radiator cap DODGE CHALLENGER SRT 2016 3.G Owners Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 2016, Model line: CHALLENGER SRT, Model: DODGE CHALLENGER SRT 2016 3.GPages: 616, PDF Size: 4.45 MB
Page 481 of 616
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads 240°F
(116°C) or greater pull over and stop the vehicle. Idle
the vehicle with the air conditioner turned off until
the pointer drops back into the normal range 200–
230°F (93–110°C). If the pointer remains at 240°F
(116°C) or greater and you hear a chime, turn the
engine off immediately and call for service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
WHEEL AND TIRE TORQUE SPECIFICATIONS
Proper lug nut/bolt torque is very important to ensure
that the wheel is properly mounted to the vehicle. Any
time a wheel has been removed and reinstalled on the
vehicle the lug nuts/bolts should be torqued using a
properly calibrated torque wrench.
6
WHAT TO DO IN EMERGENCIES 479
Page 531 of 616
NOTE:Your vehicles exhaust system may be equipped
with an Electronic Exhaust Valve (EEV) system, if the
exhaust system is replaced with aftermarket products a
Malfunction Indicator Lamp (MIL) will illuminate.
Cooling System
WARNING!
• When working near the radiator cooling fan, dis-
connect the fan motor lead or place the ignition in
the LOCK position (OFF position for Keyless
Enter-N-Go). The fan is temperature controlled and
can start at any time the ignition switch is in the
ON position (RUN position for Keyless Enter-N-
Go).
• You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
(Continued)
WARNING! (Continued)
do not open the hood until the radiator has had
time to cool. Never try to open a cooling system
pressure cap when the radiator is hot.
Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If the engine coolant (antifreeze) is dirty, the
system should be drained, flushed, and refilled with
fresh OAT coolant (conforming to MS.90032) by an
authorized dealer. Check the front of the A/C condenser
for any accumulation of bugs, leaves, etc. If dirty, clean by
gently spraying water from a garden hose vertically
down the face of the condenser.
Check the coolant recovery bottle and/or the super-
charger coolant recovery bottle (if equipped with the 6.2L
Supercharged engine) tubing for brittle rubber, cracking,
7
MAINTAINING YOUR VEHICLE 529
Page 532 of 616
tears, cuts, and tightness of the connection at the bottle
and radiator. Inspect the entire system for leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the engine coolant (antifreeze) will begin to
drain from the coolant recovery bottle. DO NOT RE-
MOVE THE COOLANT PRESSURE CAP WHEN THE
COOLING SYSTEM IS HOT.
Cooling System — Drain, Flush And Refill
NOTE:Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could lead
to severe internal engine damage. If any coolant is
needed to be added to the system please contact your
local authorized dealer. If the engine coolant (antifreeze) is dirty or contains
visible sediment, have an authorized dealer clean and
flush with OAT coolant (antifreeze) (conforming to
MS.90032).
NOTE:
If equipped with the 6.2L Supercharged engine
the intercooler must be vacuum flushed and filled. If any
coolant is needed to be added to the system please
contact your local authorized dealer.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Selection Of Coolant
Refer to “Fluids, Lubricants, And Genuine Parts” in
“Maintaining Your Vehicle” for further information.
530 MAINTAINING YOUR VEHICLE
Page 535 of 616
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as
possible.
Cooling System Pressure Caps
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
NOTE:Be sure you do not mix the engine coolant system
pressure cap with the intercooler system pressure cap
these caps are not interchangeable.
WARNING!
• Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
7
MAINTAINING YOUR VEHICLE 533
Page 536 of 616
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
534 MAINTAINING YOUR VEHICLE
Page 596 of 616
Brake Fluid......................... .567, 569
Brake, Parking .......................... .418
Brakes ................................ .421
Brake System ........................ .421, 535
Fluid Check ....................536, 567, 569
Master Cylinder ....................... .536
Parking ............................. .418
Warning Light ..................... .233, 421
Brake/Transmission Interlock .................389
Braking ............................... .266
SRT ................................ .266
Braking Distance ......................... .266
SRT ................................ .266
Brightness, Interior Lights ...................145
Bulb Replacement ..................... .560, 562
Bulbs, Light .......................... .98, 560
Camera, Rear ........................... .195
Capacities, Fluid ...................... .565, 566Caps, Filler
Fuel ................................ .470
Oil (Engine) .......................... .516
Radiator (Coolant Pressure) ................533
Carbon Monoxide Warning ................95, 469
Cargo (Vehicle Loading) ....................472
Car Washes ............................ .541
Center High Mounted Stop Light ..............564
Certification Label ........................ .472
Chains, Tire ............................ .456
Chart, Tire Sizing ........................ .437
Check Engine Light (Malfunction Indicator Light) . .512
Checking Your Vehicle For Safety ...............94
Checks, Safety ............................94
Child Restraint ............................71
Child Restraints Booster Seats ...........................76
Center Seat LATCH ......................84
Child Restraints .........................71
594 INDEX
Page 597 of 616
Child Seat Installation.....................89
How To Stow An Unused ALR Seat Belt ........85
Infants And Child Restraints ................74
Install A LATCH-Compatible Child Restraint ....84
Installing Child Restraints Using The Vehicle Seat
Belt ..................................86
Lower Anchors And Tethers For Children .......78
Older Children And Child Restraints ..........74
Seating Positions ........................77
Using The Top Tether Anchorage .............90
Clean Air Gasoline ....................... .465
Cleaning Wheels .............................. .543
Climate Control ......................... .338
Automatic ........................... .338
Cold Weather Operation ....................381
Console, Overhead ....................... .198
Console Shifter .......................... .397
SRT ................................ .397Contract, Service
......................... .583
Coolant Pressure Cap (Radiator Cap) ...........533
Cooling System .......................... .529
Adding Coolant (Antifreeze) ...............531
Coolant Capacity ....................565, 566
Coolant Level ..................... .529, 534
Disposal Of Used Coolant .................533
Drain, Flush, And Refill ...................530
Inspection ........................... .534
Points To Remember .....................534
Pressure Cap ......................... .533
Radiator Cap ......................... .533
Selection Of Coolant
(Antifreeze) ..............530, 565, 566, 567, 568
Corrosion Protection ...................... .540
Cruise Control (Speed Control) ................158
Cruise Light ......................... .255, 256
Cupholders ......................... .214, 547
Customer Assistance ...................... .581
10
INDEX 595
Page 607 of 616
Personalized Menu Bar.....................350
Pets ....................................92
Placard, Tire And Loading Information ..........443
Power Brakes .............................. .421
Deck Lid Release ........................41
Distribution Center (Fuses) ................553
Door Locks ............................32
Mirrors ..............................113
Outlet (Auxiliary Electrical Outlet) ...........211
Seats ............................... .126
Sunroof ............................. .208
Tilt/Telescoping Steering Column ............152
Windows ..............................39
Power Seats Down .............................. .127
Forward ............................. .126
Power Lumbar ........................ .127
Rearward ............................ .126Tilt ................................
.127
Up ................................ .127
Power Steering Fluid ...................567, 569
Pregnant Women And Seat Belts ...............53
Pretensioners Seat Belts ..............................53
Programmable Features .....................278
Radial Ply Tires ......................... .450
Radiator Cap (Coolant Pressure Cap) ...........533
Radio Frequency General Information ............16, 18, 26, 30, 38
Radio Operation ......................... .336
Radio Remote Controls .....................334
Radio (Sound Systems) .....................333
Rain Sensitive Wiper System .................149
Rear Camera ........................... .195
Rear Cupholder ......................... .216
Rear ParkSense System .....................185
10
INDEX 605