turn signal DODGE GRAND CARAVAN 2005 Owner's Manual

WARNING!• Anti-lock system (ABS) cannot prevent the natu-
ral laws of physics from acting on the vehicle, nor
can it increase braking or steering efficiency be-
yond that afforded by the condition of the vehicle
brakes and tires or the traction afforded.
• The ABS cannot prevent accidents, including
those resulting from excessive speed in turns,
following another vehicle too closely, or hydro-
planing. Only a safe, attentive, and skillful driver
can prevent accidents.
• The capabilities of an ABS equipped vehicle must
never be exploited in a reckless or dangerous
manner which could jeopardize the user ’ s safety
or the safety of others. All vehicle wheels and tires must be the same size and
type and tires must be properly inflated to produce
accurate signals for the computer.
POWER STEERING
The standard power steering system will give you good
vehicle response and increased ease of maneuverability
in tight spaces. The system will provide mechanical
steering capability if power assist is lost.
If for some reason, the power assist is interrupted, it will
still be possible to steer your vehicle. Under these condi-
tions you will observe a substantial increase in steering
effort, especially at very low vehicle speeds and during
parking maneuvers.
NOTE: Increased noise levels at the end of the steering
wheel travel are considered normal and does not indicate
that there is a problem with the power steering system. STARTING AND OPERATING 305
5

• The tongue weight of the trailer.
• The weight of any other type of cargo or equipment
put in or on your vehicle.
• Remember that everything put in or on the trailer adds
to the load on your vehicle.
Tongue weight must be equal to at least 10% of Gross
Trailer Weight (GTW), but no more than 15% of GTW.
Towing Requirements
• The maximum frontal area of the trailer cannot exceed
40 square feet (3.72 square meters).
• The trailer tongue load must be considered as part of
the combined weight of occupants and cargo, and
should never exceed the weight referenced on the Tire
and Loading Information placard. Refer to the Tire –
Safety Information Section in this manual.
• The “ D ” range can be selected when towing. However,
if frequent shifting occurs while in this range, the “ 3 ”
range must be selected. NOTE: Using the “ 3 ” range while operating the vehicle
under heavy operating conditions will improve perfor-
mance and extend transaxle life by reducing excessive
shifting and heat build up.
• Do not attempt to tow a trailer while using a compact
spare tire.
• Whenever you pull a trailer, regardless of the trailer
size, stop lights and turn signals on the trailer are
recommended for motoring safety.
• The automatic transaxle fluid and filter should be
changed if you REGULARLY tow a trailer for more
than 45 minutes of continuous operation. See Schedule
“ B ” in section 8 of this manual for transaxle fluid
change intervals.
NOTE: Check the automatic transaxle fluid level before
towing. STARTING AND OPERATING 339
5

HAZARD WARNING FLASHER
The hazard flasher switch is located in the center of the
instrument panel above the radio.
To engage the Hazard Warning Flashers, depress the
switch on the instrument panel. When the Hazard Warn-
ing Switch is activated, all directional turn signals will flash on and off to warn oncoming traffic of an emer-
gency. Push the switch a second time to turn off the
flashers.
This is an emergency warning system and should not be
used when the vehicle is in motion. Use it when your
vehicle is disabled and is creating a safety hazard for
other motorists.
When you must leave the vehicle to seek assistance, the
Hazard Warning Flashers will continue to operate even
though the ignition switch is OFF.
NOTE: With extended use, the Hazard Warning Flash-
ers may wear down your battery.Hazard Flasher Switch344 WHAT TO DO IN EMERGENCIES

▫ Steering Shaft Seal ....................391
▫ Steering Linkage ......................391
▫ Drive Shaft Universal Joints ..............391
▫ Body Lubrication .....................391
▫ Windshield Wiper Blades ................392
▫ Windshield And Rear Window Washers .....392
▫ Exhaust System ......................393
▫ Cooling System .......................394
▫ Hoses And Vacuum/Vapor Harnesses .......399
▫ Brakes .............................399
▫ Master Cylinder — ABS Brakes Brake
Fluid Level Check .....................401
▫ Fuel System Hoses ....................402 ▫ Automatic Transmission ................402
▫ Front And Rear Wheel Bearings ...........406
▫ Appearance Care And Protection
From Corrosion ......................406
▫ Cleaning The Instrument Panel And Underseat
Cup Holders ........................410

Integrated Power Module (IPM) ............412

Vehicle Storage ........................415

Replacement Light Bulbs .................415

Bulb Replacement ......................416
▫ Headlights ..........................416
▫ Front Park/Turn Signal And
Sidemarker Lights .....................418
▫ Front Fog Light ......................419372 MAINTAINING YOUR VEHICLE

