wheel DODGE DAKOTA 2007 3.G Repair Manual

WARNING!
Stand clear of vehicles when pulling with tow
hooks. Tow straps and chains may break, causing
serious injury.
CAUTION!
Tow hooks are for emergency use only, to rescue a
vehicle stranded off road. Do not use tow hooks for
tow truck hookup or highway towing. You could
damage your vehicle.
TOWING A DISABLED VEHICLE
Proper towing or lifting equipment is required to prevent
damage to your vehicle. Use of safety chains is recom-
mended.Attach towing device to main structural mem-
bers of the vehicle — not to bumpers or associated
brackets. State and local laws applying to vehicles
under tow must be observed.
Four-Wheel Drive Vehicles
The manufacturer recommends towing with all wheels
OFFthe ground. Acceptable methods are to tow the
vehicle on a flatbed or with one end of the vehicle raised
and the opposite end on a towing dolly.
286 WHAT TO DO IN EMERGENCIES

Two-Wheel Drive Vehicles
Provided that the transmission is operable, tow with the
transmission in Neutral and the ignition key in the OFF
position along with the front wheels raised and the rear
wheels on the ground. The speed must not exceed 30
mph (50 km/h) and the distance must not exceed 15
miles (25 km).If the vehicle is to be towed more than 15 miles (25 km )
or faster than 30 mph, it must be towed on a flatbed, or
with the rear wheels raised and the front wheels on the
ground, or with the front end raised and the rear wheels
on a towing dolly.
NOTE:Towing the vehicle, with the rear wheels on the
ground, at more than 30 mph (50 km/h) or for more than
15 miles (25 km ) can cause severe transmission damage.
WHAT TO DO IN EMERGENCIES 287
6

Drive Shaft Constant Velocity Joints
All four wheel drive models are equipped with four
constant velocity joints. Periodic lubrication of these
joints is not required. However, the joint boot should be
inspected for external leakage or damage periodically. If
external leakage or damage is evident, the joint boot and
grease should be replaced immediately. Continued op-
eration could result in failure of the joint due to water
and dirt contamination of the grease. This would require
complete replacement of the joint assembly. Refer to the
Service Manual for the detailed replacement procedure.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors and hood hinges, should be lubricated
periodically to assure quiet, easy operation and to protect
against rust and wear. Prior to the application of any
lubricant, the parts concerned should be wiped clean to
remove dust and grit; after lubricating excess oil and
grease should be removed. Particular attention shouldalso be given to hood latching components to insure
proper function. When performing other underhood ser-
vices, the hood latch, release mechanism and safety catch
should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MoparLock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
The rubber edges of the wiper blades and the windshield
should be cleaned periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove accu-
mulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield.
MAINTAINING YOUR VEHICLE 307
7

differential. Rear axle fluid level should be 1/4(6.4mm)
below filler plug for 8 1/4”, and 9 1/4axles.
Front Axle
Front Axle fluid level should be at the bottom of the fill
plug.
Selection of Lubricating Grease
The National Lubricating Grease Institute (NLGI) has
developed a symbol (Certification Mark) to aid the
vehicle owner in the proper selection of grease for chassis
components. This symbol, an example shown below, is
located on the grease container and identifies the appli-
cation and quality of the grease.There are two groups
identified, those for wheel
bearings (Letter “G”) and
those for chassis (Letter
“L”) lubrication. Perfor-
mance categories within
these groups result in dual
letter designations for
each group. The letter des-
ignations shown in the ex-
ample are the highest
quality level available and when combined as shown can
be used for chassis lubrication. Use only those greases
that have the NLGI symbol on the container along with
the proper quality level for your application.
322 MAINTAINING YOUR VEHICLE

•Avoid using abrasive compounds and power buffing
that may diminish the gloss or thin out the paint
finish.
CAUTION!
Do not use abrasive or strong cleaning materials
such as steel wool or scouring powder, which will
scratch metal and painted surfaces.
Special Care
•
If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least once
a month.
•It is important that the drain holes in the lower edges
of the doors, rocker panels be kept clear and open.
•If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
•If your vehicle is damaged due to an accident or
similar cause which destroys the paint and protective
coating have your vehicle repaired as soon as possible.
The cost of such repairs is considered the responsibil-
ity of the owner.
•If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
•If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
•Use Mopartouch up paint on scratches as soon as
possible. Your dealer has touch up paint to match the
color of your vehicle.
324 MAINTAINING YOUR VEHICLE

