radiator cap DODGE DURANGO 2013 3.G Owners Manual

•Check for accumulations of plants or brush. These
things could be a fire hazard. They might hide damage
to fuel lines, brake hoses, axle pinion seals, and
propeller shafts.
• After extended operation in mud, sand, water, or
similar dirty conditions, have the radiator, fan, brake
rotors, wheels, brake linings, and axle yokes inspected
and cleaned as soon as possible.
WARNING!
Abrasive material in any part of the brakes may cause
excessive wear or unpredictable braking. You might
not have full braking power when you need it to
prevent a collision. If you have been operating your
vehicle in dirty conditions, get your brakes checked
and cleaned as necessary. •
If you experience unusual vibration after driving in
mud, slush or similar conditions, check the wheels for
impacted material. Impacted material can cause a
wheel imbalance and freeing the wheels of it will
correct the situation.
POWER STEERING
3.6L Engine
Your vehicle is equipped with an electro-hydraulic power
steering system that will give you good vehicle response
and increased ease of maneuverability in tight spaces.
The system will vary its assist to provide light efforts
while parking and good feel while driving. If the electro-
hydraulic power steering system experiences a fault that
prevents it from providing power steering assist, then the
system will provide mechanical steering capability.
480 STARTING AND OPERATING

•You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads HOT
(H), pull over and stop the vehicle. Idle the vehicle
with the air conditioner turned off until the pointer
drops back into the normal range. If the pointer
remains on HOT (H), and you hear continuous
chimes, turn the engine off immediately and call for
service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
6
WHAT TO DO IN EMERGENCIES 575

ENGINE COMPARTMENT — 3.6L
1 — Totally Integrated Power Module (Fuses)6 — Air Cleaner Filter
2 — Engine Oil Dipstick 7 — Washer Fluid Reservoir
3 — Engine Oil Fill 8 — Coolant Pressure Cap (Radiator)
4 — Brake Fluid Reservoir 9 — Engine Coolant Reservoir
5 — Power Steering Fluid Reservoir
7
MAINTAINING YOUR VEHICLE 605

ENGINE COMPARTMENT — 5.7L
1 — Totally Integrated Power Module (Fuses)6 — Washer Fluid Reservoir
2 — Automatic Transmission Dipstick 7 — Engine Oil Dipstick
3 — Engine Oil Fill 8 — Coolant Pressure Cap (Radiator)
4 — Brake Fluid Reservoir 9 — Engine Coolant Reservoir
5 — Air Cleaner Filter 606 MAINTAINING YOUR VEHICLE

Cooling System
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
Engine Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If the engine coolant (antifreeze) is dirty or
rusty in appearance, the system should be drained,
flushed and refilled with fresh engine coolant (anti-
freeze). Check the front of the A/C condenser for anyaccumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the engine cooling system hoses for brittle rubber,
cracking, tears, cuts, and tightness of the connection at
the coolant recovery bottle and radiator. Inspect the
entire system for leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
engine coolant (antifreeze) from the radiator drain cock.
If the cap is sealing properly, the engine coolant (anti-
freeze) will begin to drain from the coolant recovery
bottle. DO NOT REMOVE THE COOLANT PRESSURE
CAP WHEN THE COOLING SYSTEM IS HOT.
7
MAINTAINING YOUR VEHICLE 625

Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing engine coolant (antifreeze) types is not
recommended and can result in cooling system damage.
Drain, flush, and refill as soon as possible to avoid
damage if coolant types are mixed in an emergency.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
• The warning words “DO NOT OPEN HOT” on the
cooling system pressure cap are a safety precaution.
Never add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or remove the
cap to cool an overheated engine. Heat causes
pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
628 MAINTAINING YOUR VEHICLE

rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month.When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
7
MAINTAINING YOUR VEHICLE 629