▫ Rear Tail, Stop, Turn Signal, Side Marker And
Back-Up Lights .......................419
▫ Center High Mounted Stop Light (CHMSL) . . . 420
▫ License Light ........................421

Fluids And Capacities ...................421
Recommended Fluids, Lubricants
And Genuine Parts .....................422
▫ Engine .............................422
▫ Chassis ............................423 MAINTAINING YOUR VEHICLE 373
7

NOTE: For lighted switches, see your dealer for replace-
ment instructions.
All of the interior bulbs are glass wedge base or glass
cartridge types. Aluminum base bulbs are not approved
and should not be used for replacement.
LIGHT BULBS — Exterior Bulb Number
Back-up, Tail, Stop, Turn Signal, & Sidemarker . . . 3057
Center High-Mounted Stop Light ............. 921
Fog Light — If Equipped .................. 9145
Front Side marker, Park/Turn Signal ........ 3457AK
Headlight ............................. 9007
License ................................ 168 BULB REPLACEMENT
Headlights
1. Remove the three screws securing the headlight mod-
ule.416 MAINTAINING YOUR VEHICLE

Front Park/Turn Signal and Sidemarker Lights
1. Remove the three screws securing the headlight mod-
ule.
2. Twist the turn signal socket to remove from the
headlight module and pull bulb from socket. 3. Replace bulb, reinstall socket and then reinstall the
headlight module.418 MAINTAINING YOUR VEHICLE

Front Fog Light
1. Reach behind the front fascia from under the vehicle.
2. Twist the front fog light bulb to remove from the fog
light housing.
3. Disconnect the electrical connector and replace the
bulb.
CAUTION!Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with an oily surface, clean the
bulb with rubbing alcohol. Rear Tail, Stop, Turn Signal, Side Marker and
Back-up Lights
1. Raise the liftgate.
2. Remove the two tail light assembly push-in type
fasteners, by prying under the fastener head with a large
flat screwdriver. MAINTAINING YOUR VEHICLE 419
7

Temperature Gauge ..................... 200
Exhaust Gas Caution .............. 38,83,333,393
Exhaust System ......................... 393
Extender, Seat Belt ........................ 52
Exterior Folding Mirrors ................... 93
Filters
Air Cleaner .......................... 384
Air Conditioning .................... 284,389
Automatic Transaxle .................... 405
Engine Oil ........................ 383,422
Engine Oil Disposal .................... 383
Flashers
Hazard Warning ....................... 344
Turn Signal ..................... 197,418,419
Flat Tire Stowage ........................ 355
Fluid Capacities ......................... 421
Fluid Leaks ............................. 85 Fluid Level Checks
Automatic Transmission ................. 404
Brake ............................... 401
Power Steering ........................ 390
Fog Light Service ........................ 419
Fog Lights .......................... 138,419
Freeing A Stuck Vehicle ................... 368
Fuel ................................. 330
Adding ............................. 334
Additives ............................ 332
Clean Air ............................ 331
Filler Cap ............................ 334
Gasoline ............................ 330
Gauge .............................. 196
Hoses .............................. 402
Light ............................... 197
Octane Rating ...................... 330,422
Requirements ...................... 330,421
Tank Capacity ........................ 421 INDEX 463
10

Service Engine Soon (Malfunction Indicator) . . . 202
Side Marker .......................... 419
Theft Alarm .......................... 200
Turn Signal ..................... 138,418,419
Voltage ............................. 199
Warning (Instrument Cluster Description) ..... 196
Washer Fluid ......................... 201
Load Leveling System .................... 185
Loading Vehicle ................... 181,336,337
Capacities ........................... 337
Tires ............................... 312
Locks
Door ................................ 17
Lower Anchors and Tether for CHildren (LATCH) . 74
Lubrication, Body ....................... 391
Luggage Rack .......................... 182
Lumbar Support ........................ 112
Maintenance, Airbag ...................... 67 Maintenance Free Battery .................. 387
Maintenance Procedures ................... 379
Maintenance Schedule .................... 426
Schedule  A  ......................... 440
Schedule  B  .......................... 429
Maintenance, Sunroof ..................... 167
Malfunction Indicator Light .............. 202,377
Manual, Service ......................... 454
Map/Reading Lights ..................... 150
Mini-Trip Computer ...................... 154
Mirrors ................................ 92
Automatic Dimming ..................... 92
Electric Remote ........................ 94
Exterior Folding ........................ 93
Heated .............................. 95
Outside .............................. 94
Rearview ............................. 92
Vanity ............................... 95
Modifications/Alterations, Vehicle ............. 7 INDEX 467
10