transfer case DODGE DURANGO 2022 Owner's Manual

276SERVICING AND MAINTENANCE
Selection Of Lubricant
It is important to use the proper transmission fluid
to ensure optimum transmission performance and
life. Use only the manufacturer's specified
transmission fluid Úpage 312. It is important to
maintain the transmission fluid at the correct level
using the recommended fluid.
NOTE:No chemical flushes should be used in any trans -
mission; only the approved lubricant should be
used.
FRONT/REAR AXLE FLUID
For normal service, periodic fluid level checks are
not required. When the vehicle is serviced for other
reasons the exterior surfaces of the axle assembly
should be inspected. If gear oil leakage is
suspected inspect the fluid level.
Front Axle Fluid Level Check
The front axle oil level needs to be no lower than
1/8 inch (3 mm) below the bottom of the fill hole.
The front axle fill and drain plugs should be
tightened to 22 to 29 ft lbs (30 to 40 N·m).
Rear Axle Fluid Level Check
The rear axle oil level needs to be no lower than
1/8 inch (3 mm) below the bottom of the fill hole.
The rear axle fill and drain plugs should be
tightened to 22 to 29 ft lbs (30 to 40 N·m).
Selection Of Lubricant
Use only the manufacturer's recommended fluid
Ú page 312.
TRANSFER CASE
Fluid Level Check
For normal service, periodic fluid level checks are
not required. When the vehicle is serviced for other
reasons the exterior surfaces of the transfer case
assembly should be inspected. If oil leakage is
suspected inspect the fluid level.
Adding Fluid
With the vehicle in a level position, fill the transfer
case to bottom edge of fill plug opening.
Drain
First remove fill plug, then remove drain plug.
Recommended tightening torque for drain and fill
plugs is 15 to 25 ft lbs (20 to 34 N·m).
Selection Of Lubricant
Use only the manufacturer's recommended fluid
Úpage 312.
CAUTION!
Using a transmission fluid other than the
manufacturer recommended fluid may cause
deterioration in transmission shift quality and/or
torque converter shudder Ú page 312.
CAUTION!
Do not overtighten the plugs as it could damage
them and cause them to leak.
CAUTION!
Do not overtighten the plugs as it could damage
them and cause them to leak.
CAUTION!
When installing plugs, do not overtighten. You
could damage them and cause them to leak.

22_WD_OM_EN_USC_t.book Page 276

312TECHNICAL SPECIFICATIONS
ENGINE FLUIDS AND LUBRICANTS
CHASSIS FLUIDS AND LUBRICANTS
Component Fluid, Lubricant, or Genuine Part
Engine CoolantWe recommend using Mopar® Antifreeze/Coolant 10 Year/150,000 Mile (240,000 km) Formula OAT
(Organic Additive Technology) meeting the requirements of the manufacturer Material Standard
MS.90032.
Engine Oil – 3.6L & 5.7L Engine We recommend using Mopar® SAE 0W-20 Full Synthetic Engine Oil which meets the requirements of
the manufacturer Material Standard MS-6395. Equivalent full synthetic SAE 0W-20 engine oil can be
used but must have the API Starburst trademark Ú
page 263.
Engine Oil Filter We recommend using a Mopar® Engine Oil Filter. If a Mopar® Engine Oil Filter is unavailable only use
filters that meet or exceed SAE/USCAR-36 Filter Performance Requirements.
Fuel Selection – 3.6L Engine 87 Octane (R+M)/2 Method , 0-15% Ethanol (Do not use E-85).
Fuel Selection – 5.7L Engine 89 Octane Recommended - 87 Octane Acceptable (R+M)/2 Method,
0-15% Ethanol (Do not use E-85).
Component
Fluid, Lubricant, or Genuine Part
Automatic TransmissionUse only Mopar® ZF 8 & 9 Speed ATF Automatic Transmission Fluid or equivalent. Failure to use the
correct fluid may affect the function or performance of your transmission.
Transfer Case We recommend using Mopar® ATF+4 Automatic Transmission Fluid.
Axle Differential (Front-Rear) – Without Electronic
Limited-Slip Differential (ELSD) We recommend using Mopar® GL-5 Synthetic Axle Lubricant SAE 75W-85.
Axle Differential (Rear) – With Electronic Limited-Slip
Differential (ELSD) We recommend using Mopar® GL-5 Synthetic Axle Lubricant SAE 75W-85 with integrated friction
modifier.
Brake Master Cylinder We recommend using Mopar® DOT 3 Brake Fluid, SAE J1703.

