maintenance schedule DODGE DAKOTA 2005 3.G User Guide

MAINTENANCE SCHEDULES
CONTENTS

Emission Control System Maintenance........348

Emissions Testing.......................348

Maintenance Schedules...................349▫Schedule “B”........................352
▫Schedule “A”........................362
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
typeon the following pages must be done at the times or
mileages specified to assure the continued proper func-
tioning of the emission control system. These, and all
other maintenance services included in this manual,
should be done to provide best vehicle performance and
reliability. More frequent maintenance may be needed for
vehicles in severe operating conditions such as dusty
areas and very short trip driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
EMISSIONS TESTING
In some localities, it may be or will become a legal
requirement to ensure that all emissions components and
systems are functioning properly as a part of the test
procedure. The test center accomplishes this by checking
the On Board Diagnostic System (OBD) system with an
electronic scan tool. If your vehicle has recently been
serviced, the OBD system may have been reset to anot
readycondition because the OBD system has not had
sufficient time since the servicing to reconfirm that
emissions components are operating properly. In most
cases, a reasonable mix and amount of normal city and
highway driving and at least one overnight-off period
will be required to prepare your vehicle for this check;
however your dealer has the equipment and procedures
required to make certain that the OBD system of your
vehicle is ready for the required testing.
348 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:IfANYof these apply to you then change your
coolant every 102,000 miles (163 000 km) or 60 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:Most vehicles are operated under the conditions
listed for ScheduleB.
Second is Schedule“A”. It is for vehicles that are not
operated under any of the conditions listed under Sched-
uleB.
MAINTENANCE SCHEDULES 349
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
350 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level (if
equipped).
•Check the manual transission fluid level (if equipped).
•Check the coolant level, hoses, and clamps.
MAINTENANCE SCHEDULES 351
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:IfANYof these apply to you then change your
coolant every 102,000 miles (163 000 km) or 60 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
352 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Drain and refill automatic transmission fluid
and change main sump filter and spin-on
cooler return filter if equipped. (4.7L).X
Flush and replace engine coolant, if not re-
placed at 102,000 miles (163 000 km).X
This applies only if your vehicle is used for police, taxi,
fleet, or frequent trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.** This maintenance is recommended by the manufac-
turer to the owner, but not required to maintain the
emissions warranty.
SCHEDULE “B” 361
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102,000 108,000 114,000 120,000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X
Rotate tires. X X X X
Drain and refill tranfer case fluid (4X4). X
Flush and replace engine coolant, if not done at 60
months.X
Flush and replace engine coolant, if not done at 102,000
miles (163 000 km)X
Inspect brake linings. X
Inspect engine air cleaner filter, replace as necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary.**X
** This maintenance is recommended by the manufac-
turer to the owner, but not required to maintain the
emissions warranty.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “A” 365
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Low Fuel.........................152,153
Malfunction Indicator................... 157
Passing............................. 119
Seat Belt Reminder..................... 153
Service.............................. 330
Turn Signal........................ 118,336
Warning (Instrument Cluster Description)..... 152
Washer Fluid......................... 157
Limited-Slip Differential................... 218
Loading Vehicle......................... 252
Tires ............................... 229
Locks................................. 16
Auto Unlock.......................... 18
Automatic Door........................ 18
Child Protection........................ 20
Door................................ 16
Ignition.............................. 13
Keys................................ 10
Power Door........................... 17Steering Wheel......................... 13
Lower Anchors and Tether for CHildren (LATCH) . 62
Lubricating Oil......................... 324
Lubrication, Body....................... 309
Lug Nuts............................. 282
Lumbar Support........................ 109
Maintenance Free Battery.................. 306
Maintenance Procedures................... 298
Maintenance Schedule.................... 349
ScheduleA......................... 362
ScheduleB.......................... 352
Malfunction Indicator Light..............157,295
Manual, Service......................... 373
Manual Transmission...............196,204,320
Fluid Level Check...................... 320
Lubricant Selection..................320,345
Map/Reading Lights..................... 127
Mirrors................................ 81
384 INDEX

Reception, Radio........................ 159
Reclining Front Seats..................... 108
Recommended Fluids, Lubricants and Genuine
Parts............................... 344
Recorder, Event Data...................... 57
Recreational Towing...................... 264
Shifting into Transfer Case Neutral (N)....... 265
Shifting out of Transfer Case Neutral (N)..... 267
Reformulated Gasoline.................... 246
Refrigerant............................ 308
Release, Hood.......................... 112
Reminder, Seat Belt....................... 39
Remote Keyless Entry..................... 21
Remote Sound System Controls.............. 182
Replacement Keys........................ 12
Replacement Parts....................... 297
Replacement Tires....................... 240
Reporting Safety Defects................... 372
Restraints, Child.......................59,64Restraints, Occupant...................... 31
Rocking Vehicle When Stuck................ 224
Rotation, Tires.......................... 244
Safety Checks Inside Vehicle................. 74
Safety Checks Outside Vehicle............... 74
Safety Defects, Reporting.................. 372
Safety Information, Tire................... 224
Safety Tips............................. 73
Satellite Radio.......................... 178
Satellite Radio Antenna................... 181
Schedule, Maintenance.................... 349
Seat Belt Maintenance.................... 328
Seat Belt Reminder....................... 39
Seat Belts............................31,32
And Pregnant Women................... 40
Child Restraint.......................59,61
Extender............................. 40
Front Seat............................ 32
INDEX 387
10