engine overheat DODGE CHARGER 2006 6.G User Guide

WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may indicate severe
and abnormal catalyst overheating. If this occurs, the
vehicle should be stopped, the engine shut off and the
vehicle allowed to cool. Thereafter, service, including a
tune-up to manufacturer’s specifications, should be ob-
tained immediately.To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idling or malfunctioning operating conditions.
Maintenance-Free Battery
The top of the MAINTENANCE-FREE battery is perma-
nently sealed. You will never have to add water, nor is
periodic maintenance required.
NOTE:The battery is stored under an access cover in
the trunk. Remote battery terminals are located in the
engine compartment for jump starting.
292 MAINTAINING YOUR VEHICLE

Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words“DO NOT OPEN HOT”on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the level of the coolant in the bottle
should be between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
MAINTAINING YOUR VEHICLE 301
7

Hazard Warning Flasher................ 262
Jacking............................. 263
Jump Starting........................ 270
Overheating......................... 262
Towing............................. 274
Emission Control System Maintenance....283,328
Engine.........................279,280,281
Air Cleaner.......................... 291
Air Cleaner Filter..................... 290
Block Heater......................... 198
Break-In Recommendations............... 59
Checking Oil Level.................285,286
Compartment..................279,280,281
Coolant (Antifreeze)................299,324
Cooling............................ 298
Exhaust Gas Caution................59,244
Fails to Start......................... 197
Fuel Requirements.................241,323
Oil ..........................285,323,324
Oil Change Interval................... 287
Oil Selection......................287,323
Oil Synthetic......................... 289
Overheating......................... 262Temperature Gauge................... 135
Enhanced Accident Response Feature......... 49
Event Data Recorder..................... 50
Exhaust Gas Caution...............59,244,298
Exhaust System........................ 297
Exterior Folding Mirrors.................. 68
Filters
Air Cleaner.......................... 290
Air Conditioning..................190,295
Engine Fuel......................... 291
Engine Oil.......................290,324
Engine Oil Disposal................... 289
Flashers
Hazard Warning...................... 262
Turn Signal.......................... 136
Flash-To-Pass.......................... 103
Flat Tire Changing...................... 263
Floor Console.......................... 127
Fluid Capacities........................ 323
Fluid Leaks............................ 61
Fluid Level Checks
Brake.............................. 304
INDEX 355
10

Maintenance Schedule................... 328
Schedule“A”........................ 339
Schedule“B”........................ 331
Malfunction Indicator Light (Check Engine) . 141,283
Manual, Service........................ 347
Mini-Trip Computer..................... 144
Mirrors............................... 67
Automatic Dimming.................... 67
Electric Remote....................... 69
Exterior Folding....................... 68
Heated.............................. 69
Outside............................. 68
Rearview............................ 67
Vanity.............................. 69
Modifications/Alterations, Vehicle............ 7
Monitor, Tire Pressure System............. 234
Mopar Parts........................284,346
Multi-Displacement Engine System.......... 218
Multi-Function Control Lever.............. 100
Navigation System...................... 177
New Vehicle Break-In Period............... 59Occupant Restraints...................... 31
Octane Rating, Gasoline (Fuel)............. 241
Oil, Engine.........................285,324
Capacity............................ 323
Change Interval...................... 287
Checking........................285,286
Disposal............................ 289
Filter...........................290,324
Filter Disposal....................... 289
Identification Logo.................... 288
Materials Added to.................... 289
Recommendation..................287,323
Synthetic........................... 289
Viscosity.........................288,323
Onboard Diagnostic System............282,283
Opener, Garage Door (HomeLink) ......... 115
Operator Manual (Owner’s Manual).......... 4
Overhead Console...................... 114
Overheating, Engine..................136,262
Owner’s Manual (Operator Manual).......4,347
Panic Alarm........................... 23
Parking Brake......................... 212
INDEX 359
10