transmission fluid DODGE DURANGO 2005 2.G User Guide

CAUTION!
Be aware that if the fluid temperature is below 50°F
(10°C) it may not register on the dipstick. Do not add
fluid until the temperature is elevated enough to
produce an accurate reading.
7. Check for leaks. Release parking brake.
To prevent dirt and water from entering the transmission
after checking or replenishing fluid, make certain that the
dipstick cap is properly reseated. It is normal for the
dipstick cap to spring back slightly from its fully seated
position, as long as its seal remains engaged in the
dipstick tube.
Automatic Transmission Fluid And Filter Change
It is important that proper lubricant is used in the
transmission. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type. It is importantthat the transmission fluid be maintained at the pre-
scribed level using the recommended fluid.
CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Recommended Fluids, Lubricants and Genuine Parts
for correct fluid type.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. Exception to
this policy is the use of special dyes to aid in detecting
334 MAINTAINING YOUR VEHICLE

fluid leaks. The use of transmission sealers should be
avoided, since they may adversely affect seals.
Transfer Case
Inspect the transfer case for fluid leaks. If a fluid leak is
evident the transfer case fluid level may be low. Have the
transfer case serviced immediately.
CAUTION!
Damage may result from operation of the vehicle
with low transfer case fluid.
The transfer case fluid should be drained and refilled at
the intervals specified.
Lubricant Selection
Refer to Recommended Fluids, Lubricants and Genuine
Parts for correct fluid type.
Axles
Refer to Recommended Fluids, Lubricants and Genuine
Parts for correct fluid type.
The manufacturer does not recommend regularly sched-
uled oil changes for axles in vehicles whose operation is
classified as normal truck service.
NOTE:The presence of water in the gear lubricant will
result in corrosion and possible failure of differential
components. Operation of the vehicle in water, as may be
encountered in some off-highway types of service, will
require draining and refilling the axle to avoid damage.
Rear Axle
Rear Axle fluid levels should be 7/8(22 mm) below the
fill hole for 8 1/4axles, and 1 1/4(31 mm) below the fill
hole for 9 1/4axles.
MAINTAINING YOUR VEHICLE 335
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid or equivalent.
Transfer Case MoparATF+4, Automatic Transmission Fluid or equivalent.
Front Axle SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant or equivalent.
Rear Axle SAE 75W-140 Synthetic Gear Lubricant or equivalent.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid or equivalent.
360 MAINTAINING YOUR VEHICLE

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
MAINTENANCE SCHEDULES 365
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Drain and refill automatic transmission fluid,
change filter (3.7L). This applies only if your ve-
hicle is used for police, taxi, fleet, or frequent
trailer towing.X
Drain and refill automatic transmission fluid and
change main sump filter (4.7L/5.7L only). This ap-
plies only if your vehicle is used for police, taxi,
fleet, or frequent trailer towing.X
Inspect transfer case fluid (4X4).X
Flush and replace engine coolant at 60 months, or
102, 000 miles (163 000 km) whichever comes first.
SCHEDULE “B” 371
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Drain and refill automatic transmission fluid,
change filter (3.7L). This applies only if your
vehicle is used for police, taxi, fleet, or fre-
quent trailer towing.X
Drain and refill automatic transmission fluid
and change main sump filter and spin-on
cooler return filter if equipped. (4.7L/5.7L
only). This applies only if your vehicle is used
for police, taxi, fleet, or frequent trailer tow-
ing.X
Flush and replace engine coolant at 120
months, if not replaced at 102,000 miles (163
000 km).X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
376 SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake) System............167,236
Adding Fuel........................262,286
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 316
Air Conditioner Maintenance............198,319
Air Conditioning........................ 197
Air Conditioning, Operating Tips............ 209
Air Conditioning, Rear Zone................ 201
Air Conditioning Refrigerant.............319,320
Air Conditioning System................197,319
Air Filter.............................. 316
Air Pressure, Tires....................249,257
Airbag.............................38,171
Airbag Light............................ 51
Alarm..............................24,167
Alarm, Panic............................ 21
Alignment and Balance................... 256
Alterations/Modifications, Vehicle............. 6
Antenna, Satellite Radio................... 194
Antifreeze (Engine Coolant)...........326,327,357Anti-Lock Brake System (ABS).............. 236
Anti-Lock Warning Light.................. 167
Anti-Theft System.....................24,167
Appearance Care........................ 337
Arming Theft System...................... 25
Auto Unlock, Doors....................... 16
Automatic Dimming Mirror...............74,78
Automatic Door Locks..................... 15
Automatic Headlights.................... 122
Automatic Transaxle...................... 221
Automatic Transmission.............218,221,332
Adding Fluid......................... 333
Fluid and Filter Changes................. 334
Fluid Level Check...................... 332
Fluid Type........................334,360
Gear Ranges.......................... 221
Special Additives...................... 334
Torque Converter...................... 225
Axle Fluid............................. 360
394 INDEX

