light DODGE GRAND CARAVAN 2016 5.G Owners Manual

Cavity Cartridge Fuse Mini-FuseDescription
M20 –15 Amp Blue Instrument Cluster Interior Light, Switch Bank,
Steering Column Module, Switch Steering Wheel
M21 –20 Amp Yellow Powertrain
M22 –10 Amp Red Horn
M23 –10 Amp Red Horn
M24 –25 Amp Clear Rear Wiper
M25 –20 Amp Yellow Fuel Pump, Diesel Lift Pump – If Equipped
M26 –10 Amp Red Power Mirror Switch, Driver Window Switch
M27 –10 Amp Red Wireless Control Module, Keyless Entry Module
M28 –10 Amp Red Powertrain, Transmission Control Module
M29 –10 Amp Red Occupant Classification Module
M30 –15 Amp Blue Rear Wiper Module, Power Folding Mirror
M31 –20 Amp Yellow Back-Up Lamps
M32 –10 Amp Red Airbag Module, THATCHUM – If Equipped
M33 –10 Amp Red Powertrain
652 MAINTAINING YOUR VEHICLE

Cavity Cartridge Fuse Mini-FuseDescription
M34 –10 Amp Red Park Assist, Heater Climate Control Module,
Headlamp Wash, Compass, Rear Camera, DoorLamps, Flashlight, Relay Diesel Cabin Heater, Rad Fan Diesel – If Equipped
M35 –10 Amp Red Heated Mirrors
M36 –20 Amp Yellow Power Outlet #3 (Instrument Panel or with Con-
sole Center)
M37 –10 Amp Red Antilock Brakes, Stability Control, Stop Lamp,
Fuel Pump
M38 –25 Amp Clear Door Lock/Unlock Motors, Liftgate Lock/Unlock
Motors
The power windows are fused by a 25 Amp circuit
breaker located in the Totally Integrated Power Module.
7
MAINTAINING YOUR VEHICLE 653

REPLACEMENT BULBS
Interior Bulbs
Bulb Number
Center & Rear Dome Lamp 578
Center & Rear Reading Lamps 578
Front Door Courtesy Lamp 578
Front Header Reading Lamps – If Equipped 578
Instrument Cluster Lamps PC74
Liftgate Lamp(s) 578
Overhead Console Reading Lamps PC579
Removable Console Lamp – If Equipped 194
Visor Vanity Lamps 6501966
NOTE: For lighted switches, see your authorized dealer for replacement instructions.
7
MAINTAINING YOUR VEHICLE 655

Fog Lamps
NOTE:Access to the fog lamp bulb is from the rear of the
fascia. On the left rear side of the fascia, remove the push
pin and lower the hinged access door on the air dam.
1. From behind the bumper fascia, or the access panel on the air dam, squeeze the two tabs on the side of the
bulb socket and pull straight out from the fog lamp.
CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with an oily surface, clean the
bulb with rubbing alcohol.
2. Disconnect the wire harness from the bulb.
3. Reconnect the wiring harness to the new bulb and reinstall by inserting the new bulb straight into the fog
lamp until it locks into place.
Rear Tail, Stop, Turn Signal, Side Marker And
Backup Lamps
1. Raise the liftgate.
2. Remove the tail lamp assembly by removing the twoscrews from the inboard side. Use a fiber stick or
similar tool to gently pry the light on the outboard side
to disengage the two ball studs.
Tail Lamp Assembly Screws
658 MAINTAINING YOUR VEHICLE

NOTE:•If a screwdriver is used, make sure a soft material is
placed between the vehicle body and tool so not to
scratch the paint.
• The PRY location is best closest to the studs while
dislodging them separately.
3. Twist the socket and remove from the lamp assembly.
4. Pull the bulb to remove it from the socket.
5. Replace the bulb, reinstall the socket, and reattach the lamp assembly.
Center High-Mounted Stop Lamp (CHMSL)
The CHMSL uses LED lamps that are not serviceable
separately. The CHMSL must be replaced as an assembly.
See your authorized dealer.
License Lamp
The license plate lamp is located under the tailgate light
bar and above the license plate.
1. Using a small screwdriver, press inward the lockingtab on the outboard side of the lamp assembly and
pull down on the lamp assembly for removal.
2. Twist and remove the socket from the lamp assembly and pull the bulb out to remove.
3. Push the bulb into the socket, twist the socket into the lamp assembly and reinstall the lamp assembly into
place ensuring the locking tab is secure.
7
MAINTAINING YOUR VEHICLE 659

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on. •
Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering and fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals.
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
• Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregular wear, even if it occurs before the oil indicator system
turns on.
• Inspect battery and clean and tighten terminals as required.
• Inspect brake pads, shoes, rotors, drums, hoses and park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or off-road conditions. 8
MAINTENANCE SCHEDULES 667

