coolant level DODGE DAKOTA 2005 3.G Owners Manual

INSTRUMENT CLUSTER DESCRIPTION
1. Fuel Gage
The fuel gauge shows level of fuel in tank when
ignition switch is in the ON position. (See page 245
for more information.)
2. Temperature Gage
The temperature gage indicates engine coolant
temperature. Any reading within the normal
range indicates that the cooling system is operat-
ing satisfactorily. The gage needle in V6 and V8 engines
will likely indicate a high temperature when driving in
hot weather, up mountain grades, in heavy traffic, or
when towing a trailer. If the needle rises to the “H” mark,
stop the vehicle, shift into N (Neutral) increase engine
speed for 2-3 minutes. If the temperature reading does
not return to normal, seek authorized service immedi-
ately.
CAUTION!
Do not leave your vehicle unattended with the
engine running as you would not be able to react to
the temperature indicator if the engine overheats.
The gage pointer will remain near its last reading when
the engine is turned off. It will return to a true reading
when the engine is restarted.
3. Turn Signal Indicators
When a turn signal is activated, a right-pointing or
left-pointing arrow lights up and flashes to indicate the
direction of the turn. These indicators also indicate
proper operation of the front and rear turn signal lights.
If either indicator flashes at a faster rate than normal,
check for a defective bulb. If either indicator fails to light
up when the lever is moved, check for a defective fuse or
turn signal LED. A single chime is activated when the
152 INSTRUMENT PANEL AND CONTROLS

CAUTION!
Mixing of coolants other than specified (non-
HOAT), may result in engine damage and decreased
corrosion protection. If a non-HOAT coolant is intro-
duced into the cooling system in an emergency, it
should be replaced with the specified coolant as
soon as possible.
Do not use plain water alone or alcohol base anti-
freeze products. Do not use additional rust inhibi-
tors or antirust products, as they may not be compat-
ible with the radiator coolant and may plug the
radiator.
This vehicle has not been designed for use with
Propylene Glycol based coolants. Use of Propylene
Glycol based coolants is not recommended.
Adding Coolant
When adding coolant, or refilling the system, a minimum
solution of 50% recommended HOAT ethylene glycol
engine coolant (antifreeze) and distilled water should be
used. Use higher concentrations (not to exceed 70%) if
temperatures below
34°F (
37°C) are anticipated.
Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant solution.
The use of lower quality water will reduce the amount of
corrosion protection in the engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
314 MAINTAINING YOUR VEHICLE

WARNING!
Never add coolant to the radiator when the engine is
overheated. Do not loosen or remove pressure cap to
cool overheated engine. The coolant is under pres-
sure and severe scalding could result.
Coolant Pressure Cap
The coolant pressure cap must be fully tightened to
prevent loss of coolant, and to insure that coolant will
return to the radiator from the coolant bottle.
The pressure cap should be inspected and cleaned if there
is any accumulation of foreign material on the sealing
surfaces.
WARNING!
The warning words “DO NOT OPEN HOT” on the
coolant pressure cap are a safety precaution. Heat
causes pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the pres-
sure cap when the system is hot or under pressure.
Coolant Level
The coolant bottle system provides a quick visual method
for determining that the coolant level is adequate. With
the engine idling, and warmed to normal operating
temperature,the level of the coolant on the overflow
bottle should be between the fluid level marks.Check
the coolant level whenever the hood is raised.
The radiator normally remains completely full, so there is
no need to remove the pressure cap except checking
coolant freeze point or replacement with new antifreeze
MAINTAINING YOUR VEHICLE 315
7

coolant. Your service attendant should be advised of this.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
A. Do not overfill the coolant bottle.
B. Check coolant freeze point in the radiator and in the
coolant bottle. If antifreeze needs to be added, contents of
coolant bottle also must be protected against freezing.
C. If frequent coolant additions are required, or if the
level in the coolant bottle does not drop when the engine
cools, the cooling system should be pressure tested for
leaks.
D. Maintain a minimum coolant concentration of 50%
ethylene glycol and distilled water.E. Make sure that the radiator and coolant bottle over-
flow hoses are not kinked or obstructed.
F. Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean also.
G. The thermostat should not be changed for summer or
winter operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance.
Emission Related Components
Fuel System Hoses And Vapor/Vacuum Harnesses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, checking, tears, cuts, abrasions, and excessive
swelling suggest deterioration of the rubber. Particular
316 MAINTAINING YOUR VEHICLE

Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
NOTE:Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
350 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level (if
equipped).
•Check the manual transission fluid level (if equipped).
•Check the coolant level, hoses, and clamps.
MAINTENANCE SCHEDULES 351
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 36,000 42,000 48,000 54000 60,000 66,000
(Kilometers) (58 000) (67 000) (77 000) (84 000) (96 000) (106 000)
[Months] [36] [42] [48] [54] [60] [66]
Change engine oil and engine oil filter. X X X X X X
Rotate tires. X X X X X X
Check transfer case fluid level (4X4). X
Flush and replace engine coolant at 60
months, if not replaced at 102,000 miles (163
000 km).X
Inspect brake linings. X X
Inspect engine air cleaner filter, replace if
necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary.**X
Inspect auto tension drive belt and replace if
required.X
SCHEDULE “A” 363
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................247,273
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 303
Air Conditioner Maintenance............... 307
Air Conditioning........................ 185
Air Conditioning, Operating Tips..........185,188
Air Conditioning Refrigerant.............307,308
Air Conditioning System................185,307
Air Filter.............................. 303
Air Pressure, Tires....................234,241
Airbag...........................41,55,158
Airbag Light............................ 54
Airbag On/Off Switch..................... 55
Alarm..............................27,154
Alarm, Panic............................ 24
Alignment and Balance................... 241
Alterations/Modifications, Vehicle............. 6
Antenna, Satellite Radio................... 181
Antifreeze (Engine Coolant)...........313,314,343
Anti-Lock Brake System (ABS)............221,222Anti-Lock Warning Light.................. 155
Anti-Theft System.....................27,154
Appearance Care........................ 325
Arming Theft System...................... 27
Auto Unlock, Doors....................... 18
Automatic Dimming Mirror................. 82
Automatic Door Locks..................... 18
Automatic Transaxle...................... 199
Automatic Transmission.............196,199,320
Adding Fluid......................... 321
Fluid and Filter Changes................. 322
Fluid Level Check...................... 320
Fluid Type........................322,345
Gear Ranges.......................... 199
Special Additives...................... 322
Torque Converter...................... 203
Axle Fluid............................. 345
Axle Lubrication........................ 323
376 INDEX

Center High Mounted Stop Light............ 338
Center Seat Storage Compartment............ 142
Certification Label....................... 252
Changing A Flat Tire..................... 274
Charging.............................. 283
Chart, Tire Sizing........................ 226
Child Restraint........................59,61
Child Restraint Tether Anchors.............62,67
Child Restraint with Automatic Belts........... 38
Child Seat.............................. 64
Circuit Breakers......................... 328
Climate Control......................... 184
Clock................................ 160
Compact Disc Maintenance................. 183
Compact Spare Tire...................... 237
Compass.............................. 131
Compass Calibration..................... 131
Compass Variance....................... 132
Computer, Trip/Travel.................... 127Console, Floor.......................... 141
Console, Overhead....................... 126
Contract, Service........................ 370
Converter, Catalytic...................... 251
Coolant............................... 315
Coolant Pressure Cap..................... 315
Cooling System......................... 312
Adding Coolant (Antifreeze).............. 314
Coolant Capacity...................... 343
Coolant Level......................... 315
Disposal of Used Coolant................ 313
Drain, Flush, and Refill.................. 313
Inspection........................... 312
Points to Remember.................... 316
Radiator Cap......................... 315
Selection of Coolant...............313,343,344
Temperature Gauge..................... 152
Cruise Control (Speed Control).............. 123
Cup Holder............................ 143
378 INDEX

Fluid Capacities......................... 343
Fluid Level Checks
Automatic Transmission................. 320
Brake............................... 318
Cooling System....................... 312
Engine Oil........................... 298
Power Steering........................ 308
Transfer Case......................... 323
Fog Lights.......................... 117,342
Four Wheel Drive....................... 206
Operation........................... 206
Four-Way Hazard Flasher.................. 272
Freeing A Stuck Vehicle................... 224
Front Axle............................. 324
Fuel................................. 245
Adding............................. 247
Filter............................... 304
Gauge.............................. 152
Octane Rating......................245,344Requirements......................245,343
Tank Capacity........................ 343
Fueling............................... 247
Fuses................................ 328
Garage Door Opener..................... 133
GasCap ...........................248,295
Gas Gauge (Fuel Gauge)................... 152
Gasoline.............................. 245
Gasoline, Reformulated................... 246
Gauges
Coolant Temperature.................... 152
Fuel................................ 152
Odometer.........................155,156
Speedometer......................... 154
Tachometer.......................... 155
Gear Ranges........................... 199
Glass Cleaning.......................... 328
Grease............................... 324
INDEX 381
10