Axle Lubrication........................ 335
Ball Joints............................. 321
Battery............................... 318
Charging............................ 296
Emergency Starting..................... 296
Gas Caution.......................... 296
Keyless Transmitter Replacement............ 24
Saving Feature (Protection)............... 121
Belts, Drive............................ 315
Belts, Seat.............................. 29
Body Mechanism Lubrication............... 321
B-Pillar Location........................ 244
Brake Fluid............................ 360
Brake System........................236,330
Anti-Lock........................... 236
Disc Brakes.......................... 330
Fluid Check.......................... 331
Hoses.............................. 332Master Cylinder....................... 331
Parking............................. 234
Warning Light.....................167,169
Brakes............................... 236
Brake/Transmission Interlock............... 221
Break-In Recommendations, New Vehicle........ 64
Bulb Replacement....................... 349
Bulbs, Light............................ 348
Calibration, Compass..................... 140
Capacities, Fluid........................ 357
Caps, Filler
Fuel.............................262,263
Oil (Engine).......................... 313
Power Steering........................ 320
Radiator (Coolant Pressure)............... 324
Car Washes............................ 337
Carbon Monoxide Warning............65,144,266
Cargo Management System................. 156
INDEX 395
10

Turn Signal.....................125,164,350
Flat Tire Stowage.....................289,295
Flooded Engine Starting................... 219
Floor Console.......................... 153
Fluid, Brake.........................331,360
Fluid Capacities......................... 357
Fluid Level Checks
Automatic Transmission................. 332
Brake............................... 331
Cooling System....................... 324
Engine Oil........................... 311
Power Steering........................ 320
Transfer Case......................... 335
Fog Lights..........................124,356
Folding Rear Seat.....................106,109
Four Wheel Drive....................... 226
Operation........................... 226
Four-Way Hazard Flasher.................. 286
Freeing A Stuck Vehicle................... 239Front Axle............................. 336
Fuel................................. 260
Adding............................. 262
Filter............................... 316
Gauge.............................. 164
Octane Rating......................260,359
Requirements......................260,357
Tank Capacity........................ 357
Fueling............................... 262
Fuses.............................152,341
Garage Door Opener..................... 142
GasCap ...........................263,307
Gas Gauge (Fuel Gauge)................... 164
Gasoline.............................. 260
Gasoline, Reformulated................... 261
Gauges
Coolant Temperature.................... 164
Fuel................................ 164
INDEX 399
10

Hitches............................. 275
Minimum Requirements................. 276
Trailer and Tongue Weight................ 274
Wiring.............................. 277
Trailer Towing Guide..................... 275
Trailer Weight.......................... 275
Transaxle............................. 221
Automatic........................... 221
Operation........................... 221
Transfer Case........................... 335
Fluid............................... 360
Transmission........................221,332
Automatic........................221,332
Filter............................... 334
Fluid............................334,360
Maintenance.......................... 332
Transmitter Battery Service.................. 24
Transmitter, Garage Door Opener............ 142
Transmitter Programming................... 22Tread Wear Indicators.................... 254
Trip Computer.......................... 136
Trip Odometer.......................... 168
Trip Odometer Reset Button................ 172
Turn Signals......................125,164,350
Underhood Fuses........................ 345
Universal Transmitter..................... 142
Unlock, Auto........................... 16
Vacuum/Vapor Harnesses................. 329
Vanity Mirrors........................... 77
Variance, Compass....................... 141
Vehicle Identification Number................ 5
Vehicle Loading......................245,268
Vehicle Modifications/Alterations.............. 6
Vehicle Storage......................... 381
Warning Lights (Instrument Cluster Description) . 164
INDEX 409
10