22_WD_OM_EN_USC_t.book Page 312

319
Disabled Vehicle Towing
................................ 253Disposal Antifreeze (Engine Coolant)....................... 273Door Ajar................................................... 90, 91Door Ajar Light.......................................... 90, 91Door Locks............................................... 22, 25Child-Protection Door Lock — Rear Doors.... 25Doors............................................................... 22Driver’s Seat Back Tilt..................................... 29Driving........................................................... 153
E
Economy (Fuel) Mode.................................... 105Electric Brake Control System....................... 183Anti-Lock Brake System............................. 182Electronic Roll Mitigation................. 184, 187Electric Remote Mirrors................................... 42Electrical Outlet, Auxiliary (Power Outlet)......... 66Electronic Speed Control (Cruise Control)...... 117Electronic Stability Control (ESC)...................184Electronic Throttle Control Warning Light........ 91Electronically Shifted Transfer Case.............. 109Emergency Gas Can Refueling...................... 248Emergency, In Case OfFreeing Vehicle When Stuck...................... 252Hazard Warning Flasher............................ 235Jacking...................................................... 239Jump Starting............................................ 246
Emission Control System Maintenance........... 98Engine........................................................... 259Air Cleaner................................................ 263Break-In Recommendations..................... 102Checking Oil Level.................................... 261Compartment.................................. 259, 260Compartment Identification............. 259, 260Cooling..................................................... 272Exhaust Gas Caution................................ 234Fails To Start............................................ 102Flooded, Starting...................................... 102Fuel Requirements.......................... 308, 311Jump Starting........................................... 246Oil.................................................... 262, 311Oil Filler Cap............................................. 259Oil Filter.................................................... 263Oil Selection........................... 262, 311, 312Oil Synthetic............................................. 263Starting........................................................ 99Enhanced Accident
Response Feature............................... 214, 254Ethanol......................................................... 309Exhaust Gas Cautions................................... 234Exhaust System................................... 234, 271Exterior Lights............................... 47, 234, 284
F
FiltersAir Cleaner
................................................ 263Air Conditioning........................ 61, 264, 265Engine Oil................................................. 263Engine Oil Disposal................................... 263Flashers........................................................ 235Hazard Warning........................................ 235Turn Signals.............................. 96, 234, 285Flash-To-Pass...................................................49Flooded Engine Starting................................ 102Fluid Capacities............................................ 311Fluid Leaks.................................................... 234Fluid Level ChecksBrake........................................................ 274Engine Oil................................................. 261Fluids And Lubricants.................................... 312Fog Lights..................................................... 285Fog Lights, Service........................................ 285Fold-Flat Seats.................................................29Folding Rear Seats...........................................31Forward Collision Warning............................ 191Four-Way Hazard Flasher.............................. 235Freeing A Stuck Vehicle................................. 252Front Axle (Differential)................................. 276
11