Fluid Level Check..................... .634
Fluid Type .......................... .634
Special Additives ...................... .635
Autostick .............................. .456
Auxiliary Electrical Outlet (Power Outlet) ........275
Auxiliary Power Outlet .....................275
Battery ................................ .615
Keyless Transmitter Replacement (RKE) ........27
Belts, Seat ...............................53
Blind Spot Monitoring ..................... .125
Body Mechanism Lubrication .................619
B-Pillar Location ......................... .504
Brake Assist System ...................... .488
Brake Control System, Electronic ..............486
Brake Fluid ............................ .631
Brake System ........................... .630
Anti-Lock (ABS) ...................... .486
Fluid Check .......................... .631Master Cylinder
....................... .631
Parking ............................. .483
Warning Light ........................ .318
Brake/Transmission Interlock .................449
Bulb Replacement ........................ .651
Bulbs, Light .............................112
Calibration, Compass ..................... .342
Camera, Rear ........................... .257
Capacities, Fluid ......................... .656
Caps, Filler Fuel ............................... .542
Oil (Engine) ......................... .613
Power Steering ....................... .482
Radiator (Coolant Pressure) ...............628
Carbon Monoxide Warning ..................109
Cargo Area Cover ........................ .292
Cargo Area Features ...................... .291
10
INDEX 679

Cargo Compartment...................... .291
Light .............................. .292
Luggage Carrier ...................... .296
Cargo Light ............................ .292
Cargo Tie-Downs ........................ .293
Car Washes ............................ .639
Cellular Phone .......................... .422
Center High Mounted Stop Light ..............655
Certification Label ........................ .545
Chains, Tire ............................ .520
Changing A Flat Tire ...................... .576
Chart, Tire Sizing ........................ .500
Check Engine Light (Malfunction Indicator Light) . .608
Checking Your Vehicle For Safety ..............108
Checks, Safety .......................... .108
Child Restraint ............................83
Child Safety Locks .........................36
Clean Air Gasoline ....................... .534Cleaning
Wheels ............................. .640
Climate Control ......................... .423
Clock ................................. .355
Cold Weather Operation ....................444
Compact Disc (CD) Maintenance ..............422
Compact Spare Tire ....................... .514
Compass .............................. .340
Compass Calibration ...................... .342
Compass Variance ........................ .341
Computer, Trip/Travel ..................... .338
Connector UCI ............................... .380
Universal Consumer Interface (UCI) .........380
Conserving Fuel ......................... .336
Console, Overhead ....................... .260
Contract, Service ......................... .671
Coolant Pressure Cap (Radiator Cap) ...........628
680 INDEX

Cooling System.......................... .625
Adding Coolant (Antifreeze) ...............627
Coolant Capacity ...................... .656
Coolant Level ........................ .629
Disposal of Used Coolant .................628
Drain, Flush, and Refill ..................626
Inspection ........................... .625
Points to Remember .....................629
Pressure Cap ......................... .628
Radiator Cap ......................... .628
Selection of Coolant (Antifreeze) ............626
Corrosion Protection ...................... .638
Cruise Control (Speed Control) ................222
Cupholders ............................ .282
Customer Assistance ...................... .669
Data Recorder, Event .......................82
Daytime Running Lights ....................203
Dealer Service ........................... .609Defroster, Rear Window
.....................295
Defroster, Windshield ......................110
Dipsticks Automatic Transmission ..................636
Oil (Engine) ...........................611
Power Steering ....................... .482
Disabled Vehicle Towing ....................598
Disposal Antifreeze (Engine Coolant) ...............628
Door Locks ..............................33
Door Opener, Garage ...................... .262
Driving ............................... .475
Driving to Achieve Maximum Fuel Economy ......336
E-85 Fuel .............................. .538
Electrical Outlet, Auxiliary (Power Outlet) ........275
Electric Rear Window Defrost .................295
Electric Remote Mirrors .....................122
Electronically Shifted Transfer Case .............469
10
INDEX 681