Alarm (Theft Alarm) ........ 17
Appearance Care ........................ 364
Arming Theft System (Security Alarm) ......... 17
Assistance Towing ........................ 96
Auto Down Power Windows ................ 33
Auto Unlock, Doors ....................... 30
Automatic Dimming Mirror ................. 77
Automatic Door Locks ..................... 30
416 INDEX

Bulbs, Light.......................... 72,376
Calibration, Compass ..................... 180
Capacities, Fluid ........................ 382
Caps, Filler Fuel ............................... 308
Oil (Engine) .......................... 344
Power Steering ........................ 263
Radiator (Coolant Pressure) ............... 356
Car Washes ............................ 364
Carbon Monoxide Warning ...............70,307
Cargo (Vehicle Loading) ................... 310
Cellular Phone .......................... 81
Center High Mounted Stop Light ............ 381
Certification Label ....................... 310
Chains, Tire ............................ 295
Chart, Tire Sizing ........................ 281
Check Engine Light
(Malfunction Indicator Light) ............... 340Checking Your Vehicle For Safety
............. 69
Checks, Safety ........................... 69
Child Restraint .................... 59,61,64,66
Child Restraint Tether Anchors .............63,64
Clean Air Gasoline ....................... 304
Cleaning Wheels ............................. 366
Windshield Wiper Blades ................ 349
Clock ........................ 186,188,191,200
Cold Weather Operation ................... 242
Compact Disc (CD) Maintenance ............. 223
Compass .............................. 180
Compass Calibration ..................... 180
Compass Variance ....................... 181
Computer, Trip/Travel .................... 173
Connector UCI ................................ 211
Universal Consumer Interface (UCI) ......... 211
Console .............................. 150
418 INDEX

Console, Floor.......................... 150
Console, Overhead ....................... 136
Contract, Service ........................ 409
Coolant Pressure Cap (Radiator Cap) .......... 356
Cooling System ......................... 354
Adding Coolant (Antifreeze) .............. 356
Coolant Capacity ...................... 382
Coolant Level ...................... 354,357
Disposal of Used Coolant ................ 357
Drain, Flush, and Refill .................. 355
Inspection ........................... 357
Points to Remember .................... 358
Pressure Cap ......................... 356
Radiator Cap ......................... 356
Selection of Coolant (Antifreeze) ......355,382,383
Corrosion Protection ..................... 364
Cruise Control (Speed Control) .............. 133
Cruise Light ........................... 158
Cupholders ......................... 149,368Customer Assistance
..................... 407
Daytime Brightness, Interior Lights ........... 129
Daytime Running Lights ................... 125
Dealer Service .......................... 342
Deck Lid, Emergency Release ................ 35
Deck Lid, Power Release ................... 33
Defroster, Rear Window ................... 152
Defroster, Windshield ................... 71,226
Delay (Intermittent) Wipers ................. 130
Diagnostic System, Onboard ................ 339
Dimmer Switch, Headlight ................. 127
Dipsticks Oil (Engine) .......................... 343
Power Steering ........................ 263
Disabled Vehicle Towing ................... 332
Disposal Antifreeze (Engine Coolant) ............... 357
Engine Oil ........................... 344
10
INDEX 419