We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You will be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust (internal combustion engines only),
some of its constituents, and certain vehicle compo-
nents contain, or emit, chemicals known to the State
of California to cause cancer and birth defects, or
other reproductive harm. In addition, certain fluids
contained in vehicles and certain products of compo-
nent wear contain, or emit, chemicals known to the
State of California to cause cancer and birth defects,
or other reproductive harm.
WARRANTY INFORMATION
See the Warranty Information Booklet, located on the
DVD, for the terms and provisions of FCA US LLC
warranties applicable to this vehicle and market.
MOPAR PARTS
MOPAR fluids, lubricants, parts, and accessories are
available from an authorized dealer. They are recom-
mended for your vehicle in order to help keep the vehicle
operating at its best.
REPORTING SAFETY DEFECTS
In The 50 United States And Washington, D.C.
If you believe that your vehicle has a defect that could
cause a crash or cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying the
manufacturer.
678 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... .488
Adding Engine Coolant (Antifreeze) ............631
Adding Fuel ............................ .543
Adding Washer Fluid ..................... .628
Additives, Fuel .......................... .538
AirBag.................................78 Advance Front Air Bag ....................80
Air Bag Operation .......................81
Air Bag Warning Light ....................90
Driver Knee Air Bag ......................82
Enhanced Accident Response ................89
Event Data Recorder (EDR) .................92
FrontAirBag...........................78
If A Deployment Occurs ...................88
Knee Impact Bolsters .....................82
Maintaining Your Air Bag System ............91
Side Air Bags ...........................83
Transporting Pets .......................117
Air Bag Deployment ........................78 Air Bag Light
..................... .90, 120, 315
Air Bag Maintenance .......................91
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .621
Air Conditioner Maintenance .................625
Air Conditioning ......................... .440
Air Conditioning Controls ...................440
Air Conditioning Filter ..................459, 626
Air Conditioning, Operating Tips ..............458
Air Conditioning, Rear Zone ..............445, 455
Air Conditioning Refrigerant ..............625, 626
Air Conditioning System .............440, 448, 625
Air Conditioning System, Zone Control ..........440
Air Pressure, Tires ........................ .513
Alarm (Security Alarm) ..................17, 324
Alterations/Modifications, Vehicle ...............7
Antenna, Satellite Radio .....................381
Antifreeze (Engine Coolant) ...............631, 660
Disposal ............................. .634
Anti-Lock Brake System (ABS) ................489
684 INDEX

Anti-Lock Warning Light....................331
Appearance Care ........................ .640
Ashtray ............................... .276
Assistance Towing ........................ .160
Assist, Hill Start ......................... .492
Auto Down Power Windows ..................41
Automatic Dimming Mirror ..................132
Automatic Door Locks ......................37
Automatic Headlights ..................... .223
Automatic Temperature Control (ATC) ..........448
Automatic Transmission ..............468, 638, 639
Adding Fluid ......................... .639
Fluid And Filter Changes ..................639
Fluid Change ......................... .639
Fluid Level Check ...................... .639
Fluid Type ........................ .638, 663
Gear Ranges .......................... .473
Special Additives ...................... .638
Torque Converter ...................... .480Auto Up Power Windows
....................41
Battery ............................ .319, 624
Charging System Light ...................319
Jump Starting ......................... .600
Keyless Transmitter Replacement (RKE) ........28
Saving Feature (Protection) ................229
Belts, Seat .............................. .120
Body Mechanism Lubrication .................627
B-Pillar Location ......................... .507
Brake Assist System ...................... .491
Brake Control System, Electronic ..............488
Brake Fluid ............................ .663
Brake System ........................ .488, 635
Anti-Lock (ABS) ....................... .488
Fluid Check .......................... .636
Parking ............................. .485
Warning Light ........................ .317
Brake/T
ransmission Interlock .................470
10
INDEX 685

Bulb Replacement........................ .657
Bulbs, Light ......................... .122, 655
Calibration, Compass ..................... .350
Camera, Rear ........................... .248
Capacities, Fluid ......................... .660
Caps, Filler Fuel ................................ .543
Power Steering ........................ .484
Radiator (Coolant Pressure) ................633
Carbon Monoxide Warning ...............119,540
Cargo Compartment Luggage Carrier ....................... .291
Cargo (Vehicle Loading) ....................282
Car Washes ............................ .640
Cellular Phone .......................... .439
Center High Mounted Stop Light ..............659
Certification Label ........................ .546
Chains, Tire ............................ .524Changing A Flat Tire
...................... .581
Chart, Tire Sizing ........................ .502
Check Engine Light (Malfunction Indicator Light) . .615
Checking Your Vehicle For Safety ..............119
Checks, Safety ............................119
Child Restraint ............................93
Child Restraints Booster Seats ...........................98
Center Seat LATCH ..................... .107
Child Restraints .........................93
Child Seat Installation .................110,112
How To Stow An Unused ALR Seat Belt .......108
Infants And Child Restraints ................96
Install A LATCH-Compatible Child Restraint . . . .107
Installing Child Restraints Using The Vehicle Seat
Belt ................................ .109
Lower Anchors And Tethers For Children ......101
Older Children And Child Restraints ..........97
Seating Positions ....................... .100
686 INDEX