Wheel and Wheel Trim Care
All wheels and wheel trim, especially aluminum and
chrome plated wheels should be cleaned regularly with a
mild soap and water to prevent corrosion. To remove
heavy soil, use Mopar Wheel Cleaner or select a nonabra-
sive, non-acidic cleaner. Do not use scouring pads, steel
wool, a bristle brush or metal polishes. Only Mopar
cleaners are recommended. Do not use oven cleaner.
Avoid automatic car washes that use acidic solutions or
harsh brushes that may damage the wheels’ protective
finish.
YES EssentialsFabric Cleaning Procedure – If
Equipped
YES Essentialsseats may be cleaned in the following
manner:
•Remove as much of the stain as possible by blotting
with a clean, dry towel.
•Blot any remaining stain with a clean, damp towel.
•For tough stains, apply Mopar Total Clean or a mild
soap solution to a clean, damp cloth and remove stain.
Use a fresh, damp towel to remove soap residue.
•For grease stains, apply Mopar Multi-purpose cleaner
to a clean, damp cloth and remove stain. Use a fresh,
damp towel to remove soap residue.
•Do not use any solvents or protectants on Yes Essen-
tials products.
Interior Care
Use MoparFabric Cleaner to clean fabric upholstery
and carpeting.
Use MoparVinyl Cleaner to clean vinyl upholstery and
trim.
MoparTotal Clean is specifically recommended for
leather upholstery.
MAINTAINING YOUR VEHICLE 325
7

on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. Thegrade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
376 IF YOU NEED CONSUMER ASSISTANCE

Catalytic Converter...................... 302
CD (Compact Disc) Player...............146,154
Cellular Phone.......................... 175
Center High Mounted Stop Light............ 341
Center Seat Storage Compartment............ 122
Certification Label....................... 247
Changing A Flat Tire..................... 273
Charging.............................. 283
Chart, Tire Sizing........................ 219
Child Restraint........................ 58,59
Child Restraint Tether Anchors............. 61,66
Child Restraint with Automatic Belts........... 40
Child Seat.............................. 63
Circuit Breakers......................... 327
Cleaning
Wheels............................. 325
Climate Control......................... 175
Clock ...........................143,148,156
Compact Disc (CD) Maintenance............. 173Compact Spare Tire...................... 230
Compass.............................. 107
Compass Calibration..................... 107
Compass Variance....................... 108
Computer, Trip/Travel.................... 104
Console, Floor.......................... 121
Console, Overhead....................... 103
Contract, Service........................ 372
Coolant Pressure Cap (Radiator Cap).......... 312
Cooling System......................... 310
Adding Coolant (Antifreeze).............. 312
Coolant Capacity...................... 345
Coolant Level......................310,313
Disposal of Used Coolant................ 313
Drain, Flush, and Refill.................. 311
Inspection........................... 313
Points to Remember.................... 314
Pressure Cap......................... 312
Radiator Cap......................... 312
380 INDEX

Maintenance.......................... 247
Replacement Parts..................... 247
Starting............................. 246
Flooded Engine Starting................... 188
Floor Console.......................... 121
Fluid, Brake........................... 347
Fluid Capacities......................... 345
Fluid Level Checks
Automatic Transmission................. 318
Brake............................... 316
Engine Oil........................... 297
Power Steering........................ 306
Transfer Case......................... 321
Fluids, Lubricants and Genuine Parts.......... 346
Fog Lights........................... 93,345
Four Wheel Drive....................... 199
Operation........................... 199
Four-Way Hazard Flasher.................. 272
Freeing A Stuck Vehicle................... 217FrontAxle(Differential) ................... 322
Fuel................................. 238
Adding............................. 243
Filter ............................... 302
Gauge.............................. 136
Octane Rating......................238,346
Requirements......................238,345
Tank Capacity........................ 345
Fuel, Flexible.............See Flexible Fuel Vehicles
Fueling ............................... 243
Fuses................................ 327
Garage Door Opener (HomeLink) ........... 110
Gas Cap (Fuel Filler Cap)...............244,293
Gas Gauge (Fuel Gauge)................... 136
Gasoline (Fuel)......................... 238
Gasoline, Reformulated................... 239
Gauges
Coolant Temperature.................... 136
INDEX 383
10

High Beam/Low Beam Select.............. 96
Instrument Cluster..................... 136
Intensity Control....................... 91
Interior........................... 90,103
License............................. 343
Lights On Reminder..................... 93
Low Fuel.........................136,137
Malfunction Indicator (Check Engine)........ 142
Passing.............................. 95
Seat Belt Reminder..................... 137
Service.............................. 332
Turn Signal........................ 94,338
Warning (Instrument Cluster Description)..... 136
Limited-Slip Differential................... 210
Loading Vehicle......................... 247
Tires ............................... 222
Locks................................. 27
Auto Unlock.......................... 30
Automatic Door........................ 29Child Protection........................ 31
Door................................ 27
Keys................................ 12
Power Door........................... 28
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 61
Lubricating Oil......................... 322
Lubrication, Body....................... 307
LugNuts ............................. 281
Lumbar Support......................... 84
Maintenance Free Battery.................. 304
Maintenance Procedures................... 296
Maintenance Schedule.................... 350
Schedule “A”......................... 364
Schedule “B”......................... 353
Maintenance, Sunroof..................... 119
Malfunction Indicator Light (Check Engine) . . 142,294
Manual, Service......................... 374
386 INDEX