22_WD_OM_EN_USC_t.book Page 319

323
Pregnant Women And Seat Belts
...................202Preparation For Jacking................................. 239Pretensioners Seat Belts.................................................. 202
R
Radial Ply Tires.............................................. 294Radiator Cap (Coolant Pressure Cap)............ 273Radio Operation............................................ 181Radio Remote Controls.................................. 181Rain Sensitive Wiper System........................... 53Rear Air Conditioning....................................... 59Rear Axle (Differential)................................... 276Rear Camera................................................. 136Rear Cross Path............................................. 190Rear ParkSense System................................ 127Rear Seat Reminder Alert.............................. 183Rear Seats, Folding......................................... 31Rear Wiper/Washer......................................... 54Reclining Front Seats...................................... 30Recreational Towing...................................... 149Shifting Into Transfer Case Neutral (N)..... 151Shifting Out Of Transfer Case Neutral (N)............................................ 152Reformulated Gasoline.................................. 309Refrigerant.................................................... 265Release, Hood................................................. 73Reminder, Seat Belt...................................... 197Remote ControlStarting System........................................... 18
Remote Keyless Entry...................................... 14Arm The Alarm............................................. 21Disarm The Alarm........................................ 21Programming Additional Key Fobs............... 16Remote Sound System (Radio) Control......... 181Remote StartingExit Remote Start Mode.............................. 19Remote Starting System.................................. 18Replacement Bulbs...................................... 284Replacement Keys........................................... 16Replacement Tires........................................ 296Reporting Safety Defects.............................. 315Restraints, Child........................................... 216Restraints, Head.............................................. 37Retractable Cargo Area Cover.......................... 75Roll Over Warning.............................................. 9Roof Type Carrier............................................. 76Rotation, Tires.............................................. 302
S
Safety Checks Inside Vehicle........................ 232Safety Checks Outside Vehicle..................... 233Safety Defects, Reporting............................. 315Safety Information, Tire................................ 286Safety Tips.................................................... 231Safety, Exhaust Gas...................................... 234Schedule, Maintenance................................ 255Seat Belt Reminder.......................................... 89Seat Belts............................................ 197, 232Adjustable Shoulder Belt.......................... 201
Adjustable Upper Shoulder Anchorage..... 201Adjustable Upper Shoulder BeltAnchorage............................................ 201Automatic Locking Retractor (ALR)........... 202Child Restraints........................................ 216Energy Management Feature................... 202Extender................................................... 201Front Seat............................... 197, 198, 200Inspection................................................. 232Lap/Shoulder Belt Operation.................... 200Lap/Shoulder Belt Untwisting................... 200Lap/Shoulder Belts................................... 198Operating Instructions.............................. 200Pregnant Women...................................... 202Pretensioners........................................... 202Rear Seat.................................................. 198Reminder.................................................. 197Seat Belt Extender.................................... 201Seat Belt Pretensioner.............................. 202Untwisting Procedure................................ 200Seat Belts Maintenance................................ 305Seats........................................... 29, 34, 35, 36Adjustment.................................... 29, 34, 35Easy Entry....................................................35Heated.........................................................36Memory.......................................................27Rear Folding......................................... 29, 31Reclining......................................................30Seatback Release........................................29Tilting...........................................................29
11

22_WD_OM_EN_USC_t.book Page 323

325
Towing
................................................. 139, 253Disabled Vehicle........................................ 253Guide......................................................... 142Recreational.............................................. 149Weight....................................................... 142Towing Behind A Motorhome......................... 149Traction Control............................................. 187Trailer Sway Control (TSC)............................. 187Trailer Towing................................................ 139Hitches...................................................... 141Minimum Requirements............................ 144Tips........................................................... 148Trailer And Tongue Weight........................ 143Wiring........................................................ 147Trailer Towing Guide...................................... 142Trailer Weight................................................ 142Transfer Case................................................ 276Electronically Shifted................................. 109Fluid.......................................................... 312Maintenance............................................. 276Transmission................................................. 105Automatic........................................ 105, 275Fluid.......................................................... 312Maintenance............................................. 275Shifting...................................................... 104Transporting Pets.......................................... 232Tread Wear Indicators................................... 295Turn Signals............................................ 96, 285
U
Uconnect Settings Customer Programmable Features
...... 23, 25Passive Entry Programming.................. 23, 25Uniform Tire Quality Grades.......................... 303Universal Garage Door Opener
(Homelink®)
b
.............................................. 43Unleaded Gasoline....................................... 308Untwisting Procedure, Seat Belt................... 200
V
Vanity Mirrors.................................................. 41Vehicle Identification Number (VIN).............. 307Vehicle Loading................................... 138, 290Vehicle Maintenance.................................... 262Vehicle Modifications/Alterations.................... 10Vehicle Security System................................... 21Vehicle Storage.......................................61, 304Voice Command............................................... 39Voice Recognition System (VR)........................ 39
W
Warning Flashers, Hazard............................. 235Warning Lights
(Instrument Cluster Descriptions).................... 93Warnings, Roll Over........................................... 9Warranty Information.................................... 315
Washers, Windshield............................. 52, 261Washing Vehicle............................................ 304Wheel And Wheel Tire Care........................... 299Wheel And Wheel Tire Trim........................... 299Wind Buffeting.................................................71Window Fogging...............................................61Windows..........................................................69Power...........................................................69Reset Auto-Up..............................................70Windshield Defroster.................................... 232Windshield Washers.............................. 52, 261Fluid.......................................................... 261Windshield Wiper Blades.............................. 268Windshield Wipers...........................................52Wipers Blade Replacement........................... 268Wipers, Intermittent.........................................52Wipers, Rain Sensitive.....................................53Wireless Charging Pad.....................................69
11

22_WD_OM_EN_USC_t.